Mercury Milan I (2005-2010) hot at all times Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 HS CAN + 1 2 ON/OFF SOL F DUTY SOL PCB 1 2 PWR GND +B 3 4 5 6 7 8 9 10 11 12 13 14 15 16 +BB 35 16 PCM CONTROL TRSW ANALOG RTN OIL TEMP + TSS - TSS + BATTERY JUNCTION BOX (BJB) (3.0L: LEFT SIDE OF BLK WIRE BLK/GRN WIRE BLU WIRE BLU/BRN WIRE BRN WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COUPLER ASSEMBLY 1 COUPLER ASSEMBLY 2 ENGINE COMPT) ENGINE CONTROLS SYSTEM FUSE GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) HS CAN+ INTERMEDIATE SHAFT SPEED ISS PS FWC TRS LINEAR PCA - LINEAR PCA + DUTY SOL C DUTY SOL A SYSTEM GND NCA WIRE NEUTRAL A ON/OFF SOL F ON/OFF SOL E ON/OFF SOL D DUTY SOL PCB DUTY SOL B ORG/ WIRE OUTPUT SHAFT SPEED (OSS) SENSOR PARK PARK/ NEUTRAL F PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF RANGE B RANGE C RED WIRE RELAY RLY GND OSS SENSOR (ISS) SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION TRANSMISSION FLUID PRESSURE SWITCH (LEFT SIDE OF TRANSMISSION) TRANSMISSION RANGE SENSOR (LEFT SIDE OF DASH) TURBINE SHAFT SPEED (TSS) VIO WIRE VIO/GRN WIRE VIO/GRY WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE

ACTIVE TORQUE CONTROL COUPLING SOLENOID (VEHICLE UNDERBODY, NEAR FUEL TANK) ALL WHEEL DRIVE CONTROL MODULE (LEFT KICK PANEL) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM FUSE GND ITCC SOL - HOT AT ALL TIMES HOT IN START OR RUN HS CAN + RUN/START B+ HS CAN+ ITCC SOL + NCA WIRE RED WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/RED WIRE WHT/VIO WIRE

BATTERY BLK WIRE BLU/ORG WIRE CHARGING INDICATOR COMPUTER DATA LINES SYSTEM FUSE FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- GEN COM GEN MON GENERATOR GRY WIRE HOT AT ALL TIMES HS CAN+ INSTRUMENT CLUSTER POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT) RED WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) VIO WIRE WHT WIRE WHT/BLU WIRE WHT/RED WIRE

6 SPEED TRANSMISSION ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/GRN WIRE BLU WIRE BPS BRAKE PEDAL POSITION SWITCH (LEFT SIDE OF DASH) BRN WIRE BSI SOL CMD COMPARTMENT) ENGINE CONTROL SYSTEM FLOOR SHIFTER FUSE 14 FUSE 19 FUSE 49 GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INHIBIT PARK PARK/ NEUTRAL PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE SHIFT LOCK SOLENOID SJB LOGIC SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) START LOCK TRANSMISSION TRANSMISSION RANGE SENSOR (LEFT SIDE OF DASH) TRSW VIO WIRE VIO/GRY WIRE VIO/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 3 3 MONO AUDIO OUT + MONO AUDIO OUT - MIC IN + MIN IN - STEREO IR + STEREO IR - 4 5 9 MIC + MIC - MIC SHLD - ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BASE AUDIO,PREMIUM, AUDIOPHILE THX AUDIO, NAVIGATION W/ NAVIGATION BATT AUDIO SHLD STEREO L(-) STEREO R(-) BATTERY JUNCTION BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX ANT COAX COAX COAX COAX SAT ANT ANT COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM END FM ANTENNA FUSE 20 (BASE OF LEFT "A" PILLAR) GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HS CAN + HS CAN - MEDIA MONO AUDIO SHLD MULTIMEDIA INSIDE MIRROR UNIT NCA WIRE PUSH PWR GND PWR GND 2 PWR GND RIGHT STEERING WHEEL SWITCH SEEK SEND SMART JUNCTION BOX (SJB) STEREO AUDIO STEREO IL + STEREO IL - MIC OUT + MIC OUT - STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 RTN MS CAN + MS CAN - TWISTED PAIR WIRES USB USB PORT VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 COMPUTER DATA LINES SYSTEM MS CAN(+) 1 2 3 4 5 6 7 8 NAV VOICE + NAV VOICE - NAV SHLD GND THX DSP CLIP ACCESSORY DELAY RELAY AM ANT AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BATTERY JUNCTION BOX (BJB) (2.3L: LEFT BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/WHT WIRE CIRCUIT BREAKER COAX COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEF PWR DEFOGGER SYSTEM FM ANT FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 20 FUSE 21 SIDE OF ENGINE COMPT) (3.0L: LEFT FRONT OF ENGINE COMPT) FUSE 22 FUSE 3 GPS ANTENNA GRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) HOT IN LF SPKR LF+ LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PIGTAIL WIRES PIGTAIL WIRES GPS SHLD GPS RF + RF - PWR GND SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) STEREO AUDIO SHLD STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 + SWC 1 + SWC 1 RTN VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE W/ NAVIGATION WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

BATTERY JUNCTION BOX (BJB) (2.3L: LEFT SIDE OF BLK/GRY WIRE BLK/VIO WIRE BRN WIRE FUSE 1 FUSE 16 FUSE ENGINE COMPARTMENT) (3.0L: LEFT FRONT OF ENGINE COMPARTMENT) GRN/WHT WIRE HOT AT ALL TIMES ILLUMINATION LOGIC LUGGAGE COMPARTMENT RELEASE SW LUGGAGE COMPARTMENT AJAR SW LUGGAGE COMPARTMENT LID RELEASE RELAY LUGGAGE COMPARTMENT LID RELEASE SWITCH LUGGAGE COMPARTMENT LID/ RELEASE SOLENOID/ AJAR SWITCH RED WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) VIO/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

3) 4) 5) OFF ON FRONT WASH SWITCH INT 4 INT 5 LOW HIGH WASH 6) 7) 8) 9) 10) BLK WIRE BLU WIRE BRN WIRE FRONT WIPER SWITCH FUSE FUSE 23 FUSE 9 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC LOGIC MFS CODE B MFS CODE C MFS MFS CODE A H LINE MFS W LINE MIST OFF INT 1 INT 2 INT 3 1) 2) MULTI- FUNCTION SWITCH ORG/ WIRE RED WIRE SMART JUNCTION BOX (SJB) SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) WIPER RUN/PARK COIL VIO WIRE WASHER PUMP RELAY WHT WIRE WINDSHIELD WIPER MOTOR (LEFT REAR OF ENGINE COMPT) WIPER MOTOR RELAY WIPER PARK WIPER PARK RELAY WIPER RUN/PARK RELAY YEL WIRE