Mercury Milan I (2005-2010) grn/vio Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 HS CAN + 1 2 ON/OFF SOL F DUTY SOL PCB 1 2 PWR GND +B 3 4 5 6 7 8 9 10 11 12 13 14 15 16 +BB 35 16 PCM CONTROL TRSW ANALOG RTN OIL TEMP + TSS - TSS + BATTERY JUNCTION BOX (BJB) (3.0L: LEFT SIDE OF BLK WIRE BLK/GRN WIRE BLU WIRE BLU/BRN WIRE BRN WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COUPLER ASSEMBLY 1 COUPLER ASSEMBLY 2 ENGINE COMPT) ENGINE CONTROLS SYSTEM FUSE GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) HS CAN+ INTERMEDIATE SHAFT SPEED ISS PS FWC TRS LINEAR PCA - LINEAR PCA + DUTY SOL C DUTY SOL A SYSTEM GND NCA WIRE NEUTRAL A ON/OFF SOL F ON/OFF SOL E ON/OFF SOL D DUTY SOL PCB DUTY SOL B ORG/ WIRE OUTPUT SHAFT SPEED (OSS) SENSOR PARK PARK/ NEUTRAL F PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF RANGE B RANGE C RED WIRE RELAY RLY GND OSS SENSOR (ISS) SENSOR (LEFT SIDE OF TRANSMISSION) TRANSMISSION TRANSMISSION FLUID PRESSURE SWITCH (LEFT SIDE OF TRANSMISSION) TRANSMISSION RANGE SENSOR (LEFT SIDE OF DASH) TURBINE SHAFT SPEED (TSS) VIO WIRE VIO/GRN WIRE VIO/GRY WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

BLK WIRE BLK/VIO WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BREAKOUT TO SMART JUNCTION BOX (SJB)) BRN WIRE COURTESY RELAY DEMAND LAMP/ BATTERY SAVER RELAY DIMMER SWITCH DOME DEMAND FRONT INTERIOR LAMP FUSE FUSE 12 GRN WIRE GRN/BLU WIRE GRN/RED WIRE GRN/VIO WIRE HOT AT ALL TIMES HOT W/ ACCESSORY DELAY RELAY ENERGIZED INSTRUMENT ILLUMINATION CIRCUIT LED SW BKLGT LEFT FRONT DOOR LOCK ACTUATOR (IN DRIVER'S DOOR) LEFT REAR DOOR LOCK ACTUATOR (IN LEFT REAR DOOR) LEFT VANITY MIRROR LAMP LOGIC LR PASS RR LUGG DOOR DOOR DOOR DOOR COMPT AJAR AJAR AJAR AJAR AJAR LUGGAGE COMPARTMENT LAMP ORG/ WIRE PANEL DIM GND PANEL DIMMING REAR INTERIOR LAMP RIGHT VANITY MIRROR LAMP SMART JUNCTION BOX (SJB) VIO WIRE VIO/GRY WIRE WHT WIRE WHT/BRN WIRE YEL WIRE YEL/ORG WIRE

2 6 5 BACKLIGHTING BATTERY GND AIR CONDITIONING SYSTEM AJAR SW B+ RUN/START BLK WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRY WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) LOGIC BRAKE FLUID LEVEL SWITCH BRN WIRE BRN/RED WIRE BRN/YEL WIRE CLOCK COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ANTI-THEFT SYSTEM ELECTROCHROMATIC INSIDE MIRROR UNIT (IN ROOF HARNESS) FUEL TANK UNIT FUSE GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HAZARD/PAD/TRACTION SWITCH HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER (IC) KEY IN LEFT FRONT DOOR LOCK ACTUATOR LEFT REAR DOOR LOCK ACTUATOR (IN LEFT REAR DOOR) LOGIC LOW OIL BRK FL PRESS LUGGAGE COMPARTMENT LID/ RELEASE SOLENOID/ AJAR SWITCH MESSAGE CENTER SWITCH MS MS CAN CAN MULTIMEDIA INSIDE MIRROR UNIT (W/ NAVIGATION) ORG/ WIRE PARK BRAKE SWITCH (UNDER CENTER CONSOLE) PARK RR PASS LR DR BRAKE DOOR DOOR DOOR DOOR SW AJAR AJAR AJAR AJAR RED WIRE RESET+ RIGHT FRONT DOOR LOCK ACTUATOR (IN RIGHT FRONT DOOR) RIGHT REAR DOOR LOCK ACTUATOR (IN RIGHT REAR DOOR) RUN/ACC KEY IN IGN SECONDARY FUEL SENDER (TOP OF FUEL TANK) SETUP INFO SMART JUNCTION TRACTION TRACTION CTL ON/OFF A/C REQ MS SW FUEL LEVEL 1 FUEL LEVEL 2 VIO WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/VIO WIRE

AUDIO ENABLE BLK WIRE BLK/YEL WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CENTER TWEETER CLOCKSPRING COMPUTER DATA LINES SYSTEM DIGITAL SIGNAL PROCSSIONG (DSP) MODULE (RIGHT REAR OF TRUNK COMPT) GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE INSTRUMENT PANEL SPEAKER LEFT FRONT SPEAKER LEFT FRONT TWEETER LEFT MID LEFT REAR SPEAKER LEFT THX SUBWOOFER SPEAKER MEDIA MS CAN - MS CAN + NAV IN + NAV IN - NCA WIRE REAR CENTER THX SPEAKER RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT MID RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH RIGHT THX SUBWOOFER SPEAKER SEEK TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) W/ NAVIGATION THX AUDIO W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE YEL/VIO WIRE

12 13 HS CAN + HS CAN - ABS CONTROL MODULE (RIGHT FRONT OF ENGINE COMPT) ACTUATOR (IN DRIVER'S DOOR) ACTUATOR (IN LEFT REAR DOOR) ACTUATOR (IN RIGHT FRONT DOOR) ACTUATOR (IN RIGHT REAR DOOR) AJAR AJAR SWITCH ANTI-THEFT HOOD SWITCH AUTOLAMP ON BLK/BLU WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE FLUID LEVEL SWITCH (LEFT REAR OF ENGINE COMPT) BRN/RED WIRE COMPUTER DATA LINES SYSTEM DRIVER SAFETY BELT BUCKLE SWITCH (UNDER RIGHT SIDE OF SEAT) DRV BUCKLE SW DRV DOOR AJAR FOG LAMP FUSE 25 GRN WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOOD AJAR HOT IN RUN OR START HS CAN+ IGNITION SWITCH INSTRUMENT CLUSTER (IC) KEY-IN IGN KEY-IN IGNITION SWITCH LEFT FRONT DOOR LOCK LEFT REAR DOOR LOCK LEFT TURN LOGIC LOW BEAM REQ LOW BRK FLUID LR DOOR AJAR LUGGAGE COMPARTMENT LID RELEASE SOLENOID LUGGAGE COMPT RELEASE SW MAIN LIGHT SWITCH MS CAN + MULTI- FUNCTION SWITCH OFF PARK PARK BRAKE SWITCH (UNDER CENTER CONSOLE) PARK BRK SW PARK LAMP ON PARK LAMPS PASS BUCKLE SW PASS DOOR PASSENGER SAFETY BELT BUCKLE SWITCH (LOWER LEFT SIDE OF SEAT TRACK) RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) RIGHT FRONT DOOR LOCK RIGHT REAR DOOR LOCK RIGHT TURN RR DOOR AJAR RUN/START VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/VIO WIRE YEL WIRE YEL/ORG WIRE