Mercury Sable IV (1999-2005) red/yel Wiring diagrams

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LEFT REAR WHEEL SPEED SENSOR (IN LEFT REAR WHEELWELL, MOUNTED ON BRAKE ASSEMBLY) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE REAR RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE SOLID STATE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: YEL/BLK WIRE YEL/RED WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS MODULE ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU/WHT WIRE DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL TRACTION CONTROL SW TRACTION CONTROL OFF GRY WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION TRACTION IND CONTROL ILLUM- INATION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ON OFF ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE REAR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: TRACTION CONTROL TRACTION CONTROL OFF TRACTION CONTROL SWITCH INTERIOR LIGHTS SYSTEM WHT/PNK WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 SUNLOAD SENSOR AUTOLAMP RELAY AUTOLAMP HEADLAMP RELAY AUTOLAMP ON AUTOLAMP ON/OFF SIGNAL AUTOLAMP RELAY AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 19 BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DASH) DAYTIME RUNNING LAMPS (DRL) RELAY DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRL RELAY FOG LAMP RELAY FOG LAMPS FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 24 FUSE 27 FUSE 29 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRN WIRE GROUND GRY WIRE HEAD HEAD PARK OFF HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LO HI LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK BRAKE SWITCH PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) RIGHT HEADLAMP RUN WIRE SUNLOAD SENSOR TAN WIRE TO PASS LO VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 SUNLOAD SENSOR AUTOLAMP RELAY AUTOLAMP HEADLAMP RELAY AUTOLAMP ON AUTOLAMP ON/OFF SIGNAL AUTOLAMP RELAY AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 19 BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE FOG LAMP RELAY FOG LAMPS FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 24 FUSE 27 FUSE 29 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND HEAD HEAD PARK OFF HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LO HI LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) RIGHT HEADLAMP SUNLOAD SENSOR TAN WIRE TO PASS LO VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE

A/C DEMAND SIG BLOWER RLY CTRL SENSOR SIGNAL RTN AMBIENT AIR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF FRONT BUMPER) AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK GRN/WHT WIRE DUAL PRESSURE SWITCH (BEHIND A/C COMPRESSOR) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH, BELOW GLOVE BOX) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH, NEAR HVAC UNIT) FUSE 16 FUSE 28 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) HIGH PRESSURE HOT AT ALL TIMES HOT IN RUN IN-VEHICLE TEMPERATURE SENSOR INTEGRATED CONTROL PANEL (ICP) (BEHIND DASH, NEAR A/C-HEATER CONTROL UNIT) LOW CHARGE PROTECTION SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT) LT BLU/PNK WIRE NORMAL PRESSURE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) SOLID STATE TAN WIRE TAN/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND INSTRUMENT CLUSTER, UNDER DASH PANEL) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) 1 2 3 4 5 6 7 8 9 10 CRUISE ON IND ACCEL SET/ AIR BAG SLIDING CONTACT BLK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) COAST DEACTIVATOR SWITCH (BEHIND LOWER SIDE OF BRAKE PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRIC CLUTCH PWR GND FUSE FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY WIRE GRY/BLK WIRE HORN HORN RELAY HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LT GRN WIRE NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE PILLAR) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REST RESUME RUN WIRE SHIFT INTERLOCK, ENGINE CONTROLS, ANTI-LOCK BRAKES, EXTERIOR LIGHTS SYSTEMS SPEED CONTROL IND SPEED CONTROL SERVO (IN LEFT REAR OF ENGINE COMPT) STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/ORG WIRE VSS (+) BRAKE APPLIED IN VREF SIG RTN VPWR VSS OUTPUT WHT WIRE YEL WIRE

AUTOLAMP ON BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS (DRL) RELAY DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRL RELAY FOG LAMPS (NOT USED) FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 27 FUSE 29 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRN WIRE GROUND GRY WIRE HEAD HEAD PARK OFF (NOT USED) AUTOLAMP ON HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER LEFT HEADLAMP LO HI LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK BRAKE SWITCH PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) RIGHT HEADLAMP RUN WIRE TO PASS LO VIO WIRE VIO/LT BLU WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE YEL WIRE

BLK WIRE BLOWER MOTOR RELAY BRN WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH, BELOW GLOVE BOX) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (IN DASH, BELOW CENTER OF GLOVE BOX) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 28 FUSE 32 FUSE 8 GRN WIRE HOT AT ALL TIMES HOT IN RUN INTEGRATED CONTROL PANEL LOW CHARGE PROTECTION SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT) LOW HIGH LT GRN WIRE LT LT MED 2 MED 1 OFF FLOOR/VENT VENT FLOOR NORM MIX DEF MAX OFF FLOOR/VENT VENT FLOOR NORM MIX MAX DEF ORG/ WIRE PNK WIRE RED WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR VIO WIRE WHT WIRE YEL WIRE

A/C CLUTCH RELAY A/C CLUTCH SOLENOID BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE BLU WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DUAL PRESSURE SWITCH (BEHIND A/C COMPRESSOR) ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN MOTOR 1 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN MOTOR 2 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) FUSE 22 FUSE 25 FUSE 28 FUSE 9 GRY/RED WIRE HIGH PRESSURE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN START OR RUN LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE NORMAL PRESSURE ORG/ WIRE PCM POWER RELAY PNK WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) TAN WIRE TAN/ORG WIRE WHT/LT BLU WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR FFV FUEL GAUGE SENSOR FUEL SENDER (ON FUEL TANK) FUEL TANK UNIT FUSE 16 FUSE 27 GAS GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE