Mercury Mountaineer II (2001-2005) instrument cluster Wiring diagrams

A/C CLUTCH RELAY (IN BATTERY JUNCTION BOX) A/C INDICATOR DIODE (IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 7 COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (UNDER LEFT DASH PANEL) FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN AND START HOT IN START OR RUN IN-VEHICLE TEMPERATURE SENSOR (BEHIND TOP LEFT OF DASH) INSTRUMENT CLUSTER J/C 1 J/C 2 (IN BATTERY JUNCTION BOX) LT BLU WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM SUNLOAD SENSOR (AT CENTER OF DASH) TAN WIRE TAN/ORG WIRE VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

ABS CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND RIGHT REAR SEAT) COMPT) ABS TEST CONNECTOR DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DRIVER SEAT MODULE (IN DRIVER'S SEAT) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (UNDER LEFT DASH PANEL) FOUR-WHEEL DRIVE CONTROL MODULE (UNDER PASSENGER DASH PANEL) FUSE 24 HOT AT ALL TIMES INSTRUMENT CLUSTER LOW TIRE PRESSURE MODULE (UNDER PASSENGER DASH PANEL) LT BLU WIRE LT BLU/WHT WIRE ORG/ WIRE PARKING AID MODULE (AT RIGHT "D" PILLAR) PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) RESTRAINTS CONTROL MODULE (BELOW CENTER CONSOLE) TAN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE WHT/YEL WIRE YEL WIRE

-SET CANCEL 1 2 3 4 5 6 POWER CRUISE CTRL SET IND AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CRUISE CTRL SET IND CRUISE CTRL SET IND DK GRN WIRE DK GRN/ORG WIRE FUSE GRY WIRE GRY/RED WIRE HORN SWITCH HORNS SYSTEM HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR NCA WIRE ON RES SET+ ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) SIGNAL RETURN SPEED CONTROL ACTUATOR (RIGHT FRONT OF ENGINE COMPARTMENT, ON FENDER) SPEED CONTROL SWITCH SPEED CTRL INDICATOR SPEED CTRL SW RTN BRAKE PRESS SW IN TAN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 POWER CRUISE CTRL SET IND ABS CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPARTMENT) AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE BRAKE PRESS SW IN BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CRUISE CTRL SET IND CRUISE CTRL SET IND DK GRN WIRE DK GRN/ORG WIRE FUSE GRN WIRE GRY WIRE GRY/RED WIRE HORN SWITCH HORNS SYSTEM INTERIOR LIGHTS SYSTEM HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR NCA WIRE ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE SET- SET+ RES ON SIGNAL RETURN SPEED CONTROL ACTUATOR (RIGHT FRONT OF ENGINE COMPARTMENT, ON FENDER) SPEED CONTROL SWITCH SPEED CTRL INDICATOR SPEED CTRL SW RTN BRAKE PRESS SW IN TAN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

AUTO A/C BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF BLK WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN WIRE DK GRN/VIO WIRE ENGINE COMPT, AT FENDER APRON) FUSE 10 FUSE 4 FUSE 7 GRN WIRE GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LEFT EXTERIOR REAR VIEW MIRROR LT BLU WIRE MANUAL A/C MICRO- PROCESSOR ORG/YEL WIRE REAR WINDOW DEFROST GRID REAR WINDOW DEFROST RELAY RIGHT EXTERIOR REAR VIEW MIRROR VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 VBATT LAMP PWR VBATT 1/2 3/4 5/6 7/8 9/0 ANTI- THEFT HOOD SWITCH (RIGHT FRONT OF ENGINE COMPT, ON FENDER) ANTI- THEFT INHIBIT SWITCH (IN DRIVER DOOR, NEAR LATCH ASSEMBLY) AUTOLMP RELAY AUTOLMP SIG HORN RELAY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 18 FUSE 6 CENTRAL SECURITY MODULE (BEHIND RIGHT REAR SEAT) DATA LINK CONNECTOR DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK DK DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DOOR AJAR SW LIFTGATE AJAR SW INPUT GND DOOR LOCKS SYSTEM DRIVER SIDE REAR DOOR AJAR SWITCH FUSE 16 FUSE 2 FUSE 20 FUSE 22 FUSE 28 GLASS RELEASE GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES INSTRUMENT CLUSTER JOINT CONNECTOR 3 KEY PAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH LEFT HORN RIGHT HORN LIFTGATE AJAR SWITCH (LOWER CENTER OF LIFTGATE) LIFTGATE GLASS AJAR SWITCH (IN CENTER OF TAILGATE) LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE ORG/ WIRE ORG/RED WIRE ORG/WHT WIRE PASSEN- GER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWER WINDOWS SYSTEM PWR VBATT SW INPUT REAR AUXILIARY JUNCTION BOX (AJB) (ON REAR ``D" PILLAR) RED WIRE RED/ORG WIRE RIGHT FRONT DOOR AJAR SWITCH SW INPUT SW INPUT SW INPUT SIG RTN UBP PWR PWR TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE UBP VBATT VIO WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE

10 5 1 4 6 11 ILLLUMINATION VPWR VPWR EXTERIOR LIGHTS INPUT GROUND GROUND 12 9 7 REAR WINDOW DEFROST SW A/C DEMAND SIGNAL BLOWER MOTOR TO BLOWER SWITCH A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLEND DR OUTPUT BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE VPWR GROUND YEL/BLK WIRE YEL/RED WIRE

10 5 1 4 6 11 ILLLUMINATION VPWR VPWR EXTERIOR LIGHTS INPUT GROUND GROUND 12 9 7 REAR WINDOW DEFROST SW A/C DEMAND SIGNAL BLOWER MOTOR TO BLOWER SWITCH A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLEND DR OUTPUT BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE VPWR GROUND YEL/BLK WIRE YEL/RED WIRE

BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CKP SENS CKP SENS TPS CMP SENS CRANKSHAFT POSITION SENSOR (LEFT FRONT OF ENGINE) DFPE SENS KS 1 DIFFERENTIAL PRESSURE FEEDBACK EGR (DFPE) SENSOR (TOP OF THROTTLE BODY) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE ECT INPUT ELECTRONIC VACUUM REGULATOR (EVR) SOLENOID VALVE (ON REAR OF RIGHT CYL HEAD) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP RIGHT OF ENGINE) EVR CTRL RETURN FUEL GAUGE MICRO- PROCESSOR FUEL INJECTORS GRN/VIO WIRE GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE IAC CTRL IDLE AIR CONTROL VALVE (TOP OF THROTTLE BODY) INJ 1 INJ 3 INJ 5 INSTRUMENT CLUSTER KS #1 LT BLU WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE PCM TO COIL INJ 2 PCM TO COIL INJ 4 PNK/WHT WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE RED/YEL WIRE TAN WIRE TAN/BLK WIRE THROTTLE POSITION (TPS) SENSOR (TOP OF THROTTLE BODY) V REF INJ 6 VIO/WHT WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

4 2 FUEL GUAGE MICROPROCESSOR BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUEL PUMP RELAY BLK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK GRN/YEL WIRE FUEL PUMP/ FUEL GAUGE SENDER FUEL TANK ASSEMBLY FUEL TANK PRESSURE SENSOR FUSE 13 GRY/LT BLU WIRE GRY/RED WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 26 HOT IN RUN OR START INERTIA FUEL SHUTOFF SWITCH (BASE OF RIGHT "A" PILLAR) INSTRUMENT CLUSTER J/C 1 (IN BATTERY JUNCTION BOX) LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/VIO WIRE NCA WIRE ORG/ WIRE PNK/BLK WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE TAN/YEL WIRE VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE YEL/BLK WIRE YEL/LT BLU WIRE