Mercury Sable IV (1999-2005) gry Wiring diagrams

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS MODULE ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU/WHT WIRE DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL TRACTION CONTROL SW TRACTION CONTROL OFF GRY WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION TRACTION IND CONTROL ILLUM- INATION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ON OFF ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE REAR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: TRACTION CONTROL TRACTION CONTROL OFF TRACTION CONTROL SWITCH INTERIOR LIGHTS SYSTEM WHT/PNK WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 SUNLOAD SENSOR AUTOLAMP RELAY AUTOLAMP HEADLAMP RELAY AUTOLAMP ON AUTOLAMP ON/OFF SIGNAL AUTOLAMP RELAY AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 19 BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DASH) DAYTIME RUNNING LAMPS (DRL) RELAY DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRL RELAY FOG LAMP RELAY FOG LAMPS FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 24 FUSE 27 FUSE 29 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRN WIRE GROUND GRY WIRE HEAD HEAD PARK OFF HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LO HI LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK BRAKE SWITCH PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) RIGHT HEADLAMP RUN WIRE SUNLOAD SENSOR TAN WIRE TO PASS LO VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE

15 16 28 41 46 69 86 38 91 42 66 SCP - SCP + A/C CLUTCH RELAY A/C CLUTCH SOLENOID BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN MOTOR 1 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN MOTOR 2 (IN FRONT OF ENGINE COMPT, BEHIND RADIATOR) ENGINE COOLING FAN RELAY ENGINE COOLING FAN RESISTOR (NEAR ELECTRIC COOLING FANS) FUSE 22 FUSE 25 FUSE 28 FUSE 2 GRN WIRE GRY WIRE GRY/RED WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN START OR RUN INTEGRATED CONTROL PANEL (ICP) LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT BLU/PNK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE OR RUN ORG/ WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE SIG RTN TAN WIRE TAN/ORG WIRE WHT WIRE WHT/LT BLU WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) 1 2 3 4 5 6 7 8 9 10 CRUISE ON IND ACCEL SET/ AIR BAG SLIDING CONTACT BLK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) COAST DEACTIVATOR SWITCH (BEHIND LOWER SIDE OF BRAKE PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRIC CLUTCH PWR GND FUSE FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY WIRE GRY/BLK WIRE HORN HORN RELAY HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LT GRN WIRE NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE PILLAR) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REST RESUME RUN WIRE SHIFT INTERLOCK, ENGINE CONTROLS, ANTI-LOCK BRAKES, EXTERIOR LIGHTS SYSTEMS SPEED CONTROL IND SPEED CONTROL SERVO (IN LEFT REAR OF ENGINE COMPT) STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/ORG WIRE VSS (+) BRAKE APPLIED IN VREF SIG RTN VPWR VSS OUTPUT WHT WIRE YEL WIRE

3.0L 24-VALVE A/C CLUTCH SOLENOID ABS CONTROL MODULE AIR BAG SLIDING CONTACT ANTI-THEFT HOOD SWITCH BATTERY BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH DK GRN WIRE DRIVER SIDE DOOR LOCK SWITCH DRIVER SIDE EXTERIOR REAR VIEW MIRROR DUAL PRESSURE SWITCH ENGINE COOLANT TEMPERATURE (ECT) SENDER ENGINE COOLING FAN BRAKE RELAY ENGINE COOLING FAN MOTOR 1 EXTERIOR REAR VIEW MIRROR SWITCH FUEL PUMP RELAY GENERIC ELECTRONIC MODULE (GEM) GRY WIRE HIGH MOUNTED STOPLAMP HIGH SPEED FAN CONTROL RELAY HORN INSTRUMENT CLUSTER KEY PAD SWITCH ASSEMBLY KEYLESS ENTRY W/O ANTI- THEFT LEFT FRONT DOOR AJAR SWITCH LEFT FRONT PARK/ TURN LAMP LEFT FRONT FOG LAMP LEFT LOCK CYLINDER SWITCH LEFT REAR DOOR AJAR SWITCH LEFT REVERSING LAMP LIFTGATE GLASS AJAR SWITCH LOW COOLANT LEVEL SWITCH LT BLU WIRE LT GRN WIRE LUGGAGE COMPARTMENT LID RELEASE SWITCH POWER ANTENNA MODULE MASS AIR FLOW (MAF SENSOR) MASTER WINDOW ADJUST SWITCH HIGH MOUNTED STOPLAMP NCA WIRE NON-SPEED CONTROL JUMPER ORG/ WIRE PARKING BRAKE SWITCH PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) REAR WINDOW DEFROST RELAY 2 RED WIRE RESTRAINTS CONTROL MODULE RIGHT FRONT PARK/ TURN LAMP DAYTIME RUNNING LAMPS RESISTOR RIGHT REVERSING LAMP LIFTGATE AJAR SWITCH RIGHT SAFETY BELT ASSEMBLY SEDAN SEDAN SE SEDAN W/ KEYLESS ENTRY SHIELD SPEED CONTROL SERVO W/ ABS W/ ANTI- THEFT W/ KEYLESS ENTRY W/ POWER LOCKS W/ SPEED CONTROL W/O ABS W/O SPEED CONTROL WAGON WHT WIRE WIND- SHIELD WIPER MOTOR WINDSHIELD WASHER PUMP MOTOR RIGHT FRONT FOG LAMP YEL WIRE

AUTOLAMP ON BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS (DRL) RELAY DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRL RELAY FOG LAMPS (NOT USED) FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 27 FUSE 29 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRN WIRE GROUND GRY WIRE HEAD HEAD PARK OFF (NOT USED) AUTOLAMP ON HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER LEFT HEADLAMP LO HI LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK BRAKE SWITCH PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) RIGHT HEADLAMP RUN WIRE TO PASS LO VIO WIRE VIO/LT BLU WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE YEL WIRE

A/C SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CHARGING SYSTEM COOLING FANS SYSTEM DIGITAL TRANS- MISSION RANGE (DTR) SENSOR DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (RIGHT SIDE OF INTAKE MANIFOLD) FFV FUEL PUMP (ON FRONT SIDE OF FUEL TANK) FUEL PUMP RELAY FUEL SENDER MOD PROGRAMMING FUSE 16 FUSE 2 FUSE 37 GAS GENERATOR CKP POS SENS + CKP POS SENS - GROUND GROUND IGN COIL A SHIFT SOL A LOW SPD FAN RLY GROUND IGN COIL B SHIFT SOL C GRY WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGNITION COIL (LEFT REAR OF ENGINE) IGNITION TRANSFORMER CAPACITOR (ATTACHED TO IGNITION COIL) INERTIA FUEL SHUT-OFF SWITCH (IN CARGO AREA, BEHIND RIGHT WHEELWELL) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE MAF SENS TFT SENS ECT SENS IAT SENS FUEL PUMP MOD DUAL PRESS SW FAN RLY CTRL NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PASSIVE ANTI-THEFT TRANSCEIVER MODULE (NEAR IGNITION SWITCH) PCM POWER RELAY PNK STARTER RLY GENERATOR HIGH SPD FAN RLY EVR TACH WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT, IN FIREWALL) RED WIRE RED/BLK WIRE SCP BUS (-) SCP BUS (+) RX, SIGNAL TX, SIGNAL SIGNAL RTN STARTING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE THEFT IND TO DTR SENSOR (DIAGRAM 4 OF 4) TO SPARK PLUGS TOP OF ENGINE) TSS VIO WIRE VIO/ORG WIRE VOLTAGE AT START WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR FFV FUEL GAUGE SENSOR FUEL SENDER (ON FUEL TANK) FUEL TANK UNIT FUSE 16 FUSE 27 GAS GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

A/C SYSTEM BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 25 CKP POS SENS - CKP POS SENS + COOLING FANS SYSTEM DIGITAL TRANS- MISSION RANGE (DTR) SENSOR DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON TOP OF TRANSMISSION HOUSING) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUEL PUMP (ON FRONT SIDE OF FUEL TANK) FUEL PUMP RELAY FUEL SENDER MOD PROGRAMMING FUSE 16 FUSE 2 FUSE 37 GROUND GROUND IGN COIL A SHIFT SOL A LOW SPD FAN RLY GROUND IGN COIL B SHIFT SOL C GRY WIRE GRY/RED WIRE HIGH SPD FAN RLY EGR TACH HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGNITION COIL (LEFT REAR OF ENGINE) IGNITION TRANSFORMER CAPACITOR (ATTACHED TO IGNITION COIL) INERTIA FUEL SHUT-OFF SWITCH (IN CARGO AREA, BEHIND RIGHT WHEELWELL) LT BLU WIRE LT BLU/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE MAF SENS TFT SENS ECT SENS IAT SENS DRIVER INPUT DUAL PRESS SW FAN RLY CTRL NCA WIRE ORG DK GRN/ WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PASSIVE ANTI-THEFT TRANSCEIVER MODULE (NEAR IGNITION SWITCH) PCM POWER RELAY PNK STARTER RLY WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR CORNER OF ENGINE COMPT, IN FIREWALL) RED WIRE RED/BLK WIRE SCP BUS (-) SCP BUS (+) RX, SIGNAL TX, SIGNAL STARTING SYSTEM TAN/LT BLU WIRE TAN/ORG WIRE TAN/RED WIRE TAN/YEL WIRE THEFT IND PSP SWITCH KNOCK SENS TO DTR SENSOR (DIAGRAM 4 OF 4) TO SPARK PLUGS TSS SENS VIO WIRE VIO/ORG WIRE VOLTAGE AT START WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ON FRONT OF INTAKE MANIFOLD) ENGINE COOLANT TEMPERATURE SENSOR FUEL SENDER (ON FUEL TANK) FUSE 16 FUSE 27 GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION INDICATOR LAMP MASS AIRFLOW SENSOR (IN AIR INTAKE ASSEMBLY) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER STEERING PRESSURE SENSOR (ON TOP LEFT REAR SIDE OF ENGINE) RED WIRE RED/BLK WIRE SPEEDOMETER TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE