Mercury Milan I (2005-2010) defogger system Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 BATTERY BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/GRY WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CMD COMPUTER DATA LINES SYSTEM DEF REQUEST RECIRC CCW RECIRC CW IGN FEED BLEND INPUT VREF ACTUATORS DEFOGGER SYSTEM DR HSHI PASS REQUEST DR HS REQUEST DR HSLO ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (RIGHT SIDE OF DASH) FUSE GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES IGN FEED RUN/START BLEND FBK IN-VEHICLE TEMPERATURE SENSOR (LEFT SIDE OF DASH) MODE ACTUATOR FBK ACTUATORS RETURN MODE INPUT MS CAN - MS CAN + MOTOR+ MOTOR- VPWR CMD GND PSS HSLO IN CAR TEMP SENSOR RET 4 RED WIRE SEATS SYSTEM SUNLOAD SENSOR (RIGHT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR ANT SAT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER CLOCKSPRING COAX ANT COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR + SUBWOOFER + SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - SUBWOOFER - SUBWOOFER - LOGIC MEDIA MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR GND RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SHIELD SMART JUNCTION STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 15 14 SWC 2 RTN SWC 2 + ACCESSORY DELAY RELAY ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER CLOCKSPRING COAX ANT COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM END FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR + SUBWOOFER + SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - SUBWOOFER - SUBWOOFER - LOGIC MEDIA MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PUSH PWR GND RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SEND SHIELD SMART JUNCTION STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 GND 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 BATT POWER A/C REQ A/C REQ BACKLIGHTING GND AMP BLK WIRE BLK/GRY WIRE BLK/VIO WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLOWER RELAY BLU WIRE BLU/GRY WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DEFROST REQ RECIR DOOR CCW RECIR DOOR CW IGN FEED BLEND INPUT DRIVER TEMPERATURE BLEND DOOR ACTUATOR (CENTER OF DASH) FRESH/RECIRCULATION DOOR ACTUATOR (RIGHT SIDE OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (RIGHT SIDE OF DASH) FUSE FUSE 13 FUSE 23 FUSE 27 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/VIO WIRE GRY/YEL WIRE HIGH M HIGH M LOW HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN HS CAN+ IGN FEED R/S PASS TEMP FDBK INSTRUMENT CLUSTER MANUAL CLIMATE CONTROL MODULE (CENTER OF DASH) MODE ACT FDBK VREF RET ACT MODE INPUT MODE DOOR ACTUATOR (CENTER OF DASH) ORG/ WIRE RED WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/GRY WIRE YEL/VIO WIRE

ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) AUDIO SHIELD ENABLE AUDIOPHILE SOUND RADIO CIRCUIT BLK WIRE BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COAX COAX ANT SAT ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 18 FUSE 22 (BASE OF LEFT "A" PILLAR) FUSE 3 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT REAR SPEAKER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE RIGHT REAR SPEAKER SHIELD SMART JUNCTION BOX (SJB) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) AUDIO SHIELD ENABLE AUDIOPHILE SOUND RADIO CIRCUIT BLK WIRE BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COAX COAX SAT ANT ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 18 FUSE 22 (BASE OF LEFT "A" PILLAR) FUSE 3 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT REAR SPEAKER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE RIGHT REAR SPEAKER SHIELD SMART JUNCTION BOX (SJB) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 3 3 MONO AUDIO OUT + MONO AUDIO OUT - MIC IN + MIN IN - STEREO IR + STEREO IR - 4 5 9 MIC + MIC - MIC SHLD - ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BASE AUDIO,PREMIUM, AUDIOPHILE THX AUDIO, NAVIGATION W/ NAVIGATION BATT AUDIO SHLD STEREO L(-) STEREO R(-) BATTERY JUNCTION BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX ANT COAX COAX COAX COAX SAT ANT ANT COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM END FM ANTENNA FUSE 20 (BASE OF LEFT "A" PILLAR) GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HS CAN + HS CAN - MEDIA MONO AUDIO SHLD MULTIMEDIA INSIDE MIRROR UNIT NCA WIRE PUSH PWR GND PWR GND 2 PWR GND RIGHT STEERING WHEEL SWITCH SEEK SEND SMART JUNCTION BOX (SJB) STEREO AUDIO STEREO IL + STEREO IL - MIC OUT + MIC OUT - STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 RTN MS CAN + MS CAN - TWISTED PAIR WIRES USB USB PORT VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 COMPUTER DATA LINES SYSTEM MS CAN(+) 1 2 3 4 5 6 7 8 NAV VOICE + NAV VOICE - NAV SHLD GND THX DSP CLIP ACCESSORY DELAY RELAY AM ANT AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BATTERY JUNCTION BOX (BJB) (2.3L: LEFT BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/WHT WIRE CIRCUIT BREAKER COAX COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEF PWR DEFOGGER SYSTEM FM ANT FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 20 FUSE 21 SIDE OF ENGINE COMPT) (3.0L: LEFT FRONT OF ENGINE COMPT) FUSE 22 FUSE 3 GPS ANTENNA GRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) HOT IN LF SPKR LF+ LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PIGTAIL WIRES PIGTAIL WIRES GPS SHLD GPS RF + RF - PWR GND SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) STEREO AUDIO SHLD STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 + SWC 1 + SWC 1 RTN VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE W/ NAVIGATION WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE