Mercury Mountaineer II (2001-2005) hot in start or run Wiring diagrams

ABS CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPT) ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE BOOSTER SENSOR (ON FRONT OF BRAKE BOOSTER) BRAKE FLUID LEVEL SWITCH (MOUNTED ON RIGHT SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE FOUR-WHEEL DRIVE CONTROL MODULE (UNDER PASSENGER DASH PANEL) FUSE 10 FUSE 22 FUSE 23 FUSE 26 FUSE 5 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LEFT FRONT WHEEL SPEED SENSOR LEFT REAR WHEEL SPEED SENSOR LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG/ WIRE ORG/RED WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWETRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PRIMARY BRAKE PRESSURE SENSOR (ON MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RIGHT FRONT WHEEL SPEED SENSOR RIGHT REAR WHEEL SPEED SENSOR SECONDARY BRAKE PRESSURE SENSOR (ON BRAKE BOOSTER) STEERING POSITION SENSOR TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TRACTION CONTROL SWITCH VBATT VIO/WHT WIRE VPWR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE YAW VELOCITY SENSOR (BELOW CENTER CONSOLE) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS CONTROL MODULE (LEFT FRONT SIDE OF ENGINE COMPT) ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SWITCH (MOUNTED ON RIGHT SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FOUR-WHEEL DRIVE CONTROL MODULE (UNDER PASSENGER DASH PANEL) FUSE 10 FUSE 22 FUSE 23 FUSE 45 FUSE 5 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN LEFT FRONT WHEEL SPEED SENSOR LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE ORG/ WIRE PNK WIRE PNK/LT BLU WIRE REAR AXLE SPEED SENSOR (ON REAR DIFFERENTIAL) RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SCP+ TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VIO WIRE VIO/WHT WIRE VPWR VPWR VPWR YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C CLUTCH RELAY (IN BATTERY JUNCTION BOX) A/C INDICATOR DIODE (IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 7 COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (UNDER LEFT DASH PANEL) FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN AND START HOT IN START OR RUN IN-VEHICLE TEMPERATURE SENSOR (BEHIND TOP LEFT OF DASH) INSTRUMENT CLUSTER J/C 1 J/C 2 (IN BATTERY JUNCTION BOX) LT BLU WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM SUNLOAD SENSOR (AT CENTER OF DASH) TAN WIRE TAN/ORG WIRE VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

1 2 3 4 5 6 GROUND REAR A/C FRONT TO REAR A/C REAR REAR BLOWER TO AUX A/C MODULE A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT AUDIO/ CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR HIGH BLOWER MOTOR RESISTOR HIGH BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE FAN DN FAN UP TEMP UP FUSE 25 FUSE 33 GROUND REAR A/C FRONT TO REAR A/C REAR GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT ILLUMINATION INPUT LT BLU/ORG WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TAN WIRE TEMP DN TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WHT WIRE YEL WIRE YEL/BLK WIRE

-SET CANCEL 1 2 3 4 5 6 POWER CRUISE CTRL SET IND AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CRUISE CTRL SET IND CRUISE CTRL SET IND DK GRN WIRE DK GRN/ORG WIRE FUSE GRY WIRE GRY/RED WIRE HORN SWITCH HORNS SYSTEM HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR NCA WIRE ON RES SET+ ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) SIGNAL RETURN SPEED CONTROL ACTUATOR (RIGHT FRONT OF ENGINE COMPARTMENT, ON FENDER) SPEED CONTROL SWITCH SPEED CTRL INDICATOR SPEED CTRL SW RTN BRAKE PRESS SW IN TAN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

10 5 1 4 6 11 ILLLUMINATION VPWR VPWR EXTERIOR LIGHTS INPUT GROUND GROUND 12 9 7 REAR WINDOW DEFROST SW A/C DEMAND SIGNAL BLOWER MOTOR TO BLOWER SWITCH A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLEND DR OUTPUT BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE VPWR GROUND YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 GROUND REAR A/C FRONT TO REAR A/C REAR REAR BLOWER TO AUX A/C MODULE AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLOWER MOTOR HIGH BLOWER MOTOR RESISTOR HIGH BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 25 DK GRN/YEL WIRE FUSE 33 GROUND REAR A/C FRONT TO REAR A/C REAR GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT ILLUMINATION INPUT LT BLU/ORG WIRE LT GRN WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) RED/BLK WIRE RED/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WHT WIRE YEL WIRE YEL/BLK WIRE

10 5 1 4 6 11 ILLLUMINATION VPWR VPWR EXTERIOR LIGHTS INPUT GROUND GROUND 12 9 7 REAR WINDOW DEFROST SW A/C DEMAND SIGNAL BLOWER MOTOR TO BLOWER SWITCH A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLEND DR OUTPUT BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE VPWR GROUND YEL/BLK WIRE YEL/RED WIRE

1 2 3 4 5 6 GROUND REAR BLOWER TO AUX A/C MODULE REAR BLOWER TO AUX A/C MODULE AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 25 FUSE 33 GROUND REAR A/C FRONT TO REAR A/C REAR GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT ILLUMINATION INPUT INTERIOR LIGHTS SYSTEM 1205 260 269 LT BLU/ORG WIRE LT GRN WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR BLOWER TO AUX A/C MODULE AUX BLOWER TO AUX A/C MODULE REAR MODE DOOR ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) RED/BLK WIRE RED/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 VPWR GND TX RX 39 11 14 22 RLY CTRL TX RX IND CTRL BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 14 DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE 20 GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT GRN WIRE ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) PATS INDICATOR POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) STARTER RELAY SUNLOAD SENSOR (AT CENTER OF DASH) WHT WIRE WHT/LT GRN WIRE