Mercury Sable III (1995-1999) hot in run or start Wiring diagrams

13 10 2 DATA LINK CONNECTOR (CENTER OF DASH) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLU WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/WHT WIRE CHECK ENGINE IND LAMP COLUMN SHIFT TO STARTING SYSTEM BACKUP LAMPS CONSOLE SHIFT CONSOLE SHIFT ONLY) CONSTANT CONTROL RELAY MODULE (LEFT SIDE OF BATTERY) DK BLU/WHT WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRL MODULE EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX ENGINE CONTROLS FUSE 12 FUSE 28 FUSE 6 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE PANEL FUSE 10 IGNITION COIL, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER INSTRUMENT CLUSTER, GEM, FLEX FUEL MODULE INSTRUMENT ILLUMINATION LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (NEAR ENGINE AIR INTAKE ASSEMBLY) NCA WIRE NEAR INJ 6) OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PRNDL/TRANSMISSION CONTROL ILLUMINATION RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT ONLY) SHIFT SOLENOID 2 SHIFT SOLENOID 3 SPEED CONTROL DEACTIVATE SWITCH SPEED CONTROL MODULE, A/C SYSTEM TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (AT TOP RIGHT SIDE OF ENGINE, BEHIND INTAKE) TRANS RANGE (TR) SENSOR (LEFT SIDE OF TRANS- AXLE) TRANSAXLE TRANSMISSION CONTROL SWITCH (TCS) VEHICLE SPEED SENSOR (VSS) (REAR CENTER OF ENGINE COMPT, MOUNTED ON TRANSAXLE) WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE

13 10 2 DATA LINK CONNECTOR (DLC) (CENTER OF DASH) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLU WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/WHT WIRE CHECK ENGINE IND LAMP COLUMN SHIFT BACKUP LAMPS CONSOLE SHIFT CONSOLE SHIFT ONLY) CONSTANT CONTROL RELAY MODULE (LEFT SIDE OF BATTERY) DK BLU/WHT WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRL MODULE EEEC POWER FUSE EEEC RELAY ENGINE COMPARTMENT FUSE/RELAY BOX ENGINE CONTROLS FUSE 12 FUSE 28 FUSE 6 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE PANEL FUSE 10 IGNITION COIL, RADIO CAPACITOR, PATS MODULE INSTRUMENT CLUSTER INSTRUMENT CLUSTER, GEM, LIGHT SENSOR/ AMPLIFIER INSTRUMENT ILLUMINATION LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE MASS AIR FLOW (MAF) SENSOR (IN ENGINE AIR INTAKE ASSEMBLY) NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL/ORG WIRE PRNDL/TRANS. CONTROL ILLUM. PRNDL/TRANSMISSION CONTROL ILLUMINATION RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT ONLY) SHIFT SOLENOID 2 SHIFT SOLENOID 3 SPEED CONTROL DEACTIVATE SWITCH SPEED CONTROL MODULE, A/C SYSTEM TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (AT TOP REAR OF ENGINE, BEHIND INTAKE MANIFOLD) TO STARTING SYSTEM TRANSAXLE TRANSCMISSION CTRL IND LAMP TRANSMISSION CONTROL SWITCH (TCS) VEHICLE SPEED SENSOR (VSS) (REAR CENTER OF ENGINE COMPT, MOUNTED ON TRANSAXLE) WHT WIRE WHT/BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/YEL WIRE YEL WIRE

"ANTI-THEFT" INDICATOR 1/2 15 16 BUS (-) BUS (+) 7/8 5/6 3/4 8 1 2 ILLUM ENTRY REQ ALL DOOR UNLOCK RAP INPUT 9/0 AIR BAG DIAGNOSTIC MONITOR (BEHIND CONTROL PANEL) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DATA LINK DATA LINK CONNECTOR (PARTIAL) (BELOW STEERING COL) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DOOR LOCKS SYSTEM EXTERIOR LAMPS SYSTEM (BACKUP LAMPS CIRCUIT) EXTERIOR LAMPS SYSTEM (BRAKE ON/OFF SWITCH) FUSE 10 FUSE 20 FUSE 23 GEM IN B/U LAMPS (PWR) GEM INPUT GEM INPUT POWER/BATTERY RKE JUMPER GND KEYPAD LAMP ANTI-THEFT LED GENERIC ELECTRONIC MODULE (ATTACHED TO I/P FUSE PANEL) HEADLAMPS SYSTEM (W/ AUTOLAMPS) HOOD TAMPER SWITCH (LEFT FRONT CORNER OF ENGINE COMPT.) HORN RLY HORNS SYSTEM HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START I/P FUSE PANEL (LEFT SIDE OF I/P) INSTRUMENT CLUSTER ISO LINK KEYLESS ENTRY KEYPAD SWITCH ASSEMBLY KEYPAD 1/2 SIG KEYPAD 3/4 SIG KEYPAD 7/8 SIG KEYPAD 9/0 SIG UNLOCK INPUT KEYPAD 5/6 SG LOCK INPUT KEYPAD COMON LEFT FRONT FENDER) LIFTGATE RELEASE RELAY (RIGHT OF STEERING COLUMN) LOCK INPUT LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN/RED WIRE NCA WIRE PASSIVE ANTI-THEFT SYSTEM (BEHIND INTEGRATED CONTROL PANEL) PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER (NEAR IGNITION SWITCH) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR CORNER OF ENGINE COMPT) PPL/LT BLU WIRE RED WIRE RED/BLK WIRE RED/LT GRN WIRE SEDAN TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TRUNK LID ANTI-THEFT SWITCH (REAR OF CARGO AREA) TRUNK LID RELEASE RELAY (RIGHT OF STEERING COLUMN) TRUNK LID RELEASE SWITCH TRUNK/HOOD SW RKE JUMPER IGN (RUN) HAZ/BRAKE LAMPS TRUNK/LIFTGATE AUTOLAMP W/ KEYLESS ENTRY ONLY WAGON WHT WIRE WHT/PPL WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 HI BEAM IND OUT 1 2 3 4 5 PWR (START/RUN) ON/OFF IN AUTOLAMP RLY PWR (BAT) TIME DELAY IN AUTOLAMP HEADLAMP RELAY (IN ENGINE COMPARTMENT FUSE/RELAY BOX) AUTOLAMP ON IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (RIGHT OF MASTER CYLINDER) BRAKE IND BRN WIRE DAYTIME RUNNING LAMPS (DRL) MODULE (BELOW LEFT HEADLAMP) DELAY DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENGINE COMPARTMENT FUSE/RELAY BOX EXTERIOR LIGHTS SYSTEM (AUTOLAMP PARK RELAY) FUSE 12 FUSE 18 FUSE 22 FUSE 3 FUSE 4 FUSE 6 FUSE 2 GRY/WHT WIRE HEAD HEADLAMP SWITCH HEADLAMP SWITCH ILLUM HEADLAMPS FUSE (AUTO) HI LOW FTP HIGH BEAM IND HOT AT ALL TIMES HOT AT ALL TIMES DAYTIME RUNNING LAMPS FUSE HOT IN ACC OR RUN HOT IN RUN HOT IN RUN OR START I/P FUSE PANEL I/P FUSE PANEL FUSE 30 IGNITION SWITCH OFF LOCK INSTRUMENT CLUSTER LEFT HEADLAMP LIGHT SENSOR/AMPLIFIER (RIGHT SIDE OF I/P VENT, NEAR WINDSHIELD) LOW FTP LT BLU RED/ WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/YEL WIRE MULTI- FUNCTION SWITCH OFF OFF HEAD ORG/ WIRE PARK PARK LAMP FUSE PARKING BRAKE SWITCH (ABOVE BRAKE PEDAL) PPL PPL/LT BLU WIRE PPL/ORG WIRE PULSE WIDTH DIMMING MODULE RED WIRE RED/YEL WIRE RIGHT HEADLAMP RUN WIRE SOLID STATE WHT WIRE WHT/PPL WIRE

1 2 3 4 5 PWR (START/RUN) ON/OFF IN AUTOLAMP RLY PWR (BAT) TIME DELAY IN ALL OTHERS AUTOLAMP HEADLAMP RELAY (IN ENGINE COMPART- MENT FUSE/ RELAY BOX) AUTOLAMP ON IND BLK WIRE BRN WIRE DAYTIME RUNNING LAMP (DRL) JUMPER (BELOW LEFT HEADLAMP) DELAY DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENGINE COMPARTMENT FUSE/RELAY BOX EXTERIOR LIGHTS SYSTEM (AUTOLAMP PARK RELAY) FUSE 12 FUSE 18 FUSE 22 FUSE 3 FUSE 4 GRY/WHT WIRE HEAD OFF HEADLAMP SWITCH HEADLAMP SWITCH ILLUM HI LOW FTP HIGH BEAM IND HOT AT ALL TIMES HOT AT ALL TIMES HEADLAMPS FUSE (AUTO) HOT AT ALL TIMES PARK LAMP FUSE HOT IN ACC OR RUN HOT IN RUN OR START I/P FUSE PANEL FUSE 2 I/P FUSE PANEL FUSE 30 INSTRUMENT CLUSTER LEFT HEADLAMP LIGHT SENSOR/AMPLIFIER (RIGHT SIDE OF I/P VENT, NEAR WINDSHIELD) LOW HI FTP LT BLU RED/ WIRE LT BLU/RED WIRE LT GRN WIRE MULTI- FUNCTION SWITCH OFF OFF HEAD ORG/ WIRE PARK PPL PPL/LT BLU (OR GRY/WHT) WIRE PPL/LT BLU WIRE PPL/ORG WIRE PULSE WIDTH DIMMING MODULE RED WIRE RED/YEL WIRE RIGHT HEADLAMP SOLID STATE TAURUS W/ ABS WHT WIRE WHT/PPL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 VAPS CTRL VAPS CTRL 158 1010 464 70 WARNING SYSTEM DEFOGGER SYSTEM WARNING SYSTEM 871 627 680 684 INSTRUMENT CLUSTER SYSTEM ACCESSORY DELAY RELAY ANTI-THEFT OUT BATTERY SAVER RELAY BATTERY SAVER RELAY CONTROL BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DELAY DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DOOR LOCK IN DOOR UNLOCK IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY DRIVER'S UNLOCK RELAY CTRL ELECTRONIC POWER STEERING SYSTEM FUSE 12 FUSE 2 FUSE 20 FUSE 23 FUSE 8 GEM GEM CHIME/ TONE LOGIC GENERIC ELECTRONIC MODULE (ATTACHED TO I/P FUSE PANEL) GND PWR GND SIG GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE HEAD HEADLAMP SWITCH HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN HOT IN RUN OR START I/P FUSE PANEL (LEFT SIDE OF I/P) IGN (RUN/ACC) IGN (START) INTERIOR LAMP RELAY INTERIOR LAMP RELAY CTRL INTERIOR LIGHTS, WARNING SYSTEMS (DOOR AJAR SWITCHES) KEY WARNING SW IN REAR DEFROST SW IN LOW COOLANT IND CTRL DATA LINK LEFT FRONT FENDER) LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/YEL WIRE MOTOR SENSE HI MOTOR SWITCH DOWN COMMAND MOTOR LOW SENSE OFF OFF HEAD ONE TOUCH WINDOW DOWN RELAY ORG/ WIRE ORG/RED WIRE PARK PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE POWER (RUN/START) HEADLAMP SW IN WIPER/WASHER SIG RTN POWER WINDOWS SYSTEM PPL/YEL WIRE REAR WINDOW DEFROST RELAY REAR WINDOW DEFROST RELAY CTRL RED WIRE RED/YEL WIRE RELAY CTRL REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND INTEGRATED CONTROL PANEL) SEATBELT IND CTRL DOOR AJAR IND CTRL INTV DELAY/WASH WIPER MODE SELECT SHUNT RESISTOR TAN WIRE TAN/RED WIRE VEHICLE SPEED SENSOR (REAR CENTER OF ENGINE COMPT. ON TRANSAXLE) VSS IN WARNING SYSTEM WASHER RELAY WIPER HI/LO RELAY WIPER R/P RELAY LOW COOLANT WHT WIRE WHT/PPL WIRE WINDOW SWITCH UP COMMAND WIPER PARK SENSE GND (SIG) WIPER/WASHER SYSTEM YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 CASSETTE RIGHT (+) CASSETTE RIGHT (-) 17 2 3 4 5 18 7 20 6 19 1 15 16 FUSED IGNITION AUDIO SYTEM ON 434 1002 640 694 INTERIOR LIGHTS SYSTEM 59 503 504 MIRRORS SYSTEM AIR CONDITIONING SYSTEM ANTENNA BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CELLULAR PHONE DEFOGGER SYSTEM DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN/ORG WIRE DK GRN/PPL WIRE ENGINE COMPARTMENT FUSE/RELAY BOX (FRONT CENTER OF ENGINE COMPT) FUSE 12 FUSE 17 FUSE 20 FUSE 24 FUSE 8 GROUND GROUND GROUND POWER GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE HEATED BACKLITE HEATED MIRROR CASSETTE LEFT (+) CASSETTE LEFT (-) HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START I/P FUSE PANEL (UNDER LEFT CORNER OF DASH) INTEGRATED CONTROL PANEL LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LEFT FRONT DOOR SAIL SPEAKER LEFT SIG IN LEFT SIG OUT LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MEMORY SEEK ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWER POWER ANTENNA PPL PROTOCOL A PROTOCOL A CD LEFT (+) CD RIGHT (+) SHIELD PPL PROTOCOL A PROTOCOL B PROTOCOL B REAR CONTROL UNIT (LEFT REAR SIDE OF CARGO AREA) RED/BLK WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT DOOR SAIL SPEAKER RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RIGHT SIG IN RIGHT SIG OUT SHIELD SHIELD CASSETTE RIGHT (+) CASSETTE RIGHT (-) CASSETTE LEFT (+) CASSETTE LEFT (-) SHIELD PROTOCOL B AUDIO SYSTEM ON CELLULAR PHONE TAN WIRE TAN/YEL WIRE WHT/LT GRN WIRE WHT/PNK WIRE

434 1002 640 694 INTERIOR LIGHTS SYSTEM 724 725 CELLULAR PHONE AIR CONDITIONING SYSTEM ANTENNA AUDIO SYTEM ON PROTOCOL A BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/PNK WIRE CELLULAR PHONE DEFOGGER SYSTEM DK BLU/ORG WIRE DK GRN/ORG WIRE DK GRN/PPL WIRE ENGINE COMPARTMENT FUSE/RELAY BOX (FRONT CENTER OF ENGINE COMPT) FUSE 12 FUSE 17 FUSE 20 FUSE 24 FUSE 8 FUSED IGNITION GROUND GROUND POWER GRY/LT BLU WIRE GRY/RED WIRE HEATED BACKLITE HEATED MIRROR HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START I/P FUSE PANEL (UNDER LEFT CORNER OF DASH) INTEGRATED CONTROL PANEL LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MIRRORS SYSTEM ORG/LT GRN WIRE ORG/RED WIRE PHONE AUDIO (-) PHONE AUDIO (+) PNK WIRE PNK WIRE POWER ANTENNA PROTOCOL A PROTOCOL B PROTOCOL B AUDIO SYSTEM ON CELLULAR PHONE REAR CONTROL UNIT (LEFT REAR SIDE OF CARGO AREA) RED/BLK WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER TAN WIRE TAN/YEL WIRE WHT/LT GRN WIRE

9 22 LOW COOLANT SW GND BATTERY BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DIODE CENTER (WAGON) (RIGHT REAR CENTER OF VEHICLE, BELOW CARGO FLOORING) DOOR AJAR INDICATOR ENGINE COOLANT LEVEL SWITCH (ON ENGINE COOLANT RESERVOIR) FUSE 12 FUSE 20 FUSE 23 FUSE 5 FUSE 8 GEM CHIME/ TONE LOGIC GENERIC ELECTRONIC MODULE (GEM) (ATTACHED TO I/P FUSE PANEL) GRY WIRE GRY/RED WIRE HEADLAMP SWITCH HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN HOT IN RUN OR START I/P FUSE PANEL (LEFT SIDE OF I/P) IGN (RUN/ACC) IGN (START) INSTRUMENT CLUSTER KEY WARNING SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT FRONT FENDER) LEFT REAR DOOR AJAR SWITCH LIFTGATE DOOR AJAR SWITCH (WAGON) LIFTGATE WINDOW AJAR SWITCH (WAGON) LOW COOLANT INDICATOR LT BLU/WHT WIRE LT GRN/YEL WIRE OFF HEAD ORG/ WIRE ORG/RED WIRE ORG/WHT WIRE PARK PNK WIRE PNK/LT BLU WIRE PPL RED WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND INTEGRATED CONTROL PANEL) RIGHT FRONT DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RUN WIRE SEAT BELT INDICATOR SEATBELT SWITCH WAGON ONLY WHT WIRE WHT/PPL WIRE YEL WIRE YEL/BLK WIRE