Mercury Milan I (2005-2010) blu/red Wiring diagrams

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

1 2 3 4 5 6 7 8 9 10 ENABLE CLIP GND AUDIO 1 2 3 4 5 6 7 8 SUBWOOFER + SUBWOOFER - AUDIO SHIELD ENABLE/CLIP 1 2 3 4 5 6 CHANNEL 1 + CHANNEL 1 - CHANNEL 2 + CHANNEL 2 - ACCESSORY DELAY RELAY AM ANT FM ANT DEF PWR AM ANTENNA ANT PWR ANT PWR SAT ANT ANT COAX COAX ANTENNA (FUSION, MILAN) (BASE OF RIGHT "C" PILLAR) ANTENNA MODULE (MKZ: RIGHT REAR OF TRUNK) AUDIO CONTROL MODULE (ACM) (CENTER OF DASH) AUDIO INPUT JACK (IN CENTER CONSOLE) BLK WIRE BLK/BLU WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN/BLU WIRE BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CIRCUIT BREAKER COAX COAX COAX COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM FM ANTENNA FUSE FUSE 17 FUSE 18 FUSE 22 FUSE 3 GRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INPUT INPUT LEFT REAR SPEAKER LEFT REAR SUBWOOFER LF SPKR + LR SUBWOOFER + RR SUBWOOFER + RF SPKR + RF SPKR - PWR GND LF SPKR - LR SUBWOOFER - RR SUBWOOFER - LOGIC MIC IN+ MIC IN- MIRRORS SYSTEM MS CAN - MS CAN + NCA WIRE PWR RIGHT REAR SPEAKER RIGHT REAR SUBWOOFER SHIELD SMART JUNCTION SUBWOOFER AMPLIFIER (FUSION, MILAN: RIGHT SIDE OF LUGGAGE COMPT) SWC 2 - SWC 2 + SWC 1 + SWC 1 RTN TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

3.5L ANTI-THEFT SYSTEM ANTI-LOCK BRAKES SYSTEM BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM FUSE 6 GRN WIRE GRN/RED WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HORN SW HORNS SYSTEM HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, AIR CONDITIONING SYSTEMS INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER, AIR CONDITIONING SYSTEMS SUPPLEMENTAL RESTRAINTS SYSTEM ORG/ WIRE POWER DISTRIBUTION SYSTEM RED WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) SOUND SYSTEMS ANTI-THEFT SYSTEM STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/GRN WIRE VIO/WHT WIRE VOLT IN RUN OR ACC VOLT SPLY AT ALL TIMES RIGHT TURN FRONT FOG COMMAND VOLT SPLY AT ALL TIMES VOLT SPLY IN START, RUN VOLT SPLY IN START VOLT SPLY IN START, RUN VOLT SPLY IN START, RUN VOLT SPLY IN START, RUN VOLT IN RUN OR ACC WASHER PUMP RELAY WIPER RUN/PARK COIL WHT WIRE WHT/ORG WIRE WHT/RED WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 MS CAN+ MS CAN- PCBLWCTL PBBLWCTL BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/YEL WIRE CLIMATE CONTROLLED SEAT SWITCHES MS CAN (+) MS CAN (-) COMPUTER DATA LINES SYSTEM DBLWR- DBLWR+ DCBLWCTL DBBLWCTL DCHSENS DCSHSENSRT DBKSENS DBKSENSRT DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE (CENTER OF DASH) DUAL CLIMATE CONTROLLED SEAT MODULE (UNDER SEAT BOTTOM) FUSE 11 FUSE 12 GRN WIRE GRN/BLK WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/VIO WIRE HOT AT ALL TIMES LEFT FRONT SEAT BACK HEATER (IN DRIVER'S SEAT BACK) LEFT FRONT SEAT CUSHION HEATER (IN SEAT CUSHION) NCA WIRE ORG/ WIRE PASSENGER'S SEAT BOTTOM) PBLWR- PBLWR+ PCSHSENS PCSHSENSRT PBKSENS PBKSENSRT RED WIRE RIGHT FRONT SEAT BACK HEATER (RIGHT SIDE OF FRONT PASSENGER'S SEAT BACK) RIGHT FRONT SEAT CUSHION HEATER VIO WIRE VIO/BLK WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/VIO WIRE

& RECEIVER 12 11 MS CAN- MS CAN+ 12 13 MS CAN + MS CAN - 12 6 MS CAN+ MS CAN- 14 15 (NOT USED) 15 16 15 16 MS CAN+ MS CAN- 2 1 15 14 MS CAN+ MS CAN- HS CAN+ HS CAN- 3 11 MS CAN + MS CAN - 54 53 17 16 HS CAN- HS CAN+ MS CAN- MS CAN+ 6 SPEED TRANSMISSION ABS CONTROL MODULE (RIGHT FRONT OF ENGINE COMPARTMENT) ACCESSORY PROTOCOL INTERFACE AUDIO CONTROL MODULE (ACM) AUDIO DIGITAL SIGNAL PROCESSING B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BASE THX AUDIO/ AUDIO/ AUDIO- NAVI- PHILE GATION BLK/VIO WIRE BLU WIRE BLU/RED WIRE DRIVER SEAT MODULE DRIVER'S DOOR MODULE (FRONT OF DRIVER'S DOOR) DUAL AUTOMATIC TEMPERATURE CONTROL DUAL CLIMATE CONTROLLED SEAT MODULE (DCSM) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL FEPS FEPS HS CAN- FUSE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ HS HS CAN+ CAN- INSTRUMENT CLUSTER MODULE MODULE (APIM) MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ NEAR BREAKOUT TO CLOCK) OCCUPANT CLASSIFICATION SYSTEM MODULE (OCSM) ORG/ WIRE PARKING AID MODULE (PAM) POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SATELLITE DIGITAL AUDIO RECEIVER SATELLITE RADIO RECEIVER SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) MS CAN- SYSTEM MODULE (W/ SATELLITE RADIO) TRANSMISSION VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

1 7 MS CAN+ MS CAN- 12 13 MS CAN + MS CAN - 14 15 (NOT USED) 15 16 15 16 MS CAN+ MS CAN- 2 1 15 14 MS CAN+ MS CAN- HS CAN+ HS CAN- 3 11 MS CAN + MS CAN - 6 SPEED TRANSMISSION ABS CONTROL MODULE (RIGHT FRONT OF ENGINE COMPARTMENT) ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AUDIO CONTROL MODULE (ACM) AUDIO DIGITAL SIGNAL PROCESSING (DSP) MODULE (W/ THX) B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BASE THX AUDIO/ AUDIO/ AUDIO- NAVI- PHILE GATION BLK/VIO WIRE BLU WIRE BLU/RED WIRE DUAL AUTOMATIC TEMPERATURE CONTROL ELECTRONIC AUTOMATIC TEMPERATURE CONTROL FEPS HS CAN- FUSE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HS CAN+ HS HS CAN+ CAN- HS HS FEPS CAN+ CAN- INSTRUMENT CLUSTER MODULE MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ NEAR BREAKOUT TO CLOCK) OCCUPANT CLASSIFICATION SYSTEM MODULE (OCSM) ORG/ WIRE PARKING AID MODULE (PAM) (W/ RPA) POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RADIO RECEIVER RED WIRE RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SATELLITE DIGITAL AUDIO RECEIVER SYSTEM MODULE (W/ SATELLITE RADIO) SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) MS CAN- TRANSMISSION VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

AUTO BATTERY JUNCTION BOX BLK/GRY WIRE BLK/VIO WIRE BLK/YEL WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BOO LR RR REDUNDANT TURN CHMSL TURN BRN/YEL WIRE COMPUTER DATA LINES SYSTEM FUSE 4 FUSE FUSE (3.0L: LEFT FRONT OF ENGINE COMPT) (2.3L: LEFT SIDE OF ENGINE COMPT) GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HAZARD LOGIC ON GND HEAD LOW PARK PARK- AUTO- BEAM LAMPS LAMP LAMP REQ ON OFF ON HOT AT ALL TIMES INSTRUMENT CLUSTER LEFT RIGHT FRONT FRONT PARK/ SIDE TURN LAMP LAMP PARK TURN LEFT TURN SIG LOGIC LOW PARK OFF LT BOO RT TURN INPUT TURN MAIN LIGHT SWITCH MS MS CAN CAN MULTI- FUNCTION SWITCH (LEFT SIDE OF DASH) TURN LEFT PARK LAMP RELAY PARK TURN PARK/ TURN LAMP RIGHT RIGHT FRONT RIGHT TURN SIG SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) TRACTION CTL ON/OFF VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/VIO WIRE YEL/GRY WIRE YEL/RED WIRE YEL/VIO WIRE

"A" PILLAR) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/RED WIRE BRN WIRE BRN/WHT WIRE DRIVER HS REQ DRIVER HSLO DRV BATT DRV HEATER FEED DRV HI LED IND DRV HIGH/LOW/OFF DRV LOW LED IND DRV NTC SENSE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE FUSE 11 FUSE 28 GRN WIRE GRY WIRE GRY/BLU WIRE GRY/YEL WIRE HEATED SEAT MODULE (UNDER SEAT BOTTOM) HOT AT ALL TIMES HOT IN START OR RUN LEFT FRONT SEAT BACK HEATER (IN DRIVER'S LEFT FRONT SEAT CUSHION HEATER (IN SEAT CUSHION) NCA WIRE NTC RETURN ORG/ WIRE PAN) PASS BATT PASS HEATER FEED PASS HI LED IND PASS HIGH/LOW/OFF PASS HS REQ PASS HSHI PASS HSLO PASS LOW LED IND PASS NTC SENSE RED WIRE RIGHT FRONT SEAT BACK HEATER (RIGHT SIDE OF FRONT PASSENGER'S SEAT BACK) RIGHT FRONT SEAT CUSHION HEATER (RIGHT SIDE OF FRONT PASSENGER'S SEAT BOTTOM) RUN/START SEAT BACK) SMART JUNCTION BOX (SJB) (BASE OF LEFT VIO WIRE VIO/BRN WIRE VIO/GRN WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLU WIRE YEL/GRY WIRE YEL/VIO WIRE

A/C EVAPORATIVE THERMISTOR (RIGHT SIDE OF DASH) AIR CONDITIONING SYSTEM APP 1 APP 2 APP 3 APPSREF 2 FTPTREF FPM APPSREF 1 BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE BLK/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE C VREF SMC PCM CONTROL C-SIGRTN COMPT) COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM EAIRM EVAP CANISTER VENT CONTROL SOLENOID (REAR OF VEHICLE CHASSIS) EVAPORATIVE EMISSION (EVAP) CANISTER PURGE VALVE (LOWER RIGHT STRUT TOWER) FC-V FUSE FUSE 3 FUSE 48 FUSE 49 FUSE 47 GRN/ BLU WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY/ORG WIRE GRY/RED WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN SMART JUNCTION FUSE BOX (SJB) (BASE OF LEFT "A" PILLAR) IAT IGNITION JUNCTION HARNESS, NEAR BREAKOUT TO POWERTRAIN CONTROL MODULE (PCM)) MAF MAF MAFRTN IAT FTPT INJPWRM BOO BPS MAFRTN OUTPUT SHAFT SPEED (OSS) SENSOR (M/T) (TOP OF TRANSMISSION) PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PWR GND SMR STARTING/CHARGING SYSTEM TRSW CPP TT CPP BT SDC VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

A/C EVAPORATIVE THERMISTOR (RIGHT SIDE OF DASH) A/C PRESSURE TRANSDUCER SENSOR (CENTER REAR OF ENGINE COMPT) ACET KAPWR FEPS SCCS SCCSRTN C SIGRTN APPSRTN 2 APPSRTN 1 CANVNT FPC ACPT ACCR AIR CONDITIONING SYSTEM APP 1 APP 2 APP 3 APPSREF 2 FTPTREF FPM APPSREF 1 BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK/GRN WIRE BLU/GRY WIRE BLU/RED WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/YEL WIRE C VREF SMC PCM CONTROL C-SIGRTN CASE GND PWR GND 1 PWR GND 2 PWR GND 3 COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM EVAP CANISTER VENT CONTROL SOLENOID (REAR OF VEHICLE CHASSIS) FC-V FUSE 23 FUSE 3 FUSE 47 FUSE 48 FUSE 49 GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) FUSE HS CAN + HS CAN - EVMV IAT IGNITION MAF MAF MAFRTN IAT FTPT INJPWRM BOO BPS MAFRTN PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PWR GND SMCS SMR STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TRSW VIO/BRN WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/RED WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE