Mercury Mountaineer I facelift (1997-2001) fuse 10 Wiring diagrams

1 2 3 4 5 6 7 15 16 17 18 19 20 DATA (-) BATTERY GROUND INPUT GROUND 130 OHMS 226 OHMS 2940 OHMS 422 OHMS 931 OHMS AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROLLER (NEAR BLOWER MOTOR) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CLOCKSPRING ASSEMBLY CRUISE CONTROL DK BLU/LT GRN WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN FUSE 10 FUSE 2 FUSE 36 FUSE JUNCTION PANEL GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN ILLUMINATION IN-CAR TEMPERATURE SENSOR (BEHIND TOP CENTER OF DASH) LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PPL PPL 2 3 4 5 RED WIRE RED/BLK WIRE RED/ORG WIRE SOUND SYSTEMS SPEED CONTROL SERVO/ AMPLIFIER ASSEMBLY (IN RIGHT REAR ENGINE COMPARTMENT) SPEED CTRL SW GND SUN LOAD SENSOR (TOP RIGHT SIDE OF DASH, ABOVE GLOVE BOX) TAN/ORG WIRE TEMP WHT WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 1 1 CURRENT SENSE LOW DOWN IN ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DK BLU/ORG WIRE DK GRN/VIO WIRE DOOR LOCKS SYSTEM FUSE 10 FUSE 20 FUSE 25 FUSE 28 GENERIC ELECTRONIC MODULE ONLY GENERIC ELECTRONIC MODULE/ CENTRAL TIMER MODULE (BEHIND CENTER OF DASH) GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM ANTI-LOCK BRAKES SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWER WINDOW SYSTEM RED WIRE RED/BLK WIRE RUN WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/ORG WIRE WARNING SYSTEM WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM (FRONT) WIPER/WASHER SYSTEM (FRONT-REAR) YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

12 8 INT LAMP RLY CTRL BAT SAVER RLY CTRL AUXILIARY RELAY BOX 2 (LEFT REAR OF VEHICLE, ABOVE WHEELWELL) BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE CARGO LAMP COMPASS/ OUTSIDE AIR TEMPERATURE MODULE DIMMER MODULE (LEFT SIDE OF STEERING COLUMN) DK GRN WIRE FUSE 10 FUSE 26 FUSE JUNCTION PANEL GRN WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT ILLUMINATION CIRCUIT INTERIOR LAMP INTERIOR LAMP RELAY LEFT FRONT DOOR AJAR SWITCH LEFT FRONT RUNNING BOARD LAMP LEFT LIFTGATE AJAR SWITCH LEFT REAR DOOR AJAR SWITCH LEFT REAR RUNNING BOARD LAMP LEFT VANITY MIRROR LAMP/SWITCH LIFTGATE WIPER DISABLE SWITCH LIGHTED RUNNING BOARD RELAY LT ELECTRIC SHIFT CONTROL MODULE LT GRN WIRE LT GRN/DK GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE MAP LAMP NORM ON OFF ORG/ WIRE PNK/LT BLU WIRE POWER WINDOWS CIRCUIT PPL PPL/ORG WIRE REAR INTERIOR LAMP REAR MAP LAMP RELAY MODULE (BEHIND CENTER OF DASH) RIGHT FRONT DOOR AJAR SWITCH RIGHT FRONT RUNNING BOARD LAMP RIGHT LIFTGATE AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RIGHT REAR RUNNING BOARD LAMP RIGHT VANITY MIRROR LAMP/SWITCH TAN/YEL WIRE W/O OVERHEAD CONSOLE ONLY WHT WIRE WHT/PPL WIRE YEL/BLK WIRE

1 2 3 4 5 6 INDICATOR CONTROL 1000 OHMS 2200 OHMS 4-WHEEL ANTI-LOCK BRAKE SYSTEM 680 OHMS 120 OHMS A/T W/ HIGH SERIES CONSOLE A/T W/O HIGH SERIES CONSOLE AIR BAG SLIDING CONTACT (IN STEERING COLUMN) BACK LIGHT BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND STEERING COLUMN) BRAKE PRESS INPUT GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) BRN WIRE CLUTCH PEDAL POSITION (CPP) SWITCH (ON CLUTCH PEDAL ARM) CLUTCH PEDAL POSITION (CPP) SWITCH JUMPER COAST CONTROL MODULE DK GRN/ORG WIRE FUSE FUSE 10 FUSE JUNCTION PANEL GRY WIRE GRY/BLK WIRE GRY/YEL WIRE HORN RELAY (BEHIND RIGHT SIDE OF DASH, IN RPO RELAY BLOCK) HORN SWITCHES HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE M/T MAIN LIGHT SWITCH NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE PNK WIRE REAR AXLE SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/ LT GRN WIRE RED/BLK WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RESUME SET/ ACCEL SPEED CONT SW IN SPEED CONT SW GND IGNITION SPEED CONTROL INDICATOR LAMP SPEED CONTROL SERVO (IN RIGHT REAR OF ENGINE COMPARTMENT) TAN/LT BLU WIRE VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/ LT GRN WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM (RAP MODULE) (1999 ONLY) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/YEL WIRE DAY/NIGHT MIRROR/ AUTOLAMP SENSOR (MOUNTED IN REARVIEW MIRROR) DIMMER RELAY (IN RELAY MODULE) DK BLU/WHT WIRE DK GRN WIRE EXPLORER ONLY FUSE 10 FUSE 11 FUSE 13 FUSE 21 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) HAZARD HEAD HEADLAMP RELAY (IN RELAY MODULE) HIGH MOUNTED STOP LAMP ASSEMBLY HOT AT ALL TIMES HOT IN RUN IGN (RUN) INSTRUMENT CLUSTER LAMPS ON LEFT FRONT PARK/ TURN LAMPS LEFT FRONT SIDE MARKER LAMP LEFT LICENSE LAMP LEFT TURN SIGNAL LAMP (REAR) LEFT REAR STOP/ PARK LAMP LEFT TURN INDICATOR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MULTI- FUNCTION NCA WIRE NORMAL OFF ORG/LT BLU WIRE ORG/YEL WIRE PARK PARK LAMP RELAY (IN RELAY MODULE) REAR RED/WHT WIRE RIGHT FRONT PARK/ TURN LAMPS RIGHT FRONT SIDE MARKER LAMP RIGHT LICENSE LAMP RIGHT REAR STOP/ PARK LAMP RIGHT TURN INDICATOR RIGHT TURN SIGNAL LAMP SENSOR OUTPUT SWITCH TAN/WHT WIRE TRAILER TOW PARK LAMP RELAY (W/ TRAILER TOW PACKAGE ONLY) TRAILER/CAMPER ADAPTER CIRCUIT (STOP/TURN FUSES) TURN LEFT TURN RIGHT TURN/HAZARD CONTROL TURN/HAZARD FLASHER VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/VIO WIRE

AIR CONDITIONING SYSTEM BATTERY BLK WIRE BLK/WHT WIRE CONTROL MODULE (IN LEFT SIDE OF ENGINE COMPT) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC SUSPENSION SYSTEM ENGINE LOW OIL/ TEMPERATURE SWITCH (LEFT SIDE OF ENGINE, AT OIL PAN) FUEL FLOW INPUT FUEL FLOW RATE OUTPUT FUEL LEVEL INPUT FUSE 10 FUSE 36 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GROUND GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN LAMP OUT WARNING LAMP OUT WARNING LOW WASHER FLUID SENSE ENGINE SELECT LOW WASHER FLUID LEVEL SWITCH (IN WASHER RESERVOIR) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE MESSAGE CENTER MESSAGE CENTER SWITCH ASSEMBLY MESSAGE CENTER SWITCH INPUT ILLUMINATION FEED MODULE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (MOUNTED THROUGH FIREWALL) REAR AXLE SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/BLK WIRE RED/PNK WIRE RED/WHT WIRE SOUND TONE REQUEST SPEED SENSOR INPUT (ARC) DISABLE SWITCH INPUT SUPPLEMENTAL RESTRANTS SYSTEM SWITCH BANK 1 SWITCH BANK 2 TACH INPUT TAN/YEL WIRE WHT/ BLK WIRE WHT/PNK WIRE YEL/WHT WIRE

A/C COMPRESSOR CLUTCH SOLENOID (ON LEFT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY (IN POWER DISTRIBUTION BOX) BATTERY JUNCTION BOX FUSE 2 BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY (IN POWER DISTRIBUTION BOX) BLOWER MOTOR RESISTOR (NEAR BLOWER MOTOR) BLOWER MOTOR SWITCH BRN WIRE DEF/FLR DEFROST DK GRN WIRE FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 2 FUSE 6 FUSE JUNCTION PANEL GRN WIRE GRY WIRE HI MED HI MED LO HIGH SPEED BLOWER RELAY (IN AUXILIARY RELAY BOX 2) HOT AT ALL TIMES HOT AT ALL TIMES POWER DISTRIBUTION BOX FUSE 1 HOT IN RUN ILLUMI- NATION LOW OFF LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MED NEAR BREAKOUT TO NORM A/C MAX A/C OFF PANEL OFF PANEL PANEL/FLOOR NORM A/C FLOOR MAX A/C DEF/FLR DEFROST ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PANEL/FLOOR FLOOR PCM POWER RELAY (IN POWER DISTRIBUTION BOX) PNK PNK WIRE PNK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PPL PPL 69 86 REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RESISTOR (IN DASH CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE SOLID STATE SUPPLEMENTAL RESTRAINTS SYSTEM TEMPERATURE CONTROL POTENTIOMETER WARM COLD WHT WIRE YEL WIRE YEL/RED WIRE

BLK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COMPASS COMPASS/OUTSIDE AIR TEMPERATURE MODULE DK BLU WIRE ENGINE CONTROLS SYSTEM (VEHICLE SPEED SENSOR) FUSE 10 GRY WIRE HOT IN RUN INTERIOR LIGHTS SYSTEM (COURTESY LAMPS CIRCUIT) INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LT BLU WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE POWER DISTRIBUTION SYSTEM RED WIRE THERMOMETER WHT WIRE YEL WIRE

357 1017 360 11 1145 1143 570 96 (2000) AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL FLOW RATE FUEL GUAGE SEND DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM CHK FUEL CAP EVR CTRL TACHOMETER GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM KNOCK SENS LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TFT SENS ECT SENS MAF SENS FUEL PUMP REL A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL SHIFT SOL A SHIFT SOL D TCS INPUT PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL FLOW RATE FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL 1, 2 (LEFT FRONT OF ENGINE) IGNITION COIL 3, 4 (RIGHT FRONT OF ENGINE) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS MAF SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS CTRL SW TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE