Mercury Villager I (1992-1998) engine compartment fuse/relay panel Wiring diagrams

15 16 17 18 19 PPL A/C COMPRESSOR CLUTCH COIL A/C HIGH PRESSURE SWITCH (RIGHT FRONT OF ENGINE) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT, ON ACCUMULATOR) A/C RELAY ENGINE COMPARTMENT FUSE/RELAY PANEL AMBIENT AIR TEMPERATURE SENSOR (FRONT CENTER OF ENGINE COMPARTMENT) BLK WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CENTER ENGINE COMPARTMENT FUSE PANEL COLD ENGINE LOCKOUT COOLING FAN (LO) RELAY COOLING FAN MOTOR ENGINE COMPART- MENT FUSE/RELAY JUNCTION CONNECTOR 1 ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 24 FUSE 25 FUSE 29 GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF OFF REAR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (BEHIND GLOVE BOX) PPL RAD FUSE REAR BLEND DOOR ACTUATOR REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR BLOWER MOTOR RESISTOR ASSEMBLY (LEFT SIDE OF REAR PASSENGER AREA) REAR BLOWER MOTOR SWITCH (FRONT) REAR BLOWER MOTOR SWITCH (REAR) REAR BLOWER MOTOR SWITCH RELAY REAR ENGINE COOLANT VALVE SOLENOID (CENTER REAR OF ENGINE) REAR VENT DOOR ACTUATOR (LEFT SIDE OF PASSENGER AREA) RED/WHT WIRE STRUT TOWER) SUNLOAD SENSOR IN-CAR TEMPERATURE SENSOR (BEHIND ASHTRAY, IN I/P) TOP OF ENGINE) WHT WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 IGNITION A/C PRESS SWITCHES A/C COMPRESSOR CLUTCH COIL A/C HIGH PRESSURE SWITCH (RIGHT FRONT OF ENGINE) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT, ON ACCUMULATOR) A/C RELAY ENGINE COMPARTMENT FUSE/RELAY PANEL AUXILIARY A/C-HEATER CIRCUIT BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLW FUSE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CENTER ENGINE COMPARTMENT FUSE PANEL COOLING FAN (LO) RELAY COOLING FAN MOTOR ENGINE COMPART- MENT FUSE/ RELAY PANEL ENGINE COMPART- MENT FUSE/RELAY JUNCTION CONNECTOR 1 ENGINE COMPARTMENT FUSE/RELAY PANEL FRONT BLOWER MOTOR FRONT BLOWER MOTOR RELAY FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND RIGHT SIDE OF I/P, IN PLENUM) FRONT BLOWER MOTOR SWITCH FRONT CLIMATE CONTROL PANEL FUSE 13 FUSE 2 FUSE 28 FUSE 29 FUSE 31 GRN RED/ WIRE GRN WIRE GRN/YEL WIRE GROUND FRESH/RECIRC DR ACT GRY WIRE GRY/BLU WIRE GRY/RED WIRE HI MH ML LO HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL I/P FUSE/RELAY PANEL IGNITION SWITCH LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE MODE ACT SIG RETURN FRT BLOWER MTR CTRL FRESH/RECIRC DR ACT MODE ACTUATOR (BEHIND CENTER OF I/P) MODE ACTUATOR MODE ACTUATOR NCA WIRE ORG/ WIRE PNK WIRE PNK/BLK WIRE POSITION SWITCHES POWERTRAIN CONTROL MODULE (BEHIND GLOVE BOX) PPL PPL POWER RAD FUSE REAR BLW MTR SW GROUND RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RUN WIRE TOP OF ENGINE) WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL/BLK WIRE YEL/RED WIRE

1995 VFTC 2 20 (ANALOG) (ELECTRONIC) ABS FUSE ABS FUSE ANTI-LOCK WARNING INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (TOP OF BRAKE PEDAL SUPPORT) BRN WIRE DATA LINK CONNECTOR #2 (BEHIND LEFT SIDE OF I/P) ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 22 FUSE 29 FUSE 30 GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GROUND RT FNT SOL OUTPUT GROUND RT FNT WHEEL SPD SENS GRY/BLU WIRE HOT AT ALL TIMES HOT IN START OR RUN HYDRAULIC ACTUATOR ASSEMBLY (RIGHT FRONT OF ENGINE COMPARTMENT) I/P FUSE/RELAY PANEL INSTRUMENT CLUSTER L FNT WHEEL SPD SENS L FNT WHEEL SPD SENS L REAR WHEEL SPD SENS L REAR WHEEL SPD SENS GROUND RT FNT WHEEL SPD SENS LEFT FRONT LEFT FRONT WHEEL SPEED SENSOR LEFT REAR WHEEL SPEED SENSOR LT GRN WIRE MOTOR RELAY NCA WIRE ORG/ WIRE ORG/BLU WIRE PNK WIRE PPL PPL SOL RETURN PUMP MOTOR PUMP MTR (HYDRAULIC) REAR RED WIRE RIGHT FRONT RIGHT FRONT WHEEL SPEED SENSOR RIGHT REAR WHEEL SPEED SENSOR SOL RLY/MTR RLY REAR SOL OUTPUT SOLENOID RELAY WHT WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/RED WIRE

"ANTI-THEFT" INDICATOR 9 11 GROUND HORN CONTROL ANTI-THEFT RELAY AREA) BLK WIRE BLK/PNK WIRE BLU WIRE BLU/WHT WIRE BRN/YEL WIRE DOOR LOCKS SYSTEM ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT RELAY BOX FUSE 23 FUSE 30 GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM (AUTOLAMPS) HOOD SWITCH HORNS SYSTEM (HORN RELAY) HOT AT ALL TIMES HOT AT ALL TIMES INLINE CIRCUIT BREAKER #1 (BEHIND LEFT SIDE OF I/P) HOT IN ACC OR RUN HOT IN START OR RUN I/P FUSE/ RELAY PANEL FUSE 5 INTERIOR LIGHTS SYSTEM (DOOR JAMB SWITCHES) KEYLESS ENTRY KEYPAD ASSEMBLY KEYLESS ENTRY SYSTEM LEFT DOOR KEY LOCK SWITCH LEFT REAR LIFTGATE KEY LOCK SWITCH LIFTGATE LATCH SWITCH ASSEMBLY LIFTGATE LOCK ACTUATOR ASSEMBLY LOCK LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE PPL PPL PPL RED WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RIGHT DOOR KEY LOCK SWITCH SEC FUSE SLIDING DOOR CONTACT SWITCH SLIDING DOOR CONTROL UNIT (IN SLIDING DOOR) SLIDING DOOR KEY LOCK SWITCH SLIDING DOOR LOCK ACTUATOR (REAR OF SLIDING DOOR) SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND CENTER OF I/P) SOLID STATE STARTING SYSTEM (INHIBIT RELAY) TRANSMISSION RANGE (TR) SENSOR UNLOCK W/ FIXED GLASS W/ MOVABLE GLASS WHT WIRE WHT/RED WIRE YEL WIRE

ALL DOORS LOCK ALL DOORS UNLOCK KEYPAD ILLUMINATION INPUT ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM INSTRUMENT CLUSTER SYSTEM ANTI-THEFT SYSTEM POWER WINDOWS SYSTEM BLK WIRE BLK/PNK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BRN/YEL WIRE COURTESY LAMPS CONTROL COURTESY LAMPS CONTROL GROUND DOOR LOCK ACTUATORS OUTPUT DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM INTERIOR LIGHTS SYSTEM ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 30 GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/RED WIRE HEADLAMP SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM HORN RELAY GROUND PWR WINDOW RELAY GROUND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START I/P FUSE/ RELAY PANEL FUSE 5 INLINE CIRCUIT BREAKER #1 (BEHIND LEFT SIDE OF I/P) INLINE CIRCUIT BREAKER #2 INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE P/W FUSE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER MIRROR SWITCH POWER SUPPLY DRIVER UNLOCK SIGNAL GROUND BDY SIDE DR CONTACT ASSMLY POWER SUPPLY POWER SUPPLY POWER SUPPLY PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SEC FUSE SMART ENTRY CONTROL (SEC)/TIMER MODULE (BEHIND CENTER OF I/P) WARNING SYSTEMS DEFOGGER SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE YEL WIRE

AIR BAG DIAGNOSTIC MONITOR (BEHIND LEFT SIDE OF I/P) BLK WIRE BLK/RED WIRE BLU WIRE BLU/WHT WIRE DATA LINK CONNECTOR #1 (BEHIND LEFT SIDE OF I/P) DATA LINK CONNECTOR #2 (BEHIND LEFT SIDE OF I/P) DATA LINK CONNECTOR (ENGINE COMPARTMENT, NEAR BATTERY) DLC #1 DLC #2 DLC #2 DLC DLC #2 ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 29 GRN WIRE GRY/BLU WIRE HOT AT ALL TIMES ENG CONT FUSE HOT IN START OR RUN I/P FUSE/ RELAY PANEL POWERTRAIN CONTROL MODULE (PCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) RED WIRE TOP OF ENGINE) TRANSAXLE CONTROL MODULE (TCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) WHT WIRE WHT/GRN WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

ACTUATOR ACTUATOR SPD CONT ON/OFF SW SPEED CONT DIS SW ANALOG CLUSTER ANTI-THEFT RELAY BLK WIRE BLK/RED WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPORT) BRN WIRE BRN/YEL WIRE CLOCK- SPRING CRUISE INDICATOR ELECTRONIC CLUSTER ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT FUSE/RELAY PANEL INHIBIT RELAY ENGINE COMPARTMENT FUSE/RELAY PANEL JUNCTION CONNECTOR 1 ENGINE COMPT FUSE/ RELAY PANEL ENGINE COMPT FUSE/ RELAY PANEL HORN RELAY (COIL) FUSE FUSE 22 GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HORN FUSE HORNS SYSTEM HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE/ RELAY PANEL FUSE 30 INSTRUMENT CLUSTER JOINT CONNECTOR 1 LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OF STRUT TOWER) OHMS ON INDICATOR ON ON OFF OFF ORG/ WIRE PNK WIRE PNK/BLU WIRE RED WIRE RED/YEL WIRE RESUME/ ACCEL RING ASSEMBLY SHIFT LOCK SOLENOID PARK POSITION SWITCH SIDE OF I/P) SPEED CONT SW ASSM SPEED CONT SW ASSM SPEED CONTROL SPEED CONTROL ACTUATOR (RIGHT SIDE OF ENGINE, COMPARTMENT ON FRONT SPEED CONTROL DISENGAGE SWITCH (ON BRAKE PEDAL SUPPORT) SPEED CONTROL HOLD RELAY SPEED CONTROL MODULE (BELOW CENTER OF I/P) SPEED CONTROL ON/OFF SWITCH SPEED SIGNAL INPUT 3 3 (ANALOG) (ELECTRONIC) SWITCH ASSEMBLY SET/ COAST TAPED TO MAIN HARNESS) TRANSAXLE CONT MOD INST CLSTR/TCM ACTUATOR GROUND ACTUATOR TRANSAXLE CONTROL MODULE (TCM) (BEHIND RIGHT TRANSMISSION RANGE (TR) SENSOR (ON FRONT OF TRANSAXLE) VACUUM PUMP MOTOR VACUUM VENT SOLENOID SOLENOID VEHICLE SPEED SENSOR (VSS) (ON REAR OF TRANSAXLE) VEHICLE SPEED SIGNAL BRAKE ON/OFF SW W/ ANTI- THEFT W/O ANTI- THEFT WHT WIRE WHT/BLU WIRE YEL WIRE

BLK WIRE BLU WIRE DEF FUSE ENGINE COMPARTMENT FUSE/RELAY PANEL FUSE 14 FUSE 15 FUSE 16 GRN WIRE HOT AT ALL TIMES I/P FUSE/ RELAY PANEL IGNITION SWITCH ILLUM INDICATOR J/C 1 (BEHIND LEFT POWER/ HEATED MIRROR LIFTGATE DEFROST GRID LIFTGATE DEFROSTER RELAY NCA WIRE OFF ON/OFF SWITCH PNK WIRE REAR DEFOGGER SWITCH RED WIRE RIGHT POWER/ HEATED MIRROR RUN WIRE SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND CENTER OF I/P) WHT WIRE YEL/GRN WIRE

6 5 (ELECTRONIC) (ANALOG) A/C HIGH PRESSURE SWITCH A/C RELAY ACHPS GND FFS DLC BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (TOP RIGHT FRONT OF ENGINE) COOLING FAN RELAYS DATA LINK CONNECTOR (DLC) (LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) EGR TEMPERATURE (EGRT) SENSOR (ON UNDERSIDE OF THROTTLE BODY, AIR INTAKE) ENG CONT FUSE ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP RIGHT REAR OF ENGINE) GND CKPREF CKP GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START FUSE 12 HOT IN START OR RUN FUSE 4 I/P FUSE/ RELAY PANEL IGN GND CKPREF CKP INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (LEFT FRONT CORNER OF ENGINE COMPARTMENT) LO FAN RY ACR LT GRN WIRE LT GRN/RED WIRE MIL GND ST SIG HPS PNPS TP TCM PSP VSS TP SW IAT TCM TCM NCA WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) POWERTRAIN CONTROL MODULE (PCM) RELAY RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SPEED CONTROL MODULE SPEED SIGNAL OUTPUT TCM TCM (TP) THROTTLE POSITION (TP) SENSOR (TOP LEFT REAR OF ENGINE, ON THROTTLE BODY) THROTTLE POSITION (TP) SWITCH (TOP LEFT REAR OF ENGINE, ON THROTTLE BODY) TOP OF ENGINE) TRANSAXLE CONTROL MODULE TRANSAXLE CONTROL MODULE (TCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) W/ ELECTRONIC CLUSTER WHT WIRE WHT/BLK WIRE WHT/GRN WIRE WHT/PPL WIRE WHT/RED WIRE YEL/GRN WIRE

1995 VFTC 28 29 30 DLC DLC DLC 9 2 1 DATA LINK CONNECTOR (DLC) #2 (BEHIND LEFT SIDE OF I/P) BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/YEL WIRE BRN WIRE CMP KS DATA LINK CONNECTOR #1 (BEHIND LEFT SIDE OF I/P) DLC #1 DLC #2 DLC #2 DLC #2 EGRV- ENGINE COMPARTMENT FUSE/RELAY PANEL ENGINE COMPARTMENT RELAY BOX EXHAUST GAS RECIRCULATION (EGR) VALVE IDLE AIR CONTROL (IAC) VALVE #2 FRONT HEATED OXYGEN SENSOR FUEL INJECTORS GND PCMR IN GRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE HOT AT ALL TIMES IDLE AIR CONTROL (IAC) VALVE #1 IDLE AIR CONTROL VALVE RELAY INJ FUSE LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE MAF+ MAF- TP SIG RTN ECT MASS AIR FLOW (MAF) SENSOR (TOP LEFT SIDE OF ENGINE COMPARTMENT) NCA WIRE NO.1 NO.2 NO.3 NO.4 NO.5 NO.6 ORG/BLU WIRE PCMR IN PCMR IN EGRT POWERTRAIN CONTROL MODULE (PCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) PWR REAR HEATED OXYGEN SENSOR RED/BLK WIRE TOP OF ENGINE) TRANSAXLE CONTROL MODULE (TCM) (BEHIND TOP RIGHT SIDE OF I/P, BEHIND GLOVE BOX) WHT WIRE WHT/BLU WIRE WHT/PPL WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/PPL WIRE YEL/RED WIRE