Mercury Monterey VIII (2003-2007) vio Wiring diagrams

13 15 16 PROG SIGNAL SCP BUS- SCP BUS+ 55 71 23 91 37 BATTERY B+ IGNITION IGNITION SIG RTN TFT SENS SIG BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) CONTROL SOLENOIDS CYLINDER HEAD TEMPERATURE SENSOR (REAR OF LEFT CYLINDER HEAD) DATA LINK CONNECTOR (BELOW DASH. LEFT OF STEERING COLUMN) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (AT TOP OF TRANSAXLE) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM EPC SOL CTRL FLUID TEMP SENSOR FUSE 40 FUSE 43 FUSE 49 GRN WIRE GROUND GROUND GROUND GROUND GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU/BLK WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TRANS- MISSION) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/YEL WIRE REF VOLT TPS SIG OSS SIG CYL HEAD TEMP TSS SENS SHIFT SOL A SHIFT SOL B SHIFT SOL C SHIFT SOLENOID SHIFT SOLENOID PNK WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) FUSE 19 TAN/ORG WIRE TCC SOL. CTRL THROTTLE POSITION (TP) SENSOR (TOP REAR OF ENGINE, ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

2 2 1 1 GENERATOR ALT COM ALT MON BATTERY BLK WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) FUSE FUSE 49 49 CHARGE IND COMPUTER COMPUTER DATA LINES DATA LINES SYSTEM SYSTEM FUSE 50 FUSIBLE LINK A INSTRUMENT CLUSTER LT BLU WIRE MICROPROCESSOR MICROPROCESSOR NCA WIRE ORG/ WIRE ORG/LT BLU WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/PNK WIRE SCP (+) 10 10 SCP (-) 9 9 SCP+ STARTER MOTOR TAN/ORG WIRE VBATT VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 VBATT 1 2 3 4 SIGNAL 1 SIGNAL 2 PWR GND AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLU WIRE BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT FRONT OF ENGINE COMPT) CHIME CINCHING MOTOR (+) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM FORK/DETENT SWITCH LIFTGATE LATCH/ UNLATCH ASSEMBLY FUSE 13 LIFTGATE PARK STATUS FUSE 20 FUSE 9 GROUND GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START LEFT LIFTGATE OBSTACLE DETECTION STRIP LIFTGATE DRIVER MOTOR ASSEMBLY LIFTGATE OPEN/ CLOSE LIFTGATE PARK SW VREF SIG RTN LIFTGATE AJAR VPWR ENABLE ON/OFF VREF VREF LOCK ACTUATOR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MOTOR ASSEMBLY) OPTICAL SENSOR ORG/ WIRE ORG/LT BLU WIRE OVERHEAD CONSOLE (FRONT CENTER TOP OF PASSENGER COMPARTMENT) PNK/ PNK/ LT WIRE PNK/BLK WIRE POWER LIFTGATE MODULE POWER LIFTGATE OPEN/CLOSE SWITCH POWER SLIDING DOOR CIRCUIT PWR VSS RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/WHT WIRE RED/YEL WIRE RIGHT LIFTGATE OBSTACLE DETECTION STRIP (RIGHT SIDE OF LIFTGATE) SENS GND VREF VBATT SMART JUNCTION BOX (SJB) (LEFT FRONT OF FUSE 11 ENGINE COMPT) TAN WIRE TAN/WHT WIRE UNLATCH MOTOR VIO WIRE VIO/WHT WIRE VREF VREF SIG RTN VSS WHT/RED WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 VBATT OPEN/CLOSE SW VREF 1 2 3 4 ACTUATOR CTRL RETURN GROUND VBATT 1 2 3 4 SIG RTN PWR SENSOR SIGNAL SENSOR SIGNAL 70 1040 COMPUTER DATA LINES SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BUSSED COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE ENABLE ON/OFF FUSE 11 FUSE 16 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN FUSE 13 HOT IN START OR RUN ILLUMINATION ISO VPWR LEFT DETENT SWITCH LEFT POWER SLIDING DOOR CLUTCH LEFT POWER SLIDING DOOR MOTOR (IN LEFT QUARTERPANEL) LEFT POWER SLIDING DOOR POSITION SENSOR LEFT POWER SLIDING DOOR SWITCH (LEFT "B" PILLAR) LEFT PWR SLIDING DR SW LEFT SIDE POWER SLIDING DOOR MODULE LEFT SLIDING DOOR AJAR SWITCH (BOTTOM LEFT "B" PILLAR) LEFT SLIDING DOOR CONTACT SWITCH (LEFT "B" PILLAR) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE OVERHEAD CONSOLE (FRONT CENTER TOP OF PASSENGER COMPT) PNK/BLK WIRE POWER LIFTGATE MODULE PWR SIG RTN REAR PWR SLIDING DR SW RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT POWER SLIDING DOOR CLUTCH RIGHT POWER SLIDING DOOR LATCH REVERSE ACTUATOR (FRONT OF RIGHT SLIDING DOOR) RIGHT POWER SLIDING DOOR POSITION SENSOR RIGHT POWER SLIDING DOOR SWITCH (RIGHT "B" PILLAR) RIGHT PWR SLIDING DR SW RIGHT SIDE POWER SLIDING DOOR MODULE (ABOVE RIGHT REAR WHEELWELL) RIGHT SLIDING DOOR CONTACT SWITCH (RIGHT "B" PILLAR) SLIDING DOOR OPEN/ CLOSE SW SLIDING DOOR PARK STATUS SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO WIRE VIO/WHT WIRE VREF VREF VREF PARK STATUS VSS VREF VREF PARK STATUS VSS VREF ISO VPWR VSS WHT WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

0) OFF 1) ON 29) REAR WASHER 31) INTERMITTENT WIPE BLK WIRE BRN WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) DK BLU WIRE DK GRN WIRE FUSE 55 FUSE 7 HOT AT ALL TIMES HOT IN RUN OR ACC JOINT CONNECTOR 2 (BEHIND CENTER OF DASH) LT GRN WIRE MICROPROCESSOR MULTI- FUNCTION SWITCH ORG/ WIRE PARK PNK WIRE REAR WASHER PUMP RELAY REAR WIPER MOTOR ASSEMBLY (INSIDE LIFTGATE) REAR WIPER RELAY REAR WIPER SWITCH RUN WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE WHT WIRE

BATTERY BLK WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPARTMENT) CHARGING CIRCUIT DIGITAL TRANSMISSION RANGE (DTR) SENSOR (AT TOP OF TRANSAXLE) DK GRN WIRE FUSE 4 FUSE 64 HOT AT ALL TIMES IGNITION SWITCH LOCK OFF LT BLU WIRE LT GRN WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/LT BLU WIRE RUN WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) FUSE 21 STARTER MOTOR STARTER RELAY VIO WIRE WHT WIRE YEL WIRE

AIR BAG DISABLE ILLUM AIR BAG IND AND PINS 1-2, 3-4, 5-6, 7-8, 9-10, BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-L CAN-H COMPUTER DATA LINES SYSTEM DK BLU/ORG WIRE DK GRN/WHT WIRE DRIVER 1 SIDE IMPACT SENSOR (BELOW DRIVER'S SEAT) FORWARD CRASH SENSOR FUSE 17 GROUND GRY/LT BLU WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN START OR RUN ISO VPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE OCCUPANT CLASSIFICATION SENSOR MODULE (UNDER PASSENGER'S SEAT) ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE PASSENGER 1 SIDE IMPACT SENSOR (BELOW PASSENGER SEAT) PASSENGER SAFETY BELT BUCKLE SWITCH (IN PASSENGER'S SAFETY BELT BUCKLE) PASSENGER SAFETY BELT RETRACTOR PRETENSIONER (RIGHT OF CENTER CONSOLE) PASSENGER SAFETY BELT TENSION SENSOR (IN RIGHT "B" PILLAR) PNK WIRE PNK/BLK WIRE PNK/ORG WIRE PNK/WHT WIRE POWER QUARTER WINDOW SWITCH PWR RED WIRE RED/BLK WIRE RED/ORG WIRE RED/PNK WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (UNDER CENTER CONSOLE) SEAT WEIGHT PRESSURE SENSOR SHORTING BAR SIG SIG RTN SIG VREF SIG RTN GND CAN L CAN H VPWR SIG RTN PWR SIG SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TONE DRV IND CTRL VIO WIRE VIO/LT GRN WIRE VREF SIG RTN VREF SIG RTN VREF SIG RTN VREF SIG RTN VREF VREF VREF SIG RTN VREF SIG RTN WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR BAG IND AIR BAG SLIDING CONTACT (BEHIND DRIVER SIDE OF DASH) ANTI-THEFT SYSTEM BAR SHORTING BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/YEL WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER 2 SIDE IMPACT SENSOR DRIVER AIR BAG UNIT DRIVER SAFETY BELT RETRACTOR PRETENSIONER (LEFT SIDE OF CENTER CONSOLE) FUSE 19 (BEHIND LEFT SIDE OF DASH) GRN WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN OR START INSTRUMENT CLUSTER LEFT "C" PILLAR) LEFT SAFETY CANOPY MODULE (TOP OF LEFT "D" PILLAR) LEFT SIDE AIR BAG MODULE (IN DRIVER'S SEAT BACK) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MICRO- PROCESSOR NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PASSENGER 2 SIDE IMPACT SENSOR PILLAR) PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/ORG WIRE RED/PNK WIRE REST RIGHT SAFETY CANOPY MODULE (TOP OF RIGHT "D" RIGHT SIDE AIR BAG MODULE (IN PASSENGER'S SEAT BACK REST) SAFETY BELT IND SHORTING BAR SMART JUNCTION BOX (SJB) STAGE 1 STAGE 1 PASSENGER AIR BAG MODULE (ON RIGHT SIDE OF DASH) STAGE 2 VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE