Mercury Sable IV (1999-2005) (right rear side of engine compt) Wiring diagrams

1 3 6 13 15 16 24 27 37 38 49 50 51 53 54 55 64 71 76 77 79 81 84 89 SS B 2 10 13 DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) 90 91 92 103 REF VOLT SIG RETURN BPP GROUND BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 2 BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 22 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON SIDE OF BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CHECK TRANS INDICATOR LAMP DIGITAL TRANSMISSION RANGE SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON REAR OF ENGINE BLOCK) FUSE 17 FUSE 27 FUSE 28 GROUND SS C TCC B+ GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER, INTEGRATED CONTROL PANEL LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (ON TRANSAXLE) PCM RELAY PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOLENOIDS TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TOP OF ENGINE) TRANSAXLE TSS EEPROM SCP BUS- SCP BUS+ GROUND SS A TFT ECT TURBINE SHAFT SPEED (TSS) SENSOR (ON REAR SIDE OF TRANSAXLE) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 3 6 13 15 16 24 27 37 38 49 50 51 53 54 55 64 71 76 77 79 81 84 89 SS B 2 10 13 DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) 90 91 92 103 REF VOLT SIG RETURN BPP GROUND BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 2 BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 22 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON SIDE OF BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CHECK TRANS INDICATOR LAMP DIGITAL TRANSMISSION RANGE SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON REAR OF ENGINE BLOCK) FUSE 17 FUSE 27 FUSE 28 GROUND SS C TCC B+ GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER, INTEGRATED CONTROL PANEL LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (ON TRANSAXLE) PCM RELAY PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOLENOIDS TAN/ORG WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSAXLE TSS EEPROM SCP BUS- SCP BUS+ GROUND SS A TFT ECT TURBINE SHAFT SPEED (TSS) SENSOR (ON REAR SIDE OF TRANSAXLE) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

86 28 46 38 91 42 VREF BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DUAL PRESSURE SWITCH (BEHIND A/C COMPRESSOR) ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN MOTOR 1 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN MOTOR 2 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) FUSE 2 FUSE 25 FUSE 9 GRY/RED WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN START OR RUN LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE ORG/ WIRE PCM POWER RELAY RED WIRE RED/ORG WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) VREF SIG RTN WHT/LT BLU WIRE

4 6 VBATT GROUND AUTO- LAMP HEADLAMP RELAY AUTO- LAMP PARK RELAY BLK WIRE BLK/LT GRN WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN WIRE DOOR LOCK DOOR UNLOCK DRIVER SIDE DOOR LOCK SWITCH FUSE 11 FUSE 16 FUSE 26 FUSE 27 FUSE 29 FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY/RED WIRE HEADLIGHTS SYSTEM HORN RELAY HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INTERIOR LIGHTS SYSTEM (AT BASE OF LEFT "A" PILLAR) LEFT FRONT DOOR AJAR SWITCH LEFT LOCK CYLINDER SWITCH LEFT REAR DOOR AJAR SWITCH LIFTGATE AJAR SWITCH (WAGON) LIFTGATE GLASS AJAR SWITCH LIFTGATE LOCK CYLINDER SWITCH LOCK LOCK/UNLOCK LT BLU/BLK WIRE LT GRN/YEL WIRE LUGGAGE COMPARTMENT ANTI-THEFT SWITCH (SEDAN) NCA WIRE PASSENGER SIDE DOOR LOCK SWITCH PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE PULSE STRETCHER MODULE (WAGON) (IN LIFTGATE) RIGHT FRONT DOOR AJAR SWITCH RIGHT LOCK CYLINDER SWITCH RIGHT REAR DOOR AJAR SWITCH ANTI- THEFT HOOD SWITCH TAN/LT GRN WIRE UNLOCK WAGON WHT/RED WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/LT GRN WIRE

3.0L 24-VALVE 3.0L 24-VALVE W/O FLEX FUEL ABS AIR BAG IND ANTI- SLOSH MODULE ANTI- THEFT "ON" IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) CHARGE IND CHECK ENGINE IND CHECK FUEL CAP IND CONN A CONN B CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR AJAR IND ENGINE COOLANT TEMPERATURE GAUGE EXC ABS EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FLEX FUEL FLEXIBLE FUEL SENSOR MODULE (BEHIND CENTER OF DASH, NEAR INSTRUMENT CLUSTER) FUEL GAUGE FUEL GAUGE SENSOR FUEL TANK UNIT FUSE 16 FUSE 27 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LEFT TURN IND LOW BRAKE FLUID LEVEL/PARK BRAKE IND LOW COOLANT LEVEL IND LOW FUEL IND LOW OIL LEVEL IND LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MOUNTED ABOVE PARKING BRAKE PEDAL) NCA WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE PARKING BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SAFETY BELT IND SPEED CONTROL IND SPEED CONTROL SERVO (IN LEFT REAR OF ENGINE COMPT) SPEED- OMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM EXTERIOR LIGHTS SYSTEM TACHOMETER TAN/YEL WIRE TRACTION CONTROL IND TRANSAXLE IND W/O FLEX FUEL WARNING SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

1/2 21 20 DOOR UNLOCK RLY DOOR LOCK RLY 3/4 4 6 BATT GND 5/6 7/8 9/0 BLK WIRE BLK/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DK BLU/YEL WIRE DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER DOOR UNLOCK RELAY DRIVER DOOR UNLOCK RLY DRIVER SIDE DOOR LOCK SWITCH FUSE 16 FUSE 22 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) HOT AT ALL TIMES KEY PAD ILLUM KEY PAD IN KEY PAD SWITCH ASSEMBLY LEFT FRONT DOOR LOCK ACTUATOR LEFT REAR DOOR LOCK ACTUATOR LIFTGATE LOCK ACTUATOR (WAGON) LIFTGATE OR TRUNK LID UNLOCK RLY CTRL DOOR UNLOCK SW DOOR LOCK SW 26 6 18 LIFTGATE UNLOCK RELAY (WAGON) LOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE PASSENGER SIDE DOOR LOCK SWITCH PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/WHT WIRE RELAY CENTER BOX 2 (UNDER LEFT SIDE OF DASH) RIGHT FRONT DOOR LOCK ACTUATOR RIGHT REAR DOOR LOCK ACTUATOR UNLOCK WHT/RED WIRE YEL WIRE YEL/LT GRN WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR FFV FUEL GAUGE SENSOR FUEL SENDER (ON FUEL TANK) FUEL TANK UNIT FUSE 16 FUSE 27 GAS GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ON FRONT OF INTAKE MANIFOLD) ENGINE COOLANT TEMPERATURE SENSOR FUEL SENDER (ON FUEL TANK) FUSE 16 FUSE 27 GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION INDICATOR LAMP MASS AIRFLOW SENSOR (IN AIR INTAKE ASSEMBLY) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER STEERING PRESSURE SENSOR (ON TOP LEFT REAR SIDE OF ENGINE) RED WIRE RED/BLK WIRE SPEEDOMETER TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE