Mercury Monterey VIII (2003-2007) hot in start or run Wiring diagrams

10 2 DATA LINK CONNECTOR (BELOW DASH, LEFT OF STEERING COLUMN) 15 16 SCP+ SCP- 4 3 2 1 SIG RTN ANGLE A ANGLE B VPWR 6 5 4 3 2 1 GND RAST TEST RATE ACCEL PWR 9 10 SCP- SCP+ ABS CONTROL MODULE (UNDER VEHICLE, MOUNTED ON INSIDE FRAME RAIL) ABS TEST CONNECTOR (NEAR MASTER CYLINDER) AUDIO UNIT BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BOX (SJB) (BEHIND LEFT SIDE OF DASH) BRAKE BOOSTER SENSOR (W/ IVD) (AT LEFT REAR SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION SWITCH (BEHIND DASH, TOP OF BRAKE PEDAL) BRAKE PRESSURE SWITCH (AT LEFT REAR SIDE OF ENGINE COMPT) BRK PRE SW IN 7 8 9 10 11 12 BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) FUSE 8 (AT LEFT SIDE OF ENGINE COMPT) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE FUSE FUSE 12 FUSE 16 FUSE 18 GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER J/C 2 (BEHIND CENTER OF DASH) J/C 4 (BELOW LEFT SIDE OF DASH) JOINT CONNECTOR 1 (BEHIND LEFT OF DASH) LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR WHEEL) LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/RED WIRE PARKING AID MODULE (RIGHT "D" PILLAR) PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR WHEEL) SCP+ SCP- 19 20 21 22 23 24 25 SENSOR IN SELF TEST INPUT B VREF SMART JUNCTION SPEED CONTROL SERVO (AT LEFT SIDE OF ENGINE COMPT) STEERING POSITION SENSOR (W/ IVD) (BEHIND DRIVER SIDE OF DASH) TAN/BLK WIRE TAN/ORG WIRE TRACTION ASSIST/ PARKING AID DISABLE SWITCH VBATT SCP+ 3 4 VBATT VPWR VSS GROUND SUPPLY SIG RTN GROUND W/ IVD WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YAW SENS IN FREQUENCY INPUT A VREF YAW VELOCITY SENSOR (W/ IVD) (UNDER DRIVER'S SEAT) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C CLUTCH FIELD COIL (ON A/C COMPRESSOR) A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C PRESSURE TRANSDUCER SENSOR AUXILIARY RELAY BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) CYLINDER HEAD TEMPERATURE SENSOR (REAR OF LEFT CYLINDER HEAD) DROPPING RESISTOR (LEFT FRONT OF ENGINE COMPARTMENT) ENGINE CONTROLS SYSTEM ENGINE COOLING FAN CIRCUIT BREAKER ENGINE COOLING FAN MOTOR 1 (BEHIND LEFT SIDE OF RADIATOR) ENGINE COOLING FAN MOTOR 2 (BEHIND RIGHT SIDE OF RADIATOR) ENGINE COOLING FAN RELAY #1 ENGINE COOLING FAN RELAY #2 ENGINE COOLING FAN RELAY #3 ENGINE COOLING FAN RELAY 4 ENGINE COOLING FAN RELAY 5 FUSE 1 FUSE 2 BOX 1 (RIGHT FRONT OF ENGINE COMPT) FUSE 3 FUSE 2 FUSE 40 FUSE 42 FUSE 43 GRN WIRE GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT GRN WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/ORG WIRE SIG RTN TAN/LT GRN WIRE VIO WIRE VIO/ORG WIRE VREF W/ TRAILER TOW W/O TRAILER TOW WHT WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

10 9 8 GROUND SW OUT 15 16 SCP+ SCP- 32 6 18 3 VPWR ABS CONTROL MODULE (UNDER DRIVER'S SEAT) ABS TEST CONNECTOR (NEAR MASTER CYLINDER) AIR BAG SLIDING CONTACT (BEHIND DRIVER SIDE OF DASH) ANTI-THEFT SYSTEM BLK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND DASH, TOP OF BRAKE PEDAL) BRAKE PRESSURE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE FUSE HORNS SYSTEM HOT AT ALL TIMES HOT IN START OR RUN ILLUM JOINT CONNECTOR 2 (BEHIND CENTER OF DASH) JOINT CONNECTOR 4 (BELOW LEFT SIDE OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE REST REST COAST RESUME SCP - SCP + SCP+ SET ACCELERATE/ SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SPEED CONTROL OFF SPEED CONTROL ON HORN SPEED CONTROL SERVO (AT LEFT SIDE OF ENGINE COMPARTMENT) STEERING WHEEL RADIO SWITCH STEERING WHEEL/SPEED CONTROL SWITCH SWITCH (AT LEFT REAR SIDE OF ENGINE COMPT) TAN WIRE TAN/ORG WIRE VPWR SIG RTN 6 5 4 3 2 1 VREF

1 2 3 4 5 6 7 VPWR GROUND BLK WIRE ELECTROCHROMATIC INSIDE MIRROR UNIT (FRONT CENTER OF PASSENGER COMPARTMENT) FUSE 16 HOT IN START OR RUN RED/YEL WIRE REVERSE SIG SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) WHT/YEL WIRE

AIR BAG IND AMBIENT AIR TEMPERATURE SENSOR (AT RIGHT FRONT SIDE OF ENGINE COMPARTMENT) ANTI-THEFT SYSTEM AIR CONDITIONING SYSTEM BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) BRN/ORG WIRE CHARGE IND CLOCK COMPASS DATA + COMPUTER DATA LINES SYSTEM DK BLU WIRE ENGLISH/ METRIC SELECT FUEL GAUGE FUEL TANK UNIT (IN FUEL TANK) FUSE 11 FUSE 16 FUSE 19 FUSE 8 GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/ORG WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION J/C 1 (BEHIND LEFT SIDE OF DASH) JOINT CONNECTOR 2 (BEHIND CENTER OF DASH) KEY WARNING SWITCH LOW CURRENT BOARD LOW OIL PRESSURE IND LOW BRAKE FLUID LEVEL/ PARK BRAKE IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/VIO WIRE MESSAGE CENTER SWITCH MICROPROCESSOR INSTRUMENT CLUSTER NAVIGATION SYSTEM NCA WIRE OIL PRESSURE SWITCH (AT LOWER LEFT FRONT OF ENGINE) ORG/ WIRE OVERHEAD CONSOLE CIRCUIT PARKING BRAKE SWITCH (AT BASE OF PARK BRAKE HANDLE) PNK WIRE PNK/ PNK/ LT WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE RESET+ SAFETY BELT IND MESSAGE CENTER SW, INPUT KEY WARNING SW SCP+ SCP- PWR SIG RTN SIG RTN (3 BULBS) ILLUM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE TRACTION CTRL OVERRIDE, INPUT VBATT VBATT PWR GND VIO WIRE VPWR VREF WARNING SYSTEM WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM YEL WIRE

20 18 7 29 19 PNK WIRE A/C CLUTCH FIELD COIL (ON A/C COMPRESSOR) A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C PRESSURE TRANSDUCER SENSOR BLK WIRE BLK/LT BLU WIRE BLK/YEL WIRE BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPT) CLUSTER SYSTEM FRONT BLOWER MOTOR RELAY (LEFT KICK PANEL) DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND LEFT SIDE OF DASH) ELECTRONIC MANUAL TEMPERATURE CONTROL (EMTC) MODULE (CENTER OF DASH) FRESH/ RECIRCULATION DOOR ACTUATOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND RIGHT SIDE OF DASH) FUSE 12 FUSE 14 FUSE 40 FUSE 42 FUSE 8 GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN INSTRUMENT LOW CURRENT BOARD LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE MODE DOOR ACTUATOR (BEHIND CENTER OF DASH) ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE SHIFT INTERLOCK SYSTEM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO WIRE VIO/ORG WIRE W/ SINGLE ZONE A/C WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

AUXILIARY RELAY AUXILIARY RELAY BOX 1 (RIGHT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BLU WIRE BRN/WHT WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPARTMENT) CYLINDER HEAD TEMPERATURE SENSOR (REAR OF LEFT CYLINDER HEAD) DROPPING RESISTOR (LEFT FRONT OF ENGINE COMPARTMENT) ENGINE COOLING FAN CIRCUIT BREAKER ENGINE COOLING FAN MOTOR 1 (BEHIND LEFT SIDE OF RADIATOR) ENGINE COOLING FAN MOTOR 2 (BEHIND RIGHT SIDE OF RADIATOR) ENGINE COOLING FAN RELAY #1 ENGINE COOLING FAN RELAY #2 ENGINE COOLING FAN RELAY #3 ENGINE COOLING FAN RELAY 4 ENGINE COOLING FAN RELAY 5 FUSE 1 FUSE 2 BOX 1 (RIGHT FRONT OF ENGINE COMPT) FUSE 3 FUSE 2 FUSE 43 GRY/RED WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT GRN WIRE LT GRN/VIO WIRE LT GRN/YEL WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT REAR OF ENGINE COMPARTMENT) RED WIRE RED/ORG WIRE TAN/LT GRN WIRE VIO WIRE W/O TRAILER TOW W/ TRAILER TOW YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/LT BLU WIRE COMPASS, THERMOMETER FUSE 13 FUSE 16 GRN WIRE HOT IN HOT IN START OR RUN ILLUM ILLUMINATION INSTRUMENT CLUSTER LEFT POWER SLIDING DOOR SWITCH LEFT SIDE POWER SLIDING DOOR MODULE VREF LOW CURRENT BOARD LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAP READING LAMPS ORG/ WIRE OVERHEAD CONSOLE (FRONT CENTER TOP OF PASSENGER COMPARTMENT) POWER LIFTGATE MODULE ENABLE ON/OFF POWER LIFTGATE OPEN/CLOSE SWITCH PWR REAR POWER SLIDING DOOR SWITCH RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT POWER SLIDING DOOR SWITCH RIGHT SIDE POWER SLIDING DOOR MODULE (ABOVE RIGHT REAR WHEELWELL) VREF RUN WIRE SIG RTN SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/WHT WIRE VPWR VREF WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/ORG WIRE YEL WIRE

ACCESSORY DELAY RELAY 1 ACCESSORY DELAY RELAY 2 AIR BAG DISABLE ILLUMINATION AUDIO UNIT AUTO DN BLK WIRE BRN WIRE BUSSED ELECTRICAL CENTER (BEC) (AT LEFT SIDE OF ENGINE COMPARTMENT) FUSE 10 CLOSE RELAY ILLUMINATION DK BLU WIRE FUSE 17 FUSE 5 FUSE 6 GRY WIRE HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION JOINT CONNECTOR 2 (BEHIND CENTER OF DASH) LEFT FRONT POWER WINDOW MOTOR (IN LEFT FRONT DOOR) LEFT REAR QUARTER WINDOW MOTOR (LEFT REAR OF VEHICLE) LOW CURRENT BOARD LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MASTER WINDOW/ DOOR LOCK/UNLOCK SWITCH ONE-TOUCH DN ONE-TOUCH DOWN POWER RELAY OPEN RELAY PASSENGER PNK WIRE POWER QUARTER WINDOW SWITCH RED WIRE RED/LT BLU WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (UNDER CENTER CONSOLE) RIGHT FRONT POWER WINDOW MOTOR (IN RIGHT FRONT DOOR) RIGHT REAR QUARTER WINDOW MOTOR (RIGHT REAR OF VEHICLE) RIGHT SIDE FRONT POWER WINDOW SWITCH SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE TAN/LT BLU WIRE VIO WIRE WHT WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

AIR BAG DISABLE ILLUM AIR BAG IND AND PINS 1-2, 3-4, 5-6, 7-8, 9-10, BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-L CAN-H COMPUTER DATA LINES SYSTEM DK BLU/ORG WIRE DK GRN/WHT WIRE DRIVER 1 SIDE IMPACT SENSOR (BELOW DRIVER'S SEAT) FORWARD CRASH SENSOR FUSE 17 GROUND GRY/LT BLU WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN START OR RUN ISO VPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE OCCUPANT CLASSIFICATION SENSOR MODULE (UNDER PASSENGER'S SEAT) ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE PASSENGER 1 SIDE IMPACT SENSOR (BELOW PASSENGER SEAT) PASSENGER SAFETY BELT BUCKLE SWITCH (IN PASSENGER'S SAFETY BELT BUCKLE) PASSENGER SAFETY BELT RETRACTOR PRETENSIONER (RIGHT OF CENTER CONSOLE) PASSENGER SAFETY BELT TENSION SENSOR (IN RIGHT "B" PILLAR) PNK WIRE PNK/BLK WIRE PNK/ORG WIRE PNK/WHT WIRE POWER QUARTER WINDOW SWITCH PWR RED WIRE RED/BLK WIRE RED/ORG WIRE RED/PNK WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (UNDER CENTER CONSOLE) SEAT WEIGHT PRESSURE SENSOR SHORTING BAR SIG SIG RTN SIG VREF SIG RTN GND CAN L CAN H VPWR SIG RTN PWR SIG SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TONE DRV IND CTRL VIO WIRE VIO/LT GRN WIRE VREF SIG RTN VREF SIG RTN VREF SIG RTN VREF SIG RTN VREF VREF VREF SIG RTN VREF SIG RTN WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE