Mercury Montego III (2004-2007) vio/lt grn Wiring diagrams

11 3 DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) 2 2 3 4 MTR RET GND SPD CTRL VPWR AMBIENT AIR TEMPERATURE SENSOR (BEHIND LEFT SIDE OF FRONT GRILLE) AUTOLAMP SENSOR AUTOLAMP/SUNLOAD SENSOR (TOP CENTER OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE DEFOGGER SYSTEM ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (CENTER OF DASH) FRONT BLOWER MOTOR (RIGHT SIDE OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT SIDE OF DASH) FUSE 20 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN RUN OR START IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) IND CTRL IND CTRL TEMP REQ LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/RED WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SEATS SYSTEM SENS SIG SENS SIG SIG RET SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SPD CTRL IND CTRL IND CTRL TEMP REQ SENS SIG SENS SIG RLY CTRL SUNLOAD SENSOR TAN/LT BLU WIRE VIO WIRE VIO/LT GRN WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE DRIVER SIDE FRONT HEATED SEAT MODULE (UNDER DRIVER SEAT) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (EATC) FIVE HUNDRED MONTEGO (BOTTOM LEFT "C"PILLAR) FIVE HUNDRED, MONTEGO FREESTYLE FUSE 23 GRY/LT BLU WIRE HIGH IND HOT AT ALL TIMES HOT IN RUN SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) FUSE 19 LEFT FRONT SEAT CUSHION HEATER (UNDER LEFT FRONT SEAT) LEFT SEATBACK HEATER LOW IND LT BLU/WHT WIRE NCA WIRE PASSENGER SIDE FRONT HEATED SEAT MODULE (UNDER PASSENGER SEAT) RIGHT FRONT SEAT CUSHION HEATER (UNDER RIGHT FRONT SEAT) VIO/LT BLU WIRE VIO/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT BLU WIRE

6 7 22 20 4 RR SW SIG LR SW SIG RF SW SIG LF SW SIG INHIBIT SW SIG ANTI-THEFT HOOD SWITCH (LEFT FRONT OF ENGINE COMPT) ANTI-THEFT INHIBIT SWITCH (CENTER OF DRIVER'S DOOR) BLK WIRE LEFT FRONT DOOR AJAR SWITCH (DRIVER'S DOOR LATCH ASSEMBLY) LEFT REAR DOOR AJAR SWITCH (LEFT REAR DOOR LATCH ASSEMBLY) LIFTGATE/DECKLID RELEASE SWITCH (EXC FREESTYLE) LOW CURRENT BOARD LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/ORG WIRE RED WIRE REL SW CTRL RIGHT FRONT DOOR AJAR SWITCH (FRONT PASSENGER'S DOOR LATCH ASSEMBLY) RIGHT REAR DOOR AJAR SWITCH (RIGHT REAR DOOR LATCH ASSEMBLY) SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SW SIG VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL WIRE YEL/LT GRN WIRE

6 7 22 20 4 RR SW SIG LR SW SIG RF SW SIG LF SW SIG INHIBIT SW SIG ANTI-THEFT HOOD SWITCH (LEFT FRONT OF ENGINE COMPT) ANTI-THEFT INHIBIT SWITCH (CENTER OF DRIVER'S DOOR) BLK WIRE LEFT FRONT DOOR AJAR SWITCH (DRIVER'S DOOR LATCH ASSEMBLY) LEFT REAR DOOR AJAR SWITCH (LEFT REAR DOOR LATCH ASSEMBLY) LIFTGATE/DECKLID RELEASE SWITCH (EXC FREESTYLE) LOW CURRENT BOARD LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PNK/ORG WIRE RED WIRE REL SW CTRL RIGHT FRONT DOOR AJAR SWITCH (FRONT PASSENGER'S DOOR LATCH ASSEMBLY) RIGHT REAR DOOR AJAR SWITCH (RIGHT REAR DOOR LATCH ASSEMBLY) SMART JUNCTION BOX (SJB) (LEFT SIDE OF DASH) SW SIG VIO WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL WIRE YEL/LT GRN WIRE

1 1 1 1 1 1 SIG RTN VREF SIG RTN VREF SIG RTN VREF 1-2, 3-4, 5-6, 13-14 1-2, 3-4, 5-6, 7-8, 9-10, 21-22 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 VPWR BLK WIRE BLK/ORG (OR WHT/LT BLU) WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DK GRN/WHT WIRE DRIVER SEAT BELT BUCKLE SENSOR (NEAR DRIVER SEAT) DRIVER SEAT BELT BUCKLE SWITCH (NEAR DRIVER SEAT) FUSE 21 FUSE 24 GRY/ORG WIRE GRY/WHT WIRE HOT IN START OR RUN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PASSENGER AIR BAG DEACTIVATION(PAD) INDICATOR PAD IND PASSENGER SEAT BELT BUCKLE SWITCH (NEAR PASSENGER SEAT) PASSENGER SEAT BELT TENSIONER PNK/BLK WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/ORG WIRE RED/PNK (OR BRN/LT BLU) WIRE RED/PNK WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (UNDER CENTER CONSOLE) SHORTING BAR SIG RTN VPWR SIG RTN VPWR SIG RTN VPWR SMART JUNCTION BOX (SJB) TAN WIRE TAN/LT BLU WIRE VIO WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VPWR SIG RTN SIGNAL 1 1 VREF SIG RTN SIG RTN VREF VREF SIG RTN VREF SIG RTN SUPP VOLT WHT LT GRN/ WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/ LT BLU WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BLK/LT BLU WIRE BLK/ORG (OR WHT/LT BLU) WIRE BLK/ORG WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CLOCK SPRING (ON STEERING COLUMN) COMPUTER DATA LINES SYSTEM DEPLOYABLE STEERING COLUMN DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER 1 SIDE AIR BAG SENSOR (UNDER LEFT FRONT SEAT) DRIVER 2 SIDE AIR BAG MODULE (IN FRONT DRIVERS SEAT) DRIVER SAFETY CANOPY MODULE (LEFT''C" PILLAR) GRY WIRE GRY/ LT BLU WIRE GRY/ORG WIRE GRY/WHT WIRE LEFT FORWARD CRASH SENSOR (AT FRONT CENTER OF VEHICLE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE OCCUPANT CLASSIFICANTION ORG/ WIRE ORG/BLU WIRE ORG/LT GRN WIRE PASSENGER 1 SIDE AIR BAG SENSOR (UNDER RIGHT FRONT SEAT) PASSENGER 2 SIDE AIR BAG MODULE (IN FRONT PASSENGER'S SEAT) PASSENGER AIR BAG MODULE (BEHIND RIGHT SIDE OF DASH) PASSENGER SAFETY CANOPY MODULE (RIGHT''C" PILLAR) WITH SIDE AIR CURTAIN PASSENGER SEAT SEAT BELT TENSIONER (UNDER PASSENGER'S PASSENGER SIDE AIR BAG MODULE (IN FRONT PASSENGER'S SEAT) PNK WIRE PNK/BLK WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/ORG WIRE RED/PNK (OR BRN/LTBLU) WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FORWARD CRASH SENSOR (AT FRONT CENTER OF VEHICLE) SAFETY CANOPY BRIDGE RESISTOR (LEFT''C" PILLAR) SEAT PRESSURE SENSOR (UNDER PASSENGER'S SEAT) SEAT) SENSOR(OCS) (IN FRONT PASSENGER'S SEAT BOTTOM) SHORTING BAR SIG VREF RTN SIG GND CAN+ CAN- VPWR RTN SIG VREF SIG STAGE 1 STAGE 1 DRIVER AIR BAG STAGE 2 TAN WIRE TAN/BLK WIRE TAN/RED WIRE VIO WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE WHT LT GRN/ WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE WITH SIDE AIR CURTAIN WITHOUT SIDE AIR CURTAIN YEL WIRE YEL/ LT BLU WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE

16 32 MS CAN - MS CAN + 23 7 20 6 22 VREF VREF VREF VREF VREF 24 7 26 8 VREF VREF VREF VREF 32 31 26 25 HS CAN - HS CAN + VREF VREF AUTOLAMPS BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLU WIRE BRN/LT BLU WIRE COMPUTER DATA LINES SYSTEM DK BLU/WHT WIRE DRIVER SAFETY BELT BUCKLE SWITCH FIVE HUNDRED, MONTEGO FREESTYLE FUSE 20 FUSE 23 FUSE 34 FUSE 7 HEAD HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER KEY-IN IGNITION SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT REAR DOOR AJAR SWITCH LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LIGHT SWITCH OFF PARK PARKING BRAKE SWITCH PASSENGER SAFETY BELT BUCKLE SWITCH PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (CENTER OF DASH) RIGHT FRONT DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH SMART JUNCTION BOX (LEFT SIDE OF DASH) TAN WIRE TAN/WHT WIRE VIO/LT GRN WIRE VPWR VPWR VBAT MS CAN + MS CAN - HS CAN - HS CAN + WHT WIRE WHT/BLK WIRE YEL WIRE YEL/LT GRN WIRE

BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/YEL WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE ELECTRIC EGR MOTOR (TOP RIGHT REAR OF ENGINE) EVAP CANISTER VENT CONTROL SOLENOID (RIGHT REAR OF TRUNK) FUSE 40 GRY/LT BLU WIRE HEATED OXYGEN SENSOR JUNCTION CONNECTOR 1 LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE ORG/ WIRE P/N SIG RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN STARTING/ CHARGING SYSTEM TAN/YEL WIRE VAPOR MANAGEMENT VALVE (RIGHT REAR OF ENGINE COMPT) VIO/LT GRN WIRE VIO/WHT WIRE VLT (START, RUN) WHT WIRE WHT/BLK WIRE WHT/RED WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE