Mercury Sable III (1995-1999) hot in start or run Wiring diagrams

9 1 2 LOW COOLANT IND CTRL SEAT BELT IND CTRL DOOR AJAR IND CTRL AIR BAG IND ANTI- SLOSH MODULE ANTI- THEFT IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE IND CHECK ENGINE IND CONN A CONN B CONN C CRUISE CONTROL SYSTEM CRUISE ON IND D/2 D/2 RIGHT TURN IND DAYTIME RUNNING LAMPS (DRL) JUMPER (BELOW LEFT HEADLAMP) DAYTIME RUNNING LAMPS (DRL) MODULE (BELOW LEFT HEADLAMP) DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DOOR AJAR IND ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENDER (NEAR THERMOSTAT) ENGINE OIL PRESSURE SWITCH (LEFT TOP REAR CORNER OF ENG BLOCK) EXTERIOR LIGHTS EXTERIOR LIGHTS SYSTEM (BACKUP LAMPS) FUEL FUEL GAUGE FUEL PUMP/ FUEL GAUGE SENDER (IN FUEL TANK) FUSE 12 FUSE 11 FUSE 24 FUSE 6 GENERATOR/ BATTERY IND GENERIC ELECTRONIC MODULE (GEM) (ATTACHED TO THE UNDERSIDE OF I/P FUSE PANEL) GENERIC ELECTRONIC MODULE (ON I/P FUSE PNL) GND IGNITION SWITCH GRY WIRE GRY/BLK WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN I/P FUSE PANEL I/P FUSE PANEL FUSE 5 INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (PULSE WIDTH DIMMING MODULE) LEFT FRONT FENDER) LEFT TURN IND LOW COOLANT IND LOW FUEL IND LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE OFF LOCK OIL PRESSURE IND ORG/ WIRE ORG/LT BLU WIRE PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PNK WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT, MOUNTED IN COWL) PPL/ORG WIRE PRNDL/TRANSMISSION CONTROL ILLUMINATION (IN CENTER CONSOLE) RED/WHT WIRE RED/YEL WIRE RUN WIRE SEAT BELT IND SEMI-ACTIVE RIDE CONTROL (SARC) MODULE (BEHIND RIGHT REAR SEAT) SHO ONLY SIX BACK LIGHT ILLUM IND DIMMING CONTROL SPEED CONTROL MODULE (LEFT OF MASTER CYLINDER) SPEED- OMETER STARTING/ CHARGING SUPPLEMENTAL RESTRAINT SYSTEM TACH TACHOMETER TAN/YEL WIRE TCIL TCIL IND TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VEHICLE SPEED SENSOR (ON TRAS) VSS W/ DRL W/O DRL BRAKE FLUID LEVEL SWITCH (RIGHT OF MASTER CYLINDER) WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

ABS IND CTRL ISO LINK ABS MODULE FUSE ANTI-LOCK BRAKE CONTROL MODULE (LEFT FRONT OF ENG COMPT, BELOW BATTERY) ANTI-LOCK BRAKE INDICATOR BLK WIRE BLK/WHT WIRE BOO BRAKE ON/OFF (BOO) SWITCH (UPPER FRONT SIDE OF BRAKE PEDAL) COMPUTER DATA LINES DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK GRN WIRE ENGINE COMPARTMENT FUSE/RELAY BOX FUSE 12 FUSE 28 FUSE 9 HOT AT ALL TIMES HOT IN START OR RUN HYDRAULIC PUMP MOTOR I/P FUSE PANEL IGN INLET INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT BRAKE SENSOR (IN LEFT FRONT WHEEL WELL, ON BRAKE ASSEMBLY) LEFT FRONT FENDER) LEFT REAR LEFT REAR BRAKE SENSOR (IN LEFT REAR WHEEL WELL, ON BRAKE ASSEMBLY) LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/YEL WIRE OUTLET PNK/BLK WIRE PUMP MOTOR RELAY RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RF WHL SENS LO RIGHT FRONT RIGHT FRONT BRAKE SENSOR (IN RIGHT FRONT WHEEL WELL, ON BRAKE ASSEMBLY) RIGHT REAR RIGHT REAR BRAKE SENSOR (IN RIGHT REAR WHEEL WELL, ON BRAKE ASSEMBLY) RR WHL SENS HI SHORTING BAR (SHORTS PINS 21, 22 WHEN DISCONNECTED) SOLENOID CONTROL VALVES RELAY SOLID STATE TAN/BLK WIRE TAN/ORG WIRE TAN/RED WIRE YEL/BLK WIRE YEL/RED WIRE

14 25 GND GND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE FUSE 12 FUSE 23 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) (ATTACHED TO THE UNDERSIDE OF I/P FUSE PANEL) GRY/BLK WIRE GRY/BRN WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN HOT IN START OR RUN I/P FUSE PANEL INSTRUMENT CLUSTER LEFT FRONT FENDER) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENG COMPT, IN COWL) PPL/YEL WIRE PWR (BAT) PWR (START) VSS PWR (START/RUN) RED/YEL WIRE SPEED CONTROL MODULE (LEFT OF MASTER CYLINDER) (ON LEFT KICK PANEL) VAPS CTRL VARIABLE ASSIST POWER STEERING (VAPS) ACTUATOR (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR CENTER OF ENGINE COMPT. ON TRANSAXLE) VSS IN

1 2 3 4 5 6 7 8 HI BEAM IND OUT BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (RIGHT OF MASTER CYLINDER) BRAKE IND DAYTIME RUNNING LAMPS (DRL) MODULE (BELOW LEFT HEADLAMP) DAYTIME RUNNING LAMPS FUSE DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN/ORG WIRE ENGINE COMPARTMENT FUSE/RELAY BOX FUSE 12 FUSE 3 FUSE 4 FUSE 6 GRY/WHT WIRE HEAD HEADLAMP SWITCH HEADLAMPS FUSE (AUTO) HI LOW FTP HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN I/P FUSE PANEL I/P FUSE PANEL FUSE 30 IGNITION SWITCH INSTRUMENT CLUSTER LEFT HEADLAMP LOW FTP LT BLU/BLK WIRE LT GRN WIRE LT GRN/YEL WIRE MULTI- FUNCTION SWITCH OFF OFF LOCK ORG/ WIRE PARK PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/YEL WIRE RIGHT HEADLAMP RUN WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID EVAP CANP VALVE FPM EPC SOL TCC IAC TSS SENS CMP SENS A/C PRES FTP SENS FUEL INJ 5 FUEL INJ 3 FUEL INJ 1 PWR GND PWR GND IGN COIL C FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (BACK OF ENG) HEATED OXYGEN SENSOR #12 (LOWER LEFT SIDE OF ENG) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) FUSE 28 INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON AIR INTAKE ASSEMBLY) LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE) VPWR VSS WAC RLY OUT EAM RELAY VPWR WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/PNK WIRE CHECK ENGINE INDICATOR TACHO- METER CKP FEED CKP RTN CONSTANT CONTROL RELAY MODULE (ON LEFT SIDE OF BATTERY, BEHIND HEADLAMP) COOLING FANS SYSTEM CRANK- SHAFT POSITION SENSOR SHIELD DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX FUEL PUMP FUSE FUEL PUMP RELAY FUEL SENDER DLC PPL FUSE 10 GRY WIRE GRY/RED WIRE HEDF RLY CTRL EVR TACH HEGO POWER FUSE HORN FUSE HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) IGNITION COIL IMRC INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM KAPWR LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE MAF RTN TFT ECT IAT FPM ACCS IMRC NCA WIRE OCTANE ADJUST PLUG (RIGHT REAR OF ENG COMPT, NEAR PCM) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL/ORG WIRE PWR GND GND IGN COIL A SS #1 EDF RLY CTRL TCS OCT ADJ PSP PWR GND IGN COIL B SS #3 RED WIRE RED/BLK WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO SPARK PLUGS TRANSMISSIONS SYSTEM WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM BLK/WHT WIRE BLK/YEL WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENGINE COOLANT TEMPERATURE SENSOR EVAP CANP VALVE FTP SENS FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 12 FUSE 28 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSOR #11 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATED OXYGEN SENSOR #21 (REAR OF ENG COMPT, ON EXHAUST MANIFOLD) HEATER CTRL HOT AT ALL TIMES HOT IN START OR RUN I/P FUSE PANEL (BELOW LEFT SIDE OF I/P) INSTRUMENT CLUSTER SYSTEM LEFT FRONT FENDER) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS TP SENS REF VOLT SIG RTN BOO NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE PPL/LT GRN WIRE PPL/ORG WIRE PPL/WHT WIRE PPL/YEL WIRE PWR GND RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 SHIFT SOLENOID 3 TAN WIRE TAN/BLK WIRE TAN/YEL WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TR SENS DPFE SENS TRANSAXLE (TOP CENTER OF TRANSAXLE) TRANSMISSION FLUID TEMPER- ATURE SENSOR TRANSMISSION RANGE SENSOR (TOP OF TRANSAXLE HOUSING) VPWR WAC RLY OUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE