Mercedes-Benz E-class W210/S210 facelift (1999-2003) instrument cluster Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 DIAG 30 15 DATA 31 PUMP VALVE A/C COMPRESSOR AAC CONTROL UNIT, MODULE AUX FAN BLK/RED WIRE BLK/YEL/GRN WIRE BLK/YEL/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/RED WIRE BLU/YEL WIRE BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/GRY WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE CAN L CMPR CLTCH COOLANT CIRCULATION PUMP DATA DATA LINK CONNECTOR (DLC) (DTC READOUT) (PARTIAL) DRIVER-SIDE FUSE, RELAY MODULE BOX DUOVALVE ELECTRONIC IGNITION- STARTER SWITCH (EIS) CONTROL MODULE EMISSIONS SENSOR EVAP EVAPORATOR TEMPERATURE SENSOR FUSE 7 FUSE, RELAY BOX FUSE 4 GRN/BLK WIRE GRN/BLU WIRE GRY/GRN WIRE GRY/PNK WIRE GRY/RED WIRE GRY/VIO WIRE GRY/WHT WIRE GRY/YEL WIRE HEATER CORE TEMPERATURE SENSOR HOT AT ALL TIMES HOT IN RUN, START IN-CAR INSTRUMENT CLUSTER LED RWD LEFT FRONT SIGNAL PICKUP, ACTIVATION MODULE (SAM) NCA WIRE PNK/GRN WIRE R VALVE RED/BLK WIRE RED/BLU WIRE RED/WHT WIRE REFRIGERANT PRESSURE SENSOR REFRIGERANT TEMPERATURE SENSOR RWD SW SMOG REF TEMP SOLID STATE SUN REF PRESS SUN SENSOR SWITCHOVER VALVE BLOCK WHT/PNK WIRE YEL/BLU WIRE

18 9 CAN H CAN L 30 CAN H CAN L 31 9 4 CAN H CAN L 9 8 10 1 13 14 16 17 18 1 CAN L CAN H BLK WIRE BLK/WHT WIRE BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/GRY WIRE BRN/RED WIRE BRN/VIO WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM FRONT DRIVER-SIDE DOOR CONTROL MODULE FRONT FUSE/RELAY BOX (ON LEFT REAR OF ENGINE COMPT) FUSE 3 FRONT PASSENGER SIDE DOOR CONTROL MODULE FUSE 1 FUSE 16 FUSE 18 FUSE 19 FUSE 2 FUSE 3 FUSE 4 FUSE 5 GLOVE COMPARTMENT LAMP GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACC, RUN OR START INSTRUMENT CLUSTER LEFT "D" PILLAR INTERIOR LAMP (WAGON) LEFT FRONT DOOR SWITCH LEFT FRONT ENTRANCE/ EXIT LAMP LEFT REAR DOOR ENTRANCE, EXIT LAMP LEFT REAR DOOR SWITCH LEFT SUN VISOR (W/ILLUMINATED VANITY MIRROR) PSE CONTROL MODULE (BELOW RIGHT REAR SEAT) REAR DOME LAMP REAR DRIVER-SIDE DOOR CONTROL MODULE REAR FUSE BOX (BELOW RIGHT REAR SEAT) REAR PASSENGER- SIDE DOOR CONTROL MODULE RED WIRE RED/BLK WIRE RED/GRN WIRE RED/GRY WIRE RED/WHT WIRE RED/YEL WIRE RIGHT "D" PILLAR INTERIOR LAMP (WAGON) RIGHT FRONT DOOR SWITCH RIGHT FRONT ENTRANCE/ EXIT LAMP RIGHT REAR DOOR ENTRANCE, EXIT LAMP RIGHT REAR DOOR SWITCH RIGHT SUN VISOR (W/ILLUMINATED VANITY MIRROR) ROOF CONTROL UNIT CONTROL MODULE SEDAN, LIMOUSINE SOLID STATE TRUNK LAMP (SEDAN, LIMOUSINE) TRUNK LAMP SWITCH (SEDAN, LIMOUSINE) TRUNK/TAILGATE/ FUEL DOORS SYSTEM WAGON WHT WIRE YEL WIRE

1 2 CAN H CAN L 1 2 CAN L CAN H 11 12 CAN H CAN L 2 5 CAN-H CAN-L A/C CONTROL UNIT, MODULE BLK/BLU WIRE BLU/RED WIRE BRAKE ASSIST (BAS) CONTROL MODULE BRN WIRE BRN/GRY WIRE CAN-H- CAN-L- DATA LINK CONNECTOR (DLC) (DTC READOUT) (ON LEFT REAR OF ENGINE COMPT) DRIVER-SIDE FUSE, RELAY MODULE BOX ELECTRONIC IGNITION- STARTER SWITCH (EIS) CONTROL MODULE EMERGENCY CALL SYSTEM CONTROL MODULE (TELE AID) ENGINE CONTROL MODULE (ME-SFI) ESP/SPS/BAS CONTROL MODULE FUSE 1 FUSE 4 GRN WIRE GRN/BLU WIRE GRN/VIO WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE HEADLAMP RANGE ADJUSTMENT CONTROL MODULE HOT IN ON OR START HOT AT ALL TIMES INSTRUMENT CLUSTER OPERATING-MONITORING- SYSTEM (OMS) OPERATING MODULE PASSENGER- SIDE FUSE, RELAY MODULE BOX RADIO RED/GRN WIRE RED/WHT WIRE SRS CONTROL MODULE TRANSMISSION CONTROL MODULE ULTRASONIC PTS CONTROLMODULE VALVE BLOCK RELAY MODULE VIO WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRY WIRE YEL WIRE YEL/BLU WIRE YEL/RED WIRE

4 2 (SEDAN/LIMO) (WAGON) AUDIBLE IND BACK- UP FOG STOP/ TAIL TAIL/ PARK TURN BACK- UP STOP/ TAIL BLK WIRE BLK/GRN WIRE BLK/RED WIRE BLK/RED/WHT WIRE BLK/WHT WIRE BLK/WHT/BLU WIRE BLK/YEL/WHT WIRE BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/RED WIRE COCKPIT SWITCH GROUP COMPUTER DATA LINES SYSTEM ELECTRONIC IGNITION - STARTER SWITCH CONTROL MODULE EXTERIOR LAMP FAILURE IND GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BLK WIRE GRY/BLK/VIO WIRE GRY/BLU WIRE GRY/GRN WIRE GRY/RED WIRE GRY/RED/VIO WIRE GRY/YEL WIRE GRY/YEL/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER LEFT FOOTWELL) LEFT OUTSIDE MIRROR LEFT TAILLAMP UNIT LEFT TURN IND LEFT TURN SIGNAL/SIDE MARKER LAMP OFF ON OFF RED WIRE RIGHT OUTSIDE MIRROR RIGHT TAILLAMP UNIT RIGHT TURN IND RIGHT TURN SIGNAL/SIDE MARKER LAMP SIGNAL PICKUP, ACTIVATION MODULE (SAM) TAIL/ PARK TERMINAL BLOCK TURN TURN SIGNAL LAMP VIO WIRE VIO/YEL WIRE W/ TURN SIGNAL LIGHTS IN EXTERIOR MIRRORS WHT WIRE YEL WIRE

1 3 (SEDAN, LIMOUSINE) (WAGON) BLK/WHT WIRE BLU/WHT WIRE BRN WIRE COMBINATION SWITCH ELECTRONIC IGNITION - STARTER SWITCH CONTROL MODULE FRONT FUSE/ RELAY BOX FUSE 3 GRY WIRE GRY/BLK WIRE GRY/GRN WIRE GRY/RED WIRE GRY/YEL WIRE HEADLAMP FLASHER/ HIGH BEAM SWITCH HI BEAM LAMP HI BEAM LAMP LO BEAM LAMP HIGH BEAM INDICATOR HOT IN ACCY, RUN AND START ILLUMINATION CONTROL MODULE (BEHIND LEFT SIDE OF DASH, PART OF HEADLIGHT SWITCH) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LEFT FOG LAMP RIGHT FOG LAMP LEFT HEADLAMP UNIT LEFT TAILLAMP UNIT REAR FOG LAMP LO BEAM LAMP NCA WIRE PNK/RED WIRE RIGHT HEADLAMP UNIT STANDING PARK LAMP VIO WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1 3 (SEDAN, LIMOUSINE) (WAGON) 3 1 VSS BLK/VIO WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/GRY WIRE BRN/WHT WIRE COMBINATION SWITCH DATA LINK CONNECTOR (DLC) (LEFT REAR OF ENGINE COMPT) ELECTRONIC IGNITION - STARTER SWITCH CONTROL MODULE FRONT AXLE LEVEL SENSOR (UNDERSIDE OF VEHICLE, ON FRONT SUSPENSION) FRONT FUSE/ RELAY BOX FUSE 15 FUSE 3 GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/BLK WIRE GRY/GRN WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLAMP FLASHER/ HIGH BEAM SWITCH HEADLIGHT RANGE ADJUSTMENT CONTROL MODULE (UNDER LEFT SIDE OF REAR SEAT) HIGH BEAM INDICATOR HIGH BEAM LAMP HOT IN ACCY, RUN AND START HOT IN RUN AND START ILLUMINATION CONTROL MODULE (BEHIND LEFT SIDE OF DASH, PART OF HEADLIGHT SWITCH) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LAMP LEFT FOG LAMP LEFT HEADLAMP UNIT LEFT TAILLAMP UNIT REAR FOG LAMP LOW BEAM XENON LAMP NCA WIRE PNK/RED WIRE REAR AXLE LEVEL SENSOR (UNDERSIDE OF VEHICLE, ON REAR SUSPENSION) RIGHT FOG LAMP RIGHT HEADLAMP UNIT STANDING/ PARKING LAMP STANDING/ PARKING LAMP HIGH BEAM VIO WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/BLK WIRE

1 2 4 CAN L CAN H 10 11 3 8 CAN H CAN L GRND HORN SW 6 7 2 CAN H CAN L BLK WIRE BLU WIRE BRN WIRE BRN/BLK WIRE BRN/RED WIRE COMPUTER DATA LINES SYSTEM DRIVER'S SIDE FUSE, RELAY MODULE BOX ELECTRONIC IGNITION - STARTER SWITCH CONTROL MODULE FANFARE HORN SWITCH FANFARE HORNS (BEHIND INSTRUMENT CLUSTER) FUSE 4 FUSE 5 HORN RELAY HORN/ AIRBAG CLOCK SPRING CONTACT HOT AT ALL TIMES INSTRUMENT CLUSTER LEFT MULTI- FUNCTION STEERING WHEEL PUSHBUTTON GROUP FANFARE HORN SWITCH LEFT MULTI-FUNCTION STEERING WHEEL PUSHBUTTON GROUP PNK WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM RED WIRE RIGHT MULTI-FUNCTION STEERING WHEEL PUSHBUTTON GROUP SIGNAL PICK-UP, ACTIVATION MODULE (SAM) TERMINAL 2.1 (LEFT FOOTWELL) YEL WIRE

"CHECK ENGINE" MIL 1 2 3 4 SCROLL FWD/ BACK BUTTON, SYSTEM SELECTION BUTTON 1 2 PNK WIRE ABS MIL IND AIR CONDITIONING SYSTEM BAS/ASR IND BLK WIRE BLK/GRN WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/GRY WIRE BRN/RED WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM ECL SWITCH ECT GAUGE ELECTRONIC IGNITION LOCK CONTROL MODULE ELECTRONIC SPEEDO- METER ESP WARNING IND EXTERIOR LIGHTS SYSTEM AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM FUEL LEVEL GAUGE FUEL LEVEL SENSOR (IN FUEL TANK, AT FRONT BULKHEAD IN TRUNK) FUEL RESERVE IND FUSE 10 FUSE 4 FUSE 7 FUSE, RELAY BOX (ON LEFT REAR OF ENGINE COMPARTMENT) GRN WIRE GRN/BLU WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HIGH BEAM IND HORN HORN/ AIRBAG CLOCK SPRING CONTACT HOT AT ALL TIMES HOT IN OFF, ACC OR RUN HOT IN RUN OR START HYDRAULIC FLUID LEVEL SWITCH ILLUMINATION CONTROL MODULE (CANADA) INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION (4 BULBS) INSTRUMENT, SEARCH ILLUMINATION PUSHBUTTON (BRIGHT) INSTRUMENT, SEARCH ILLUMINATION PUSHBUTTON (DARK) LCS SWITCH LEFT FRONT DOOR SWITCH LEFT FRONT SEAT BELT/ COMFORT SWITCH (IN DRIVER'S SEAT BELT BUCKLE) LEFT MULTIFUNCTION STEERING WHEEL PUSHBUTTON GROUP LEFT TURN SIGNAL INDICATOR LOW BRAKE FLUID LEVEL/ PARKING BRAKE INDICATOR LAMP MULTI-FUNCTION DISPLAY ILLUM MULTI-FUNCTION DISPLAY ILLUM (WHITE) NCA WIRE PNK/BLU WIRE PSE CONTROL MODULE (BELOW RIGHT REAR SEAT) RED WIRE RED/YEL WIRE RIGHT MULTIFUNCTION STEERING WHEEL PUSHBUTTON GROUP RIGHT TURN SIGNAL INDICATOR SEAT BELT REMINDER IND SOLID STATE SOUND SYSTEM/ NAVIGATION SYSTEM SPECIAL FUNCTIONS, VOLUME, ACCEPT/ TERMINATE PHONE CALL BUTTON SRS IND STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TRIP ODO- METER RESET PUSHBUTTON VIO WIRE WARNING BUZZER WHT WIRE WHT/BLK WIRE WINDSHIELD WASHER FLUID LEVEL SWITCH (ON TOP OF WASHER FLUID RESERVOIR) YEL WIRE

2 1 CARGO AREA CONNECTOR BOX 31 CAN L CAN H 9 4 CAN H CAN L BLK WIRE BLK/RED WIRE BLK/RED/VIO WIRE BLU WIRE BLU/GRN WIRE BRN WIRE BRN/RED WIRE CAN L CENTER AIR OUTLET ILLUMINATION COCKPIT SWITCH GROUP COMPUTER DATA LINES SYSTEM CTEL TRANSMITTER/ RECEIVER (ON LEFT SIDE OF TRUNK) EMERGENCY CALL SYSTEM PUSHBUTTON (TELE AID) EMERGENCY CALL SYSTEM SERVICE, BREAKDOWN SERVICE PUSHBUTTON GROUP ESP OFF SWITCH FRONT CIGAR LIGHTER FRONT DRIVER-SIDE DOOR CONTROL MODULE FRONT FUSE/ RELAY BOX (ON LEFT REAR OF ENGINE COMPT) FUSE 11 FRONT HEATED SEAT CONTROL MODULE FRONT PASSENGER SIDE DOOR CONTROL MODULE FUSE 1 FUSE 16 FUSE 18 FUSE 2 FUSE 3 GRN WIRE GRY WIRE GRY/BLU WIRE GRY/VIO WIRE HAZARD FLASHER SWITCH HOT AT ALL TIMES HOT IN ACC, RUN OR START ILLUMINATION CONTROL MODULE (BEHIND LEFT SIDE OF DASH, PART OF HEADLIGHT SWITCH) INSTRUMENT CLUSTER LEFT FRONT DOOR ESA SWITCH GROUP (WITH MEMORY) LEFT FRONT HEATED SEAT SWITCH LEFT REAR POWER WINDOW SWITCH LOWER CONTROL FIELD CONTROL MODULE NCA WIRE OUTSIDE REARVIEW MIRROR SWITCH (WITH FOLD-IN/ OUT FEATURE) PNK WIRE PTS CONTROL MODULE PTS ON/OFF SWITCH RADIO REAR DRIVER-SIDE DOOR CONTROL MODULE REAR FUSE BOX (BELOW RIGHT REAR SEAT) REAR PASSENGER- SIDE DOOR CONTROL MODULE REAR WINDOW SUNSHADE SWITCH RED WIRE RED/BLK WIRE RED/GRN WIRE RED/GRY WIRE RED/YEL WIRE RIGHT AIR OUTLET ILLUMINATION RIGHT FRONT DOOR ESA SWITCH GROUP (WITH MEMORY) RIGHT FRONT HEATED SEAT SWITCH RIGHT REAR POWER WINDOW SWITCH SOLID STATE VALVE BLOCK RELAY MODULE VIO WIRE YEL WIRE

2 1 W/ ACOUSTIMASS BASS MODULE ASR/SPS CONTROL MODULE OR ETS/SPS CONTROL MODULE OR ESP/SPS/BAS CONTROL MODULE BLK WIRE BLK/VIO WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/WHT WIRE BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/PNK WIRE BRN/RED WIRE BRN/VIO WIRE BRN/WHT WIRE CD CHANGER CTEL TRANSMITTER/ RECEIVER (ON LEFT SIDE OF TRUNK) FM/AM AMPLIFIER FUSE 16 FUSE 5 GRN WIRE GRY WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (STEERING WHEEL CONTROLS) LEFT FRONT AXLE VSS SENSOR LEFT FRONT DOOR SPEAKER GROUP LEFT REAR DOOR SPEAKER LEFT REAR SPEAKER LEFT/RIGHT AUDIO POWER AMPLIFIER (AT LEFT WHEELWELL, IN TRUNK) NCA WIRE OPTICS CONNECTOR ORG/ WIRE PNK WIRE RADIO REAR FUSE BOX (BELOW RIGHT REAR SEAT) REAR WINDOW ANTENNA RED/BLU/WHT WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER GROUP RIGHT REAR DOOR SPEAKER RIGHT REAR SPEAKER SEDAN VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE