Mercury Sable IV (1999-2005) pnk/lt blu Wiring diagrams

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS MODULE ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU/WHT WIRE DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL TRACTION CONTROL SW TRACTION CONTROL OFF GRY WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION TRACTION IND CONTROL ILLUM- INATION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ON OFF ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE REAR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: TRACTION CONTROL TRACTION CONTROL OFF TRACTION CONTROL SWITCH INTERIOR LIGHTS SYSTEM WHT/PNK WIRE YEL/BLK WIRE YEL/RED WIRE

A/C DEMAND SIG BLOWER RLY CTRL SENSOR SIGNAL RTN AMBIENT AIR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF FRONT BUMPER) AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK GRN/WHT WIRE DUAL PRESSURE SWITCH (BEHIND A/C COMPRESSOR) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH, BELOW GLOVE BOX) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH, NEAR HVAC UNIT) FUSE 16 FUSE 28 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) HIGH PRESSURE HOT AT ALL TIMES HOT IN RUN IN-VEHICLE TEMPERATURE SENSOR INTEGRATED CONTROL PANEL (ICP) (BEHIND DASH, NEAR A/C-HEATER CONTROL UNIT) LOW CHARGE PROTECTION SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT) LT BLU/PNK WIRE NORMAL PRESSURE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) SOLID STATE TAN WIRE TAN/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND INSTRUMENT CLUSTER, UNDER DASH PANEL) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE

15 16 28 41 46 69 86 38 91 42 66 SCP - SCP + A/C CLUTCH RELAY A/C CLUTCH SOLENOID BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN MOTOR 1 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN MOTOR 2 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) FUSE 22 FUSE 25 FUSE 28 FUSE 2 GRN WIRE GRY WIRE GRY/RED WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN START OR RUN INTEGRATED CONTROL PANEL (ICP) LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT BLU/PNK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE OR RUN ORG/ WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE SIG RTN TAN WIRE TAN/ORG WIRE WHT WIRE WHT/LT BLU WIRE

1 2 3 4 5 6 LOW COOLANT LVL SW BRAKE IND CTRL VSS + B+ 218 680 AUTOLAMP RLY CTRL WIPER/WASHER DELAY IN 871 547 SAFETY BELT IND CTRL BRAKE IND CTRL BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM DEFOGGER SYSTEM DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DOOR LOCKS SYSTEM FUSE 11 FUSE 16 FUSE 27 FUSE 38 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM POWER WINDOWS SYSTEM HEADLIGHTS SYSTEM WIPER/WASHER SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START HOT IN START OR RUN INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM POWER WINDOWS SYSTEM WIPER/WASHER SYSTEM KEY PAD ILLUMINATION KEY WARNING SW IN KEYLESS ENTRY W/O ANTI- THEFT LIFTGATE UNLOCK RLY CTRL LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER WINDOWS SYSTEM RED WIRE TAN/LT GRN WIRE TRUNK, TAILGATE, FUEL DOORS SYSTEM VIO/LT BLU WIRE VIO/ORG WIRE WARNING SYSTEM WARNING SYSTEM INSTRUMENT CLUSTER SYSTEM WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) HOT AT ALL TIMES LT BLU/WHT WIRE LT GRN/RED WIRE PNK/LT BLU WIRE RESTRAINTS CONTROL MODULE (UNDER CENTER OF DASH) SCP BUS (+) TAN/ORG WIRE VIO WIRE W/ TRACTION CONTROL YEL WIRE

4 6 VBATT GROUND AUTO- LAMP HEADLAMP RELAY AUTO- LAMP PARK RELAY BLK WIRE BLK/LT GRN WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN WIRE DOOR LOCK DOOR UNLOCK DRIVER SIDE DOOR LOCK SWITCH FUSE 11 FUSE 16 FUSE 26 FUSE 27 FUSE 29 FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY/RED WIRE HEADLIGHTS SYSTEM HORN RELAY HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INTERIOR LIGHTS SYSTEM (AT BASE OF LEFT "A" PILLAR) LEFT FRONT DOOR AJAR SWITCH LEFT LOCK CYLINDER SWITCH LEFT REAR DOOR AJAR SWITCH LIFTGATE AJAR SWITCH (WAGON) LIFTGATE GLASS AJAR SWITCH LIFTGATE LOCK CYLINDER SWITCH LOCK LOCK/UNLOCK LT BLU/BLK WIRE LT GRN/YEL WIRE LUGGAGE COMPARTMENT ANTI-THEFT SWITCH (SEDAN) NCA WIRE PASSENGER SIDE DOOR LOCK SWITCH PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE PULSE STRETCHER MODULE (WAGON) (IN LIFTGATE) RIGHT FRONT DOOR AJAR SWITCH RIGHT LOCK CYLINDER SWITCH RIGHT REAR DOOR AJAR SWITCH ANTI- THEFT HOOD SWITCH TAN/LT GRN WIRE UNLOCK WAGON WHT/RED WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/LT GRN WIRE

A/C SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CHARGING SYSTEM COOLING FANS SYSTEM DIGITAL TRANS- MISSION RANGE (DTR) SENSOR DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (RIGHT SIDE OF INTAKE MANIFOLD) FFV FUEL PUMP (ON FRONT SIDE OF FUEL TANK) FUEL PUMP RELAY FUEL SENDER MOD PROGRAMMING FUSE 16 FUSE 2 FUSE 37 GAS GENERATOR CKP POS SENS + CKP POS SENS - GROUND GROUND IGN COIL A SHIFT SOL A LOW SPD FAN RLY GROUND IGN COIL B SHIFT SOL C GRY WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGNITION COIL (LEFT REAR OF ENGINE) IGNITION TRANSFORMER CAPACITOR (ATTACHED TO IGNITION COIL) INERTIA FUEL SHUT-OFF SWITCH (IN CARGO AREA, BEHIND RIGHT WHEELWELL) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE MAF SENS TFT SENS ECT SENS IAT SENS FUEL PUMP MOD DUAL PRESS SW FAN RLY CTRL NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PASSIVE ANTI-THEFT TRANSCEIVER MODULE (NEAR IGNITION SWITCH) PCM POWER RELAY PNK STARTER RLY GENERATOR HIGH SPD FAN RLY EVR TACH WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT, IN FIREWALL) RED WIRE RED/BLK WIRE SCP BUS (-) SCP BUS (+) RX, SIGNAL TX, SIGNAL SIGNAL RTN STARTING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE THEFT IND TO DTR SENSOR (DIAGRAM 4 OF 4) TO SPARK PLUGS TOP OF ENGINE) TSS VIO WIRE VIO/ORG WIRE VOLTAGE AT START WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR FFV FUEL GAUGE SENSOR FUEL SENDER (ON FUEL TANK) FUEL TANK UNIT FUSE 16 FUSE 27 GAS GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

A/C CLUTCH RELAY A/C SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF DASH, BEHIND RADIATOR) BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UPPER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHARGING SYSTEM DK BLU/ORG WIRE DK BLU/YEL WIRE DPFE SENS SENSOR INPUT CANISTER VENT VSS SENS A/C CLUTCH RLY FROM DTR SENSOR (DIAGRAM 1 OF 4) FTP SENS IPS SENSOR INPUT FUEL INJECTORS FUSE 122 FUSE 17 FUSE 28 GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR 11 (REAR OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 12 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 1) HEATED OXYGEN SENSOR 21 (FRONT OF ENGINE COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR 22 (UNDER VEHICLE, DOWNSTREAM FROM CATALYTIC CONVERTER 2) HOT AT ALL TIMES IND CTRL FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS VREF SIGNAL RETURN BPP SW NCA WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (IGN) POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT, IN FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/YEL WIRE TOP OF ENGINE) VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

A/C SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CKP POS SENS - CKP POS SENS + COOLING FANS SYSTEM DIGITAL TRANS- MISSION RANGE (DTR) SENSOR DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUEL PUMP (ON FRONT SIDE OF FUEL TANK) FUEL PUMP RELAY FUEL SENDER MOD PROGRAMMING FUSE 16 FUSE 2 FUSE 37 GROUND GROUND IGN COIL A SHIFT SOL A LOW SPD FAN RLY GROUND IGN COIL B SHIFT SOL C GRY WIRE GRY/RED WIRE HIGH SPD FAN RLY EGR TACH HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGNITION COIL (LEFT REAR OF ENGINE) IGNITION TRANSFORMER CAPACITOR (ATTACHED TO IGNITION COIL) INERTIA FUEL SHUT-OFF SWITCH (IN CARGO AREA, BEHIND RIGHT WHEELWELL) LT BLU WIRE LT BLU/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE MAF SENS TFT SENS ECT SENS IAT SENS DRIVER INPUT DUAL PRESS SW FAN RLY CTRL NCA WIRE ORG DK GRN/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PASSIVE ANTI-THEFT TRANSCEIVER MODULE (NEAR IGNITION SWITCH) PCM POWER RELAY PNK STARTER RLY WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT, IN FIREWALL) RED WIRE RED/BLK WIRE SCP BUS (-) SCP BUS (+) RX, SIGNAL TX, SIGNAL STARTING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE THEFT IND PSP SWITCH KNOCK SENS TO DTR SENSOR (DIAGRAM 4 OF 4) TO SPARK PLUGS TSS SENS VIO WIRE VIO/ORG WIRE VOLTAGE AT START WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE