Mercury Villager I (1992-1998) hot in start or run Wiring diagrams

4 8 (ANALOG) (ELECTRONIC) ALT FUSE BATTERY BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/YEL WIRE CHARGE WARNING INDICATOR ENGINE COMPARTMENT FUSE RELAY PANEL FUSE 29 FUSE LINK 1 FUSE LINK 2 GENERATOR, VOLTAGE REGULATOR GRY/BLU WIRE HOT IN START OR RUN I/P FUSE/ RELAY PANEL INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (BULB CHECK RELAY) JOINT CONNECTOR #2 (BEHIND TOP LEFT SIDE OF I/P) STARTER ASSEMBLY WHT WIRE YEL/BLK WIRE YEL/BLU WIRE

AUTOLAMP CTRL AUTOLAMP MODULE (BEHIND TOP RIGHT SIDE OF I/P) AUTOLAMP ON INPUT AUTOLAMP SENSOR (TOP RIGHT SIDE OF I/P, NEAR WINDSHIELD) BATTERY BLK WIRE BLU WIRE BLU/WHT WIRE COMBINATION SWITCH DELAYED EXIT INPUT DELAYED EXIT REHOSTAT OHM ENGINE COMPARTMENT FUSE/RELAY PANEL FLASH TO PASS GRN WIRE GRN/BLK WIRE GROUND GRY WIRE GRY/BLU WIRE GRY/RED WIRE H/L, L FUSE H/L, R FUSE HEAD PARK HEADLAMP CONTROL HEADLAMP SWITCH HI LO HIGH BEAM HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL FUSE 13 IGN INSTRUMENT CLUSTER INSTRUMENT PANEL DIMMER SWITCH J/C 1 (BEHIND LEFT SIDE OF I/P) LEFT HEADLAMP LO HI LT GRN WIRE LT GRN/RED WIRE OFF OFF HEAD HEAD PARK PARK OFF/ON CONTROL OHM ORG/ BLU WIRE ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE ORG/YEL WIRE PNK WIRE PNK/BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE REF CTRL RIGHT HEADLAMP SENSOR INPUT SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND CENTER OF I/P) W/ ANTI- THEFT W/ DRL W/ DRL ONLY W/O DRL W/O DRL W/ DRL WHT WIRE YEL WIRE

1 19 (ANALOG) (ELECTRONIC) AUTOLAMPS CIRCUIT BATTERY BLK WIRE BLU WIRE BLU/BLK WIRE BLU/YEL WIRE BRAKE WARNING INDICATOR COMBINATION SWITCH ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT FUSE/RELAY PANEL JUNCTION CONNECTOR #2 FLASH TO PASS FUSE 12 FUSE 30 GEN INPUT GENERATOR/ VOLTAGE REGULATOR (LOWER RIGHT FRONT OF ENGINE) GRN WIRE GRN/BLK WIRE GRY WIRE GRY/RED WIRE H/L, L FUSE H/L, R FUSE HEAD PARK HEADLAMP SWITCH HIGH BEAM HIGH BEAM INDICATOR HIGH BEAM ON IN HOT AT ALL TIMES HOT IN HOT IN START OR RUN I/P FUSE RELAY PANEL FUSE 29 I/P FUSE/ RELAY PANEL IGN INPUT INSTRU- MENT CLUSTER INSTRUMENT CLUSTER BULB CHECK RELAY J/C 2 (BEHIND LEFT SIDE OF I/P) LEFT HDLP CTRL LIGHTS ON INPUT LO HI LEFT HEADLAMP LO HI RIGHT HEADLAMP LT GRN WIRE LT GRN/RED WIRE OFF OFF HEAD PARK ORG YEL/ WIRE ORG/ BLU WIRE ORG/ WIRE ORG/BLU WIRE ORG/YEL WIRE PARK BK SW IN PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) PPL RED WIRE RED/BLK WIRE RED/BLU WIRE RED/YEL WIRE RIGHT HDLP CTRL START INPUT W/ AUTO LAMPS ONLY W/ AUTOLAMPS ONLY YEL WIRE YEL/PPL WIRE

2 POLE SPEED SENSOR 6 7 8 PNK WIRE AIR BAG AIR BAG DIAGNOSTIC MONITOR (BEHIND LEFT SIDE OF I/P) ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CHARGE WARNING IND COOLANT TEMP COOLANT TEMPERATURE SENDER CRUISE IND DOOR AJAR IND ENGINE COOLANT TEMP. GAUGE ENGINE OIL PRESSURE SWITCH ENGINE SPEED EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH, COMBINATION SWITCH) FUEL GAUGE FUEL GAUGE SENDER FUEL LEVEL ANTI- SLOSH MODULE FUEL PUMP MODULE FUSE 29 GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM (COMBINATION SWITCH) HI BEAM HOT IN START OR RUN I/P FUSE/ RELAY PANEL IGN ILLUM POWER ILLUM. DIM ILLUM. LAMPS IND IND. 56 OHMS INSTRUMENT CLUSTER J/C 1 (BEHIND TOP LEFT SIDE OF I/P, TAPED TO MAIN HARNESS) LEFT TURN IND LOW FUEL WARNING IND LOW OIL PRESS. IND. LOW WASHER FLUID IND MALFUNCTION IND NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLU WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SMART ENTRY CONTROL (SEC)/TIMER MODULE (BEHIND CENTER OF I/P) SPEED CONTROL MODULE (BELOW CENTER OF I/P, MOUNTED ON CENTER I/P BRACE SUPPORT) SPEEDOMETER TACHOMETER TRANSAXLE CONTROL MODULE (TCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) V REF VEHICLE SPEED IN VEHICLE SPEED OUT VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLU WIRE YEL/PPL WIRE YEL/RED WIRE

AIR BAG DIAGNOSTIC MONITOR (BEHIND LEFT SIDE OF I/P) AIR BAG IND ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CHARGE WARNING IND COMBINATION SWITCH COOLANT TEMPERATURE SENDER DIGITAL DISPLAY DOOR AJAR IND ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF I/P) ENGINE OIL PRESSURE SWITCH EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH) FUEL GAUGE SENDER FUEL PUMP FUSE 2 FUSE 29 GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HEADLIGHTS SYSTEM (COMBINATION SWITCH) HI-BEAM IND HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL IGN INSTRUMENT CLUSTER J/C 1 (BEHIND TOP LEFT SIDE OF I/P, TAPED TO MAIN HARNESS) LEFT TURN IND LOW FUEL WARNING IND LOW OIL LEVEL IND LOW OIL PRESS. IND. LOW WASHER FLUID IND MALFUNCTION IND MODULE (BELOW REAR OF VEHICLE, INSIDE FUEL TANK) NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE OUTSIDE AIR TEMPERATURE SENSOR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) PPL PPL/WHT WIRE PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SIDE OF I/P) SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND CENTER OF I/P) SPEED CONTROL MODULE (BELOW CENTER OF I/P, MOUNTED ON CENTER I/P BRACE SUPPORT) TRANSAXLE CONTROL MODULE (TCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/PPL WIRE YEL/RED WIRE

1/2 1/2 INPUT 3/4 INPUT 5/6 INPUT 7/8 INPUT 9/0 INPUT 3/4 5/6 7/8 9/0 ANTI-THEFT SYSTEM BLK WIRE BLU/ORG WIRE BRN/YEL WIRE DOOR OPEN IN DOOR OPEN IN DOOR OPEN IN ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 30 GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GROUND CHIME CONTROL ILLUMINATION OUTPUT PNK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN ACC OR RUN I/P FUSE/ RELAY PANEL FUSE 5 HOT IN START OR RUN IGNITION KEY SWITCH INLINE CIRCUIT BREAKER #1 (BEHIND LEFT SIDE OF I/P) INLINE CIRCUIT BREAKER #2 INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION) KEY-IN IGN INPUT GROUND KEYLESS ENTRY CHIME (IN REAR OF LEFT FRONT DOOR) KEYLESS ENTRY KEYPAD ASSEMBLY LEFT DOOR LOCK ACTUATOR ASSEMBLY LFTGATE OPEN IN LOCK/UNLOCK IN LOCK/UNLOCK IN LIFTGATE LATCH SWITCH ASSEMBLY LIFTGATE LOCK ACTUATOR ASSEMBLY LOCK LOCK UNLOCK LT GRN WIRE LT GRN/RED WIRE MASTER WINDOW/ DOOR LOCK SWITCH NCA WIRE OPEN LEFT DOOR JAMB SWITCH (LOWER FRONT OF LEFT "B" PILLAR) OPEN RIGHT DOOR JAMB SWITCH (LOWER FRONT OF RIGHT "B" PILLAR) OPEN SLIDING DOOR AJAR SWITCH (LOWER REAR OF RIGHT "B" PILLAR) ORG/ WIRE ORG/BLK WIRE P/W FUSE PNK WIRE POWER WINDOW RELAY RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT DOOR LOCK ACTUATOR ASSEMBLY RIGHT DOOR LOCK SWITCH SEC FUSE SLIDING DOOR CONTACT SWITCH SLIDING DOOR LOCK ACTUATOR SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND CENTER OF I/P) UNLOCK WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE YEL WIRE

BLK WIRE BLU WIRE CRUISE CONTROL SYSTEM FUSE 29 HOT IN START OR RUN I/P FUSE/ RELAY PANEL PARK POSITION SWITCH SHIFT LOCK SOLENOID SHIFT LOCK SOLENOID/PARK POSITION SWITCH SPEED CONTROL DISENGAGE SWITCH WHT WIRE

ANTI-THEFT RELAY BATTERY BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT FUSE/RELAY PANEL INHIBIT RELAY FUSE LINK 1 FUSE LINK 2 GRN WIRE HORN FUSE HOT IN START OR RUN I/P FUSE/RELAY PANEL FUSE 30 IGN FUSE ALT FUSE IGNITION SWITCH LOCK LT GRN WIRE NCA WIRE OFF PULL- IN RED WIRE RED/WHT WIRE RUN WIRE SMART ENTRY CONTROL (SEC)/TIMER MODULE (CENTER OF I/P) STARTER ASSEMBLY HOLD TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF ENGINE, ON FRONT OF TRANSAXLE) WHT WIRE WHT/PPL WIRE YEL WIRE

BATTERY BLK WIRE BLK/RED WIRE BLK/YEL WIRE ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT FUSE/RELAY PANEL INHIBIT RELAY FUSE 30 FUSE LINK 1 FUSE LINK 2 HOT IN START OR RUN I/P FUSE/ RELAY PANEL IGN FUSE IGNITION SWITCH LOCK LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF RED WIRE RED/WHT WIRE RUN WIRE STARTER ASSEMBLY HOLD PULL-IN TRANSMISSION RANGE (TR) SENSOR (LEFT SIDE OF ENGINE, ON FRONT OF TRANSAXLE) WHT WIRE WHT/PPL WIRE YEL WIRE

* PIN SHORTING BAR IS ENGAGED WHEN MODULE CONNECTOR IS DISCONNECTED 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 +/- 1995 VFTC AIR BAG DIAGNOSTIC MONITOR (BEHIND LEFT SIDE OF I/P) AIR BAG INDICATOR BLK WIRE BLU WIRE BLU/RED WIRE CLOCKSPRING ASSEMBLY DATA LINK CONNECTOR #2 (BEHIND LEFT SIDE OF I/P) DLC INTERFACE DOOR OPEN INPUT DRIVER'S AIR BAG DRIVER'S AIR BAG + LOCK DETECTION IN ENGINE CONTROLS SYSTEM FUSE 29 FUSE 3 GROUND HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL INDICATOR INSTRUMENT CLUSTER J/C 1 (BEHIND LEFT SIDE OF I/P) LEFT DOOR JAMB SWITCH NCA WIRE ORG/ WIRE PASS AIR BAG PASSENGER'S AIR BAG POWER INPUT RED WIRE RED/BLU WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE