Mercury Sable IV (1999-2005) fuse 27 Wiring diagrams

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LEFT REAR WHEEL SPEED SENSOR (IN LEFT REAR WHEELWELL, MOUNTED ON BRAKE ASSEMBLY) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE REAR RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE SOLID STATE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: YEL/BLK WIRE YEL/RED WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT, BELOW BATTERY) ABS INDICATOR ABS MODULE ABS PUMP MOTOR BATTERY JUNCTION BOX (BJB) (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU/WHT WIRE DK GRN WIRE FRONT FUSE 13 FUSE 15 FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND BRAKE FLUID LEVEL TRACTION CONTROL SW TRACTION CONTROL OFF GRY WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN IGNITION TRACTION IND CONTROL ILLUM- INATION INSTRUMENT CLUSTER LEFT DUMP VALVES LEFT ISO VALVES LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ON OFF ORG/ WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE REAR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RELAY BOX RIGHT DUMP VALVES RIGHT ISO VALVES RR WHEEL SENSOR RR WHEEL SENSOR RF WHEEL SENSOR RF WHEEL SENSOR BPP SWITCH RUN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE THERE IS A SHORTING BAR ACROSS PINS 15&16 NOTE: TRACTION CONTROL TRACTION CONTROL OFF TRACTION CONTROL SWITCH INTERIOR LIGHTS SYSTEM WHT/PNK WIRE YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 SUNLOAD SENSOR AUTOLAMP RELAY AUTOLAMP HEADLAMP RELAY AUTOLAMP ON AUTOLAMP ON/OFF SIGNAL AUTOLAMP RELAY AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 19 BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DASH) DAYTIME RUNNING LAMPS (DRL) RELAY DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRL RELAY FOG LAMP RELAY FOG LAMPS FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 24 FUSE 27 FUSE 29 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRN WIRE GROUND GRY WIRE HEAD HEAD PARK OFF HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LO HI LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK BRAKE SWITCH PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) RIGHT HEADLAMP RUN WIRE SUNLOAD SENSOR TAN WIRE TO PASS LO VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 SUNLOAD SENSOR AUTOLAMP RELAY AUTOLAMP HEADLAMP RELAY AUTOLAMP ON AUTOLAMP ON/OFF SIGNAL AUTOLAMP RELAY AUTOLAMP SENSOR (IN DASH, ABOVE GLOVE BOX) BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPT, BEHIND RADIATOR) FUSE 19 BLK WIRE BLK/LT GRN WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE FOG LAMP RELAY FOG LAMPS FOG LAMPS ON IND FUSE 11 FUSE 16 FUSE 21 FUSE 24 FUSE 27 FUSE 29 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND HEAD HEAD PARK OFF HI LO HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LO HI LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH (FLASH TO PASS) OFF ORG/ WIRE PARK OFF POWER, HOT W/ HIGH BEAMS ON RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) REMOTE CLIMATE CONTROL (RCC) MODULE (BEHIND CENTER OF DASH, NEAR GLOVE BOX) RIGHT HEADLAMP SUNLOAD SENSOR TAN WIRE TO PASS LO VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 LOW COOLANT LVL SW BRAKE IND CTRL VSS + B+ 218 680 AUTOLAMP RLY CTRL WIPER/WASHER DELAY IN 871 547 SAFETY BELT IND CTRL BRAKE IND CTRL BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM DEFOGGER SYSTEM DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DOOR LOCKS SYSTEM FUSE 11 FUSE 16 FUSE 27 FUSE 38 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GROUND GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM POWER WINDOWS SYSTEM HEADLIGHTS SYSTEM WIPER/WASHER SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START HOT IN START OR RUN INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM POWER WINDOWS SYSTEM WIPER/WASHER SYSTEM KEY PAD ILLUMINATION KEY WARNING SW IN KEYLESS ENTRY W/O ANTI- THEFT LIFTGATE UNLOCK RLY CTRL LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWER WINDOWS SYSTEM RED WIRE TAN/LT GRN WIRE TRUNK, TAILGATE, FUEL DOORS SYSTEM VIO/LT BLU WIRE VIO/ORG WIRE WARNING SYSTEM WARNING SYSTEM INSTRUMENT CLUSTER SYSTEM WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE

1 2 (SEDAN) (WAGON) 1 2 (WAGON) (SEDAN) 1 2 3 4 5 6 7 8 9 10 CRUISE ON IND ACCEL SET/ AIR BAG SLIDING CONTACT BLK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (UNDER DASH, UPPER FRONT SIDE OF BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (UNDER LEFT SIDE OF DASH) COAST DEACTIVATOR SWITCH (BEHIND LOWER SIDE OF BRAKE PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRIC CLUTCH PWR GND FUSE FUSE 17 FUSE 27 FUSE 32 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY WIRE GRY/BLK WIRE HORN HORN RELAY HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LT GRN WIRE NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE PILLAR) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REST RESUME RUN WIRE SHIFT INTERLOCK, ENGINE CONTROLS, ANTI-LOCK BRAKES, EXTERIOR LIGHTS SYSTEMS SPEED CONTROL IND SPEED CONTROL SERVO (IN LEFT REAR OF ENGINE COMPT) STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/ORG WIRE VSS (+) BRAKE APPLIED IN VREF SIG RTN VPWR VSS OUTPUT WHT WIRE YEL WIRE

AUTO A/C BATTERY JUNCTION BOX (FRONT CENTER OF ENGINE COMPARTMENT, BEHIND RADIATOR) BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DRIVER SIDE EXTERIOR REAR VIEW MIRROR FUSE 11 FUSE 12 FUSE 27 FUSE 32 FUSE 7 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN START OR RUN INTEGRATED CONTROL PANEL LT BLU WIRE LT GRN WIRE MANUAL A/C ON INDICATOR ORG/ WIRE PASSENGER SIDE EXTERIOR REAR VIEW MIRROR REAR WINDOW DEFROST GRID REAR WINDOW DEFROST RELAY 1 REAR WINDOW DEFROST RELAY 2 REAR WINDOW DEFROST SWITCH RELAY CENTER BOX 1 (UNDER LEFT SIDE OF DASH) RUN WIRE SEDAN SOLID STATE VIO WIRE WAGON WHT WIRE YEL WIRE

4 6 VBATT GROUND AUTO- LAMP HEADLAMP RELAY AUTO- LAMP PARK RELAY BLK WIRE BLK/LT GRN WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN WIRE DOOR LOCK DOOR UNLOCK DRIVER SIDE DOOR LOCK SWITCH FUSE 11 FUSE 16 FUSE 26 FUSE 27 FUSE 29 FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (UNDER LEFT SIDE OF DASH) GRY/RED WIRE HEADLIGHTS SYSTEM HORN RELAY HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INTERIOR LIGHTS SYSTEM (AT BASE OF LEFT "A" PILLAR) LEFT FRONT DOOR AJAR SWITCH LEFT LOCK CYLINDER SWITCH LEFT REAR DOOR AJAR SWITCH LIFTGATE AJAR SWITCH (WAGON) LIFTGATE GLASS AJAR SWITCH LIFTGATE LOCK CYLINDER SWITCH LOCK LOCK/UNLOCK LT BLU/BLK WIRE LT GRN/YEL WIRE LUGGAGE COMPARTMENT ANTI-THEFT SWITCH (SEDAN) NCA WIRE PASSENGER SIDE DOOR LOCK SWITCH PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE PULSE STRETCHER MODULE (WAGON) (IN LIFTGATE) RIGHT FRONT DOOR AJAR SWITCH RIGHT LOCK CYLINDER SWITCH RIGHT REAR DOOR AJAR SWITCH ANTI- THEFT HOOD SWITCH TAN/LT GRN WIRE UNLOCK WAGON WHT/RED WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/LT GRN WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR FFV FUEL GAUGE SENSOR FUEL SENDER (ON FUEL TANK) FUEL TANK UNIT FUSE 16 FUSE 27 GAS GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP MASS AIRFLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE SPEEDOMETER TACHOMETER TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

15 PNK/ WIRE A/C SYSTEM ANTI- SLOSH MODULE ANTI-LOCK BRAKES SYSTEM ANTI-THEFT ``ON" INDICATOR BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHECK FUEL CAP INDICATOR CHECK TRANSAXLE INDICATOR CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DATA LINK CONNECTOR (DLC) (MOUNTED ON DASH, BELOW STEERING COLUMN) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (ON FRONT OF INTAKE MANIFOLD) ENGINE COOLANT TEMPERATURE SENSOR FUEL SENDER (ON FUEL TANK) FUSE 16 FUSE 27 GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE MAL- FUNCTION INDICATOR LAMP MASS AIRFLOW SENSOR (IN AIR INTAKE ASSEMBLY) NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER STEERING PRESSURE SENSOR (ON TOP LEFT REAR SIDE OF ENGINE) RED WIRE RED/BLK WIRE SPEEDOMETER TACH TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE