Mercury Mountaineer II (2001-2005) tan/org Wiring diagrams

1 2 3 4 5 7 9 10 12 13 17 18 21 22 23 26 27 SS A SS B SS C SS D TCC SOL PCS A 17 20 RETURN V REF CHT ECT TPS 3 4 10 13 24 25 26 27 32 33 40 41 43 44 SCP+ SCP- 40 46 (4.6L) (4.0L) BATTERY JUNCTION (BJB) BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 23 CIRCUIT CYLINDER HEAD TEMPERATURE SENSOR (4.6L) (TOP FRONT OF CYLINDER HEAD) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DLC GROUND GROUND GROUND GROUND POWER POWER BRAKE IN TCS GROUND VBATT ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (4.0L) (TOP RIGHT OF ENGINE) FUSE 11 FUSE 13 FUSE 15 FUSE 37 FUSE 40 FUSE 41 GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER INTERMEDIATE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) ISS JOINT CONNECTOR 1 (PART OF BATTERY JUNCTION BOX) JOINT CONNECTOR 2 (PART OF BATTERY JUNCTION BOX) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PCS C PCS B SIG RTN PNK/BLK WIRE PNK/LT BLU WIRE PRESSURE CONTROL SOLENOIDS RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOIDS TAN WIRE TAN/BLK WIRE TAN/ORG WIRE TAN/WHT WIRE TFT OSS TSS THROTTLE POSTION SENSOR (TOP OF THROTTLE BODY) TORQUE CONV CLUTCH SOLENOID TRANS- MISSION CONTROL SWITCH (END OF SHIFT LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION SOLENOID BODY ASSEMBLY TURBINE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VAPOR MANAGEMENT VALVE, EVR SOLENOID VALVE VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CHARGE INDICATOR COMPUTER DATA LINES SYSTEM FUSE 21 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK C (18 GA- GENERATOR GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER LT BLU WIRE LT GRN/RED WIRE MICRO- SCP - PROCESSOR OFF ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/ 4 3 8 WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/LT GRN WIRE RUN WIRE SCP+ STARTER MOTOR TAN/ORG WIRE WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION AIR BAG CONTACT AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM ANTENNA ASYSON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BAND NEXT VOL UP BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM INTERIOR LIGHTS SYSTEM DK GRN WIRE DK GRN/ORG WIRE DVD PLAYER DVD RIGHT + DVD RIGHT - DVD LEFT + DVD LEFT - FAN DOWN FUSE 28 FUSE 3 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT WITH ACC DELAY RELAY ENERGIZED ILLUM INTERIOR LIGHTS SYSTEM (IN RADIO JUMPER HARNESS NEAR BREAKOUT LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PREMIUM SOUND RADIO CIRCUIT PROTOCOL A PROTOCOL B PTC 1 RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SHIELD SPKR LF+ SPKR RT+ TAN WIRE TAN/ORG WIRE TAN/YEL WIRE TEMP UP FAN UP TEMP DOWN VEHICLE SPEED VOL DOWN WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (ON LEFT SIDE OF ENGINE COMPT, ON INNER FENDER WELL) YEL WIRE

1 2 3 4 5 6 SCP- SCP+ VBATT 2 10 DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 15 FUSE 16 GRY/YEL WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACC LOW TIRE PRESSURE MODULE (UNDER PASSENGER DASH PANEL) PNK/LT BLU WIRE TAN/ORG WIRE VBATT YEL/LT GRN WIRE