Mercury Mountaineer II (2001-2005) dk blu/lt grn Wiring diagrams

A/C CLUTCH RELAY (IN BATTERY JUNCTION BOX) A/C INDICATOR DIODE (IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 7 COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (UNDER LEFT DASH PANEL) FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN AND START HOT IN START OR RUN IN-VEHICLE TEMPERATURE SENSOR (BEHIND TOP LEFT OF DASH) INSTRUMENT CLUSTER J/C 1 J/C 2 (IN BATTERY JUNCTION BOX) LT BLU WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM SUNLOAD SENSOR (AT CENTER OF DASH) TAN WIRE TAN/ORG WIRE VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

1 2 3 4 5 6 GROUND REAR A/C FRONT TO REAR A/C REAR REAR BLOWER TO AUX A/C MODULE A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPARTMENT) A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT AUDIO/ CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR HIGH BLOWER MOTOR RESISTOR HIGH BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE FAN DN FAN UP TEMP UP FUSE 25 FUSE 33 GROUND REAR A/C FRONT TO REAR A/C REAR GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT ILLUMINATION INPUT LT BLU/ORG WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TAN WIRE TEMP DN TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WHT WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM ANTI-THEFT SYSTEM AUTO AUTO HEAD BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE CENTRAL SECURITY MODULE (BEHIND RIGHT REAR SEAT) DK BLU WIRE DK BLU/ ORG WIRE DK BLU/ WHT WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN/ORG WIRE FUSE 16 FUSE 19 FOG LAMP RELAY FUSE 22 FUSE 42 FUSE 44 FUSE 46 GRY/ORG WIRE HEAD HEADLAMP RELAY HI-BEAM IND HIGH BEAM RELAY FUSE 43 HOT AT ALL TIMES INSTRUMENT CLUSTER LEFT FRONT FOG LAMP RIGHT FRONT FOG LAMP LEFT HEADLAMP LT BLU/BLK WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH MAIN LIGHT SWITCH FOG LAMP SWITCH MICROPROCESSOR MULTI- FUNCTION SWITCH OFF PARK ORG DK BLU/ WIRE ORG/ WIRE ORG/WHT WIRE PARK OFF PASS PASS HI HI LO LO RED/BLK WIRE RIGHT HEADLAMP SUNLOAD SENSOR (AT CENTER OF DASH) TAN WIRE TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/RED WIRE

1 2 3 4 VPWR GND TX RX 39 11 14 22 RLY CTRL TX RX IND CTRL BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 14 DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE 20 GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT GRN WIRE ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) PATS INDICATOR POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) STARTER RELAY SUNLOAD SENSOR (AT CENTER OF DASH) WHT WIRE WHT/LT GRN WIRE

348 743 A/C SYSTEM 848 151 926 CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM AC DEMAND IAT IN TANK PRESS ANTI-THEFT SYSTEM AUDIO UNIT WINDSHIELD WIPER MOTOR (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) BRN/WHT WIRE CAN VENT VSS IND CTRL RLY CTRL CHARGING SYSTEM A/C SYSTEM TRANSMISSION CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM A/C SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM A/C SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK GRN/ ORG WIRE DK GRN/ORG WIRE EVAPORATIVE EMISSION (EVAP) CANISTER VENT VALVE (RIGHT CENTER OF VEHICLE) F PMP PWR SCP BUS + SCP BUS - FUSE 15 FUSE 40 FUSE 38 FUSE 39 FUSE 37 FUSE 41 FUSE 45 GROUND BATTERY SPD CTRL SPD CTRL A/C SW GROUND GROUND GROUND GROUND PRES SW CRUISE SET A/C RLY MAF OUT IGN IGN GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INPUT J/C 1 J/C 2 LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIRFLOW (MAF) SENSOR (RIGHT FRONT OF ENGINE COMPARTMENT) NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG DK GRN/ WIRE ORG/ WIRE ORG/LT BLU WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) PCM POWER DIODE PCM POWER RELAY FUSE 11 PNK/BLK WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RETURN SENS RTN ST MTR BRAKE IN OD OFF SPD CTRL SPD SW SPD SW RLY CTRL STARTING SYSTEM TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TX SIG EVAP PU PGM SIG RX SIG V REF VAPOR MANAGE- MENT VALVE (LEFT REAR OF ENGINE COMPT) VIO WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/WHT WIRE

BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CKP SENS CKP SENS TPS CMP SENS CRANKSHAFT POSITION SENSOR (LEFT FRONT OF ENGINE) DFPE SENS KS 1 DIFFERENTIAL PRESSURE FEEDBACK EGR (DFPE) SENSOR (TOP OF THROTTLE BODY) DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE ECT INPUT ELECTRONIC VACUUM REGULATOR (EVR) SOLENOID VALVE (ON REAR OF RIGHT CYL HEAD) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP RIGHT OF ENGINE) EVR CTRL RETURN FUEL GAUGE MICRO- PROCESSOR FUEL INJECTORS GRN/VIO WIRE GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE IAC CTRL IDLE AIR CONTROL VALVE (TOP OF THROTTLE BODY) INJ 1 INJ 3 INJ 5 INSTRUMENT CLUSTER KS #1 LT BLU WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE PCM TO COIL INJ 2 PCM TO COIL INJ 4 PNK/WHT WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE RED/YEL WIRE TAN WIRE TAN/BLK WIRE THROTTLE POSITION (TPS) SENSOR (TOP OF THROTTLE BODY) V REF INJ 6 VIO/WHT WIRE WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

348 743 A/C SYSTEM 848 151 926 CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM AC DEMAND IAT IN TANK PRESS ANTI-THEFT SYSTEM AUDIO UNIT WINDSHIELD WIPER MOTOR (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) BRN/WHT WIRE CAN VENT VSS IND CTRL RLY CTRL CHARGING SYSTEM A/C SYSTEM TRANSMISSION CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM A/C SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM A/C SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ ORG WIRE EVAPORATIVE EMISSION (EVAP) CANISTER VENT VALVE (RIGHT CENTER OF VEHICLE) F PMP PWR SCP BUS + SCP BUS - FUSE 15 FUSE 39 FUSE 38 FUSE 37 FUSE 40 FUSE 41 FUSE 45 GROUND BATTERY SPD CTRL SPD CTRL A/C SW GROUND GROUND GROUND GROUND PRES SW CRUISE SET A/C RLY MAF OUT IGN IGN GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INPUT J/C 1 J/C 2 LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIRFLOW (MAF) SENSOR (RIGHT FRONT OF ENGINE COMPARTMENT) NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG DK GRN/ WIRE ORG/ WIRE ORG/LT BLU WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) PCM POWER DIODE PCM POWER RELAY FUSE 11 PNK/BLK WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RETURN SENS RTN ST MTR BRAKE IN OD OFF SPD CTRL SPD SW SPD SW RLY CTRL STARTING SYSTEM TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TX SIG EVAP PU PGM SIG RX SIG V REF VAPOR MANAGE- MENT VALVE (LEFT REAR OF ENGINE COMPT) VIO WIRE VIO/WHT WIRE VIO/YEL WIRE W/ IVD W/O IVD WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/WHT WIRE