Mercury Villager II (1998-2002) blk/yel Wiring diagrams

2000 VILLAGER 2001 VILLAGER AMBIENT AIR TEMPERATURE SENSOR (ON FRONT CENTER OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COOLANT TEMPERATURE SENSOR 1 (ON TOP CENTER REAR OF ENGINE) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FRONT BLEND DOOR ACTUATOR (BEHIND RIGHT CENTER OF DASH, ON A/C-HEATER PLENUM) FRONT BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER PLENUM) FRONT BLOWER MOTOR RELAY FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) FUSE 26 FUSE 33 FUSE 36 FUSE 37 FUSE 39 FUSE 58 GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IB IA IF EQUIPPED W/ELECTRONIC INSTRUMENT CLUSTER IGNITION SWITCH ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (BEHIND CENTER OF DASH) INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN/RED WIRE NCA WIRE OFF ORG/ WIRE PNK ILLUMINATION WIRE PNK WIRE PNK/BLK WIRE REAR A/C CIRCUIT RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RUN WIRE SOLID STATE SOLID STATE 2 3 4 5 SUNLOAD SENSOR (ON TOP LEFT SIDE OF DASH) VIO WIRE WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

0.33 OHMS 0.62 OHMS 1.67 OHMS BLK WIRE BLK/YEL WIRE BLU WIRE BLU/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FUSE 37 FUSE 45 GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/BLK WIRE OFF PNK WIRE PNK/BLK WIRE PNK/BLU WIRE REAR BLOWER MOTOR (BEHIND PANEL, RIGHT REAR SIDE OF LUGGAGE COMPARTMENT) REAR BLOWER MOTOR RELAY (BEHIND CENTER OF DASH) REAR BLOWER MOTOR SWITCH (FRONT) REAR BLOWER MOTOR SWITCH (REAR) REAR OFF RED WIRE RED/BLK WIRE SOLID STATE YEL/BLK (OR BLK/YEL) WIRE YEL/BLK WIRE

ANALOG CLUSTER DIGITAL CLUSTER 1 2 BATTERY BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHARGE INDICATOR FUSE 37 FUSE 9 FUSE 28 GENERATOR HOT IN START OR RUN INSTRUMENT CLUSTER STARTER MOTOR WHT WIRE YEL/BLK WIRE YEL/BLU WIRE

BATTERY JUNCTION BOX (BJB) (ON LEFT FRONT OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) JOINT CONNECTOR BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT REAR OF ENGINE) ENGINE COOLING FAN MOTOR (BEHIND RADIATOR) FUSE 21 FUSE 25 FUSE 37 FUSE 5 HIGH SPEED FAN CONTROL RELAY 1 HIGH SPEED FAN CONTROL RELAY 2 HOT AT ALL TIMES HOT IN RUN OR START LOW SPEED FAN CONTROL RELAY LT GRN/RED WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) RED WIRE TOP OF ENGINE) WHT WIRE WHT/BLU WIRE

0.33 OHMS 0.62 OHMS 1.67 OHMS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FRONT CLIMATE CONTROL PANEL FUSE 37 FUSE 45 GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN WIRE OFF OFF REAR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE REAR BLOWER MOTOR (BEHIND PANEL, RIGHT REAR OF LUGGAGE COMPARTMENT) REAR BLOWER MOTOR RELAY (BEHIND CENTER OF DASH) REAR BLOWER MOTOR SWITCH (FRONT) REAR BLOWER MOTOR SWITCH (REAR) RED WIRE RED/BLK WIRE SOLID STATE YEL WIRE YEL/BLK (OR BLK/YEL) WIRE YEL/BLK WIRE YEL/RED WIRE

ANTI-THEFT RELAY BATTERY BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX JOINT CONNECTOR (IN BATTERY JUNCTION BOX) BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM ENGINE COMPARTMENT RELAY BOX (LEFT FRONT OF ENGINE COMPT) FUSE 23 FUSE 35 FUSE 4 GRN/RED WIRE GRN/WHT WIRE HOLD HOT AT ALL TIMES HOT IN START OR RUN IGNITION SWITCH INHIBIT RELAY LOCK LT GRN WIRE LT GRN/BLK WIRE OFF PULL RED WIRE RED/WHT WIRE RUN WIRE SMART ENTRY CONTROL/ TIMER MODULE (BEHIND TOP CENTER OF DASH) STARTER MOTOR TRANSMISSION RANGE (TR) SENSOR (TOP FRONT OF TRANSAXLE) WHT WIRE WHT/VIO WIRE

30 8 (1999, 2001) (2000) 33 1 (1999, 2001) (2000) BATTERY BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX JOINT CONNECTOR (IN BATTERY JUNCTION BOX) BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM ENGINE COMPARTMENT RELAY BOX (LEFT FRONT OF ENGINE COMPT) FUSE 23 FUSE 35 GRN/WHT WIRE HOT IN START OR RUN IGNITION SWITCH INHIBIT RELAY LOCK LT GRN WIRE LT GRN/BLK WIRE OFF PULL HOLD RED WIRE RED/WHT WIRE RUN WIRE STARTER MOTOR TRANSMISSION RANGE (TR) SENSOR (TOP FRONT OF TRANSAXLE) WHT WIRE WHT/VIO WIRE

14 15 16 17 PNK WIRE 16 7 17 6 5 15 14 TP SWITCH PCM WOT IN PCM PCM PCM PCM 17 15 18 8 TP IN TACH PSG TP REF AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CKP COOLING FANS SYSTEM CRUISE SONTROL SYSTEM DIAG CONN MIL GND ST SIG A/C HIGH PRESS TCM EGR TEMPERATURE SENSOR (ON UNDERSIDE OF THROTTLE BODY) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT REAR OF ENGINE) EVAP CANISTER PURGE VALVE (ON RIGHT SIDE OF ENGINE) FUEL SIGNAL FLOW TACH OUTPUT FUSE 38 FUSE 54 GND CMP SENSOR CMP SENSOR GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HI FAN RLY LO FAN RLY TCM HI FAN RLY TCM (TP) LO FAN RLY HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT FRONT OF ENG COMPT) FUSE 6 HOT IN START HOT IN START OR RUN IGN GND CMP SENSOR MAP/BARO INSTRUMENT CLUSTER SPEED LT GRN WIRE LT GRN/RED WIRE NCA WIRE OF DASH) ORG/ WIRE ORG/BLK WIRE PCM POWER RELAY (BEHIND RIGHT SIDE PNK 18 19 20 21 22 23 WIRE PNK PSP WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH) RED WIRE RED/GRN WIRE RED/WHT WIRE TCM FUEL PUMP/GAGE A/C HIGH PRESS GND FUEL PUMP RLY A/C RELAY THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY ASSEMBLY) THROTTLE POSITION SWITCH (ON THROTTLE BODY) TOP OF ENGINE) TP TCM TCM TP SWITCH VSS TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT PANEL) TRANSMISSION SYSTEM VIO WIRE WHT WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE WITH DRL YEL WIRE

1 8 (ELECTRONIC) (ANALOG) 14 15 16 17 PNK WIRE 20 2 (ELECTRONIC) (ANALOG) BATTERY JUNCTION BOX (ON LEFT FRONT OF ENG COMPT) BATTERY JUNCTION BOX J/C BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE CAMSHAFT POSITION (CMP) SENSOR CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DISTRIBUTOR (FRONT OF ENGINE) ENGINE COMPARTMENT RELAY BOX (ON LEFT FRONT OF ENG COMPT) EVAP PRESSURE SENSOR (CALIFORNIA) (UNDER CENTER REAR OF VEHICLE) FUEL PUMP MODULE (AT FUEL TANK) FUEL PUMP FUEL PUMP RELAY FUEL TEMP SENSOR FUSE 37 FUSE 2 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN IGNITION COIL IGNITION TRANSFORMER CAPACITOR IGNITION SWITCH INERTIA FUEL SHUT-OFF SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE KICK PANEL) INSTRUMENT CLUSTER MALFUNCTION INDICATOR LAMP "CHECK ENGINE" LT GRN WIRE LT GRN/RED WIRE NCA WIRE OFF ORG/ WIRE PNK 18 19 20 21 22 23 WIRE PNK WIRE POWER STEERING PRESSURE (PSP) POWER TRANSISTOR RED WIRE RED/YEL WIRE RESISTOR RUN WIRE SWITCH (RIGHT REAR OF ENG COMPT) TOP OF ENGINE) VIO WIRE WHT WIRE WHT/BLK WIRE WHT/VIO WIRE YEL WIRE

BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE CALIFORNIA ONLY DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DIAG CONN DIAG CONN EGR TEMP EVAP BYPASS EVAP VENT INJ 2 FEDERAL FUEL FUSE 3 FUSE 43 GND PCMR IN MAP/BARO GRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE HEATED OXYGEN HOT AT ALL TIMES HOT IN RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 36 HOT IN START OR RUN IDLE SPEED CONTROL (TOP REAR CENTER OF ENG) INJ 4 INJ 5 INJ 6 INJECTORS ISC ISC INJ 1 EGRV INJ 3 ISO BUS LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIRFLOW (MAF) SENSOR (ON LEFT SIDE OF ENGINE COMPT) NCA WIRE PCMR IN POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) RED WIRE RED/YEL WIRE TOP OF ENGINE) TP SIG RTN ECT FUEL TEMP IAT EVAP KS TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT CLUSTER) VIO WIRE WHT WIRE WHT/BLU WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE