Mercury Milan I (2005-2010) clockspring Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM FUSE 20 GRN/ORG WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT FRONT TWEETER MEDIA NCA WIRE PWR GND RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) STEREO L(+) STEREO R(+) MS CAN(-) TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 15 14 SWC 2 RTN SWC 2 + ACCESSORY PROTOCOL INTERFACE MODULE (APIM) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM END FUSE 20 GRN/ORG WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT FRONT TWEETER MEDIA NCA WIRE PUSH PWR GND RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SEND SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) STEREO L(+) STEREO R(+) MS CAN(-) TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR ANT SAT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER CLOCKSPRING COAX ANT COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR + SUBWOOFER + SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - SUBWOOFER - SUBWOOFER - LOGIC MEDIA MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR GND RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SHIELD SMART JUNCTION STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 15 14 SWC 2 RTN SWC 2 + ACCESSORY DELAY RELAY ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER CLOCKSPRING COAX ANT COAX COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM END FM ANTENNA FUSE FUSE 18 FUSE 20 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LF SPKR + SUBWOOFER + SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - SUBWOOFER - SUBWOOFER - LOGIC MEDIA MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PUSH PWR GND RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SEND SHIELD SMART JUNCTION STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

3.0L 2.3L 3.5L 56 57 2 3 66 69 68 67 17 58 SCCS SCCSRTN HS CAN + HS CAN - CASEGND 58 34 51 66 E SIGRTN TACM+ TACM- TPREF 59 60 TPRTN 6 SPEED TRANSMISSION 65 54 47 46 37 VSSIN KAPWR BPS BOO IGNITION ACCELERATOR PEDAL POSITION SENSOR BLK WIRE BLK/GRN WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/WHT WIRE BOO INPUT BRAKE PEDAL POSITION SWITCH BREAKOUT TO LEFT STEERING WHEEL SWITCH) (BEHIND AIR BAG, IN STEERING WHEEL) BRN WIRE BRN/GRN WIRE BRN/WHT WIRE CAN (+) CLOCKSPRING CLUTCH PEDAL SPEED CONTROL DEACTIVATOR SWITCH (M/T) (LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CPP TT C-SIGRTN ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE FUSE 21 FUSE 26 BOX (SJB) (BASE OF LEFT "A" PILLAR) GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN HOT W/ PCM POWER RELAY ENERGIZED LEFT STEERING WHEEL SWITCH OFF ORG/ WIRE OSS + OUTPUT SHAFT SPEED (OSS) SENSOR (2.3L, 5 SPEED M/T) (TOP OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RSM SET- SMART JUNCTION TRANSMISSION TRANSMISSIONS SYSTEM VIO WIRE VIO/BLK WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/RED WIRE WHT/VIO WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

BLK/GRY WIRE BLU/WHT WIRE CLOCKSPRING FUSE 2 HORN RELAY HOT AT ALL TIMES LEFT HORN LOGIC RIGHT HORN SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) SWITCH YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM FUSE 20 GRN/ORG WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT FRONT TWEETER MEDIA NCA WIRE PWR GND RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) STEREO L(+) STEREO R(+) MS CAN(-) TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 15 14 SWC 2 RTN SWC 2 + ACCESSORY PROTOCOL INTERFACE MODULE (APIM) BATT AUDIO SHLD STEREO L(-) STEREO R(-) BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM END FUSE 20 GRN/ORG WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT FRONT TWEETER MEDIA NCA WIRE PUSH PWR GND RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT STEERING WHEEL SWITCH SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (RIGHT REAR OF TRUNK) SEEK SEND SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) STEREO L(+) STEREO R(+) MS CAN(-) TWISTED PAIR WIRES VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 MS CAN+ 3 3 MONO AUDIO OUT + MONO AUDIO OUT - MIC IN + MIN IN - STEREO IR + STEREO IR - 4 5 9 MIC + MIC - MIC SHLD - ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BASE AUDIO,PREMIUM, AUDIOPHILE THX AUDIO, NAVIGATION W/ NAVIGATION BATT AUDIO SHLD STEREO L(-) STEREO R(-) BATTERY JUNCTION BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/WHT WIRE CLOCKSPRING COAX ANT COAX COAX COAX COAX SAT ANT ANT COAX DCBIAS/ANT COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM END FM ANTENNA FUSE 20 (BASE OF LEFT "A" PILLAR) GRN/ORG WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HS CAN + HS CAN - MEDIA MONO AUDIO SHLD MULTIMEDIA INSIDE MIRROR UNIT NCA WIRE PUSH PWR GND PWR GND 2 PWR GND RIGHT STEERING WHEEL SWITCH SEEK SEND SMART JUNCTION BOX (SJB) STEREO AUDIO STEREO IL + STEREO IL - MIC OUT + MIC OUT - STEREO L(+) STEREO R(+) MS CAN(-) SWC 2 RTN MS CAN + MS CAN - TWISTED PAIR WIRES USB USB PORT VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VOICE VOL (-) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE YEL/BLU WIRE YEL/GRN WIRE

AUDIO ENABLE BLK WIRE BLK/YEL WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CENTER TWEETER CLOCKSPRING COMPUTER DATA LINES SYSTEM DIGITAL SIGNAL PROCSSIONG (DSP) MODULE (RIGHT REAR OF TRUNK COMPT) GRN WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE INSTRUMENT PANEL SPEAKER LEFT FRONT SPEAKER LEFT FRONT TWEETER LEFT MID LEFT REAR SPEAKER LEFT THX SUBWOOFER SPEAKER MEDIA MS CAN - MS CAN + NAV IN + NAV IN - NCA WIRE REAR CENTER THX SPEAKER RIGHT FRONT SPEAKER RIGHT FRONT TWEETER RIGHT MID RIGHT REAR SPEAKER RIGHT STEERING WHEEL SWITCH RIGHT THX SUBWOOFER SPEAKER SEEK TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VOICE VOL (-) W/ NAVIGATION THX AUDIO W/ VOICE NAVIGATION WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE YEL/VIO WIRE