Lincoln MKZ I (2006-2009) 6 speed transmission Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 B(+) 6 SPEED TRANSMISSION BLK WIRE BLK/GRN WIRE BRN/GRN WIRE COMPUTER DATA LINES SYSTEM FUSE GND OD CANCEL IGNITION GRN WIRE GRN/ORG WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN HS CAN+ ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE SHIFT INTERLOCK SYSTEM SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) START LOCK HS CAN - TRSW VIO WIRE VIO/RED WIRE WHT WIRE WHT/BLU WIRE

1 13 HS CAN+ HS CAN- 2 3 HS CAN + HS CAN - 21 5 TRS ANALOG RTN 3 2 RANGE B RANGE C 6 14 5 HS CAN- HS CAN+ START LOCK 6 SPEED TRANSMISSION BLK WIRE BLK/GRY WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM EARLY PRODUCTION LATE PRODUCTION FUSE 1 FUSION, MILAN GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/VIO WIRE HOT AT ALL TIMES LEFT REVERSING LAMP LOGIC MS CAN - MS CAN + NCA WIRE ORG/ WIRE REVERSING LAMPS RELAY (NON-SERVICEABLE) RIGHT REVERSING LAMP SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) TRANSMISSION TRANSMISSION RANGE SENSOR (LEFT SIDE OF DASH) TRANSMISSIONS SYSTEM TRSW VIO WIRE WHT WIRE WHT/BLU WIRE

11 12 MS CAN + MS CAN - 12 13 MS CAN + MS CAN - 12 6 MS CAN+ MS CAN- 14 15 (NOT USED) 15 16 15 16 MS CAN+ MS CAN- 2 1 15 14 MS CAN+ MS CAN- HS CAN+ HS CAN- 6 SPEED TRANSMISSION ABS CONTROL MODULE (RIGHT FRONT OF ENGINE COMPARTMENT) ALL WHEEL DRIVE CONTROL MODULE (LEFT KICK PANEL) AUDIO UNIT (CENTER B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BASE AUDIO/ AUDIO- PHILE THX AUDIO/ NAVI- GATION BLK/VIO WIRE BLU WIRE BLU/RED WIRE DRIVER SEAT MODULE DRIVER'S DOOR MODULE DUAL AUTOMATIC TEMPERATURE CONTROL ELECTRONIC AUTOMATIC TEMPERATURE CONTROL FEPS FEPS HS CAN- FUSE GRY WIRE GRY/ORG WIRE HEATED/COOLED SEAT MODULE (UNDER SEAT BOTTOM) MS CAN- HOT AT ALL TIMES HS CAN + HS CAN - HS CAN+ HS CAN+ HS CAN- HS CAN+ INSTRUMENT CLUSTER MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ OCCUPANT CLASSIFICATION SENSOR (OCS) (IN SEAT CUSHION) OF DASH) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SATELLITE RADIO RECEIVER SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) MS CAN- THX AMPLIFIER (WITH THX) TRANSMISSION VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

1 7 MS CAN+ MS CAN- 12 13 MS CAN + MS CAN - 14 15 (NOT USED) 15 16 15 16 MS CAN+ MS CAN- 2 1 15 14 MS CAN+ MS CAN- HS CAN+ HS CAN- 6 SPEED TRANSMISSION ABS CONTROL MODULE (RIGHT FRONT OF ENGINE COMPARTMENT) ALL WHEEL DRIVE CONTROL MODULE (LEFT KICK PANEL) AUDIO UNIT (CENTER OF DASH) B+ DATA LINK CONNECTOR (DLC) (LEFT SIDE OF DASH) BASE AUDIO/ AUDIO- PHILE THX AUDIO/ NAVI- GATION BLK/VIO WIRE BLU WIRE BLU/RED WIRE DUAL AUTOMATIC TEMPERATURE CONTROL ELECTRONIC AUTOMATIC TEMPERATURE CONTROL FEPS HS CAN- FUSE FUSION, MILAN GRY WIRE GRY/ORG WIRE HEATED/COOLED SEAT MODULE (UNDER SEAT BOTTOM) HOT AT ALL TIMES HS CAN+ HS CAN+ HS CAN- HS CAN+ HS CAN- FEPS INSTRUMENT CLUSTER MS CAN + MS CAN+ PWR GND SIG GND HS CAN+ OCCUPANT CLASSIFICATION SENSOR (OCS) (IN SEAT CUSHION) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) PROCESSING (DSP) MODULE) RED WIRE RESTRAINTS CONTROL MODULE (RCM) (UNDER CENTER CONSOLE) SATELLITE RADIO RECEIVER SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) MS CAN- THX AMPLIFIER (W/ THX) TRANSMISSION VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLU WIRE

6 SPEED TRANSMISSION A/C CLUTCH FIELD COIL ABS CONTROL MODULE ANTI-THEFT HOOD SWITCH BATTERY BLK WIRE BRAKE FLUID LEVEL SWITCH CLUTCH PEDAL POSITION (CPP) SWITCH ENGINE COOLING FAN MOTOR FOG LAMP RELAY GRN WIRE GRY WIRE HORN LEFT FRONT FOG LAMP WINDSHIELD WIPER MOTOR LEFT FRONT PARK/TURN LAMP LEFT HEADLAMP LEFT HIGH INTENSITY DISCHARGE HEADLAMP RELAY MASS AIR FLOW/ INTAKE AIR TEMPERATURE (MAF/IAT) SENSOR NCA WIRE OUTPUT SHAFT SPEED (OSS) SENSOR PETA PUMP MOTOR POWERTRAIN CONTROL MODULE (PCM) RIGHT FRONT FOG LAMP RIGHT FRONT PARK/TURN LAMP RIGHT HEADLAMP RIGHT HIGH INTENSITY DISCHARGE HEADLAMP RELAY SHIELD TRANSMISSION TRANSMISSION RANGE SENSOR VIO WIRE WINDSHIELD WASHER PUMP MOTOR WIPER PARK RELAY YEL WIRE

6 SPEED TRANSMISSION A/C CLUTCH RELAY AUDIO UNIT BASE/ AUDIOPHILE AUDIO BLOWER MOTOR RELAY BLU WIRE BRN WIRE COMPASS MODULE RESTRAINTS CONTROL MODULE HAZARD/ PAD/ TRACTION SWITCH COURTESY RELAY (FUSION/ MILAN) DEMAND LAMP/ BATTERY SAVER RELAY EARLY PRODUCTION EARLY PRODUCTION LATE PRODUCTION FLOOR SHIFTER FOG LAMP RELAY FROM FUSE 2 BATTERY JUNCTION BOX (DIAGRAM 2 OF 3) FROM FUSE 23 BATTERY JUNCTION BOX (DIAGRAM 1 OF 3) FROM FUSE 6 BATTERY JUNCTION BOX (DIAGRAM 1 OF 3) FROM SPLICE FUEL PUMP RELAY FUSE FUSE 10 FUSE 11 FUSE 14 FUSE 16 FUSE 22 FUSE 24 FUSE 25 FUSE 25 FUSE 24 FUSE 26 FUSE 27 FUSE 28 FUSE 3 FUSE 30 FUSE 4 FUSE 7 FUSE 9 GRN WIRE GRY WIRE HEATED SEAT MODULE ALL WHEEL DRIVE CONTROL MODULE HIGH CURRENT PETA PUMP RELAY IGNITION SWITCH INHIBIT INSTRUMENT CLUSTER JUNCTION BOX (BJB)) KEY-IN IGNITION SWITCH LATE PRODUCTION LEFT HIGH INTENSITY DISCHARGE HEADLAMP RELAY LOCK OCCUPANT CLASSIFICATION SENSOR (OCS) MODULE OFF ORG/ WIRE PARK LAMP RELAY HORN RELAY HI BEAM RELAY REVERSING LAMPS RELAY PCM POWER RELAY POWERTRAIN CONTROL MODULE (PCM) (EXCEPT 2.3L) RED WIRE RELAY RIGHT HIGH INTENSITY DISCHARGE HEADLAMP RELAY RUN WIRE SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) STARTER RELAY THX AUDIO / NAVIGATION TO ACCESSORY DELAY RELAY SMART JUNCTION BOX (DIAGRAM 3 OF 3) TO BATTERY JUNCTION BOX (BJB)) TO FUSE 10 BATTERY JUNCTION BOX (DIAGRAM 2 OF 3) TO FUSE 23 SMART JUNCTION BOX (DIAGRAM 3 OF 3) TO SMART JUNCTION BOX (DIAGRAM 3 OF 3) VIO WIRE WHT WIRE WHT/RED WIRE WIPER PARK RELAY WIPER RUN/PARK RELAY YEL WIRE

6 SPEED TRANSMISSION ACCESSORY DELAY RELAY ALL- WHEEL DRIVE CONTROL MODULE BASE/ AUDIOPHILE AUDIO BLK WIRE BOX (SJB) (BASE OF LEFT "A" PILLAR) BRN WIRE CIRCUIT BREAKER DECKLID RELEASE RELAY DRIVER UNLOCK RELAY DRIVER DOOR MODULE DRIVER SIDE DOOR LOCK SWITCH (FUSION/ MILAN) ENGINE COOLING FAN MOTOR EXTERIOR REAR VIEW MIRROR SWITCH FROM FUSE 13 SMART JUNCTION BOX (DIAGRAM 1 OF 3) FROM FUSE 26 SMART JUNCTION BOX (DIAGRAM 3 OF 3) FROM FUSE 3 SMART JUNCTION BOX (DIAGRAM 2 OF 3) FROM IGNITION SWITCH (DIAGRAM 2 OF 3) FROM SPLICE FRONT CIGAR LIGHTER (FUSION/ MILAN) FRONT CIGAR LIGHTER (MKZ) FUEL PCM POWER PUMP RELAY DIODE FUSE 12 FUSE 15 FUSE 16 FUSE 20 FUSE 23 FUSE 26 FUSION, MILAN GRN WIRE GRY WIRE INSTRUMENT CLUSTER LOCK ALL RELAY LOGIC MASTER WINDOW ADJUST SWITCH NCA WIRE NEAR BREAKOUT TO MASTER WINDOW ADJUST SWITCH) ORG/ WIRE PASSENGER SIDE DOOR LOCK SWITCH (FUSION/ MILAN) PASSIVE ANTI-THEFT TRANSCEIVER MODULE POWERTRAIN CONTROL MODULE (PCM) POWERTRAIN CONTROL MODULE) (EXCEPT 3.5L: NEAR ENGINE BULKHEAD GROMMET) RED WIRE REVERSING LAMPS SWITCH ROOF OPENING PANEL MODULE SATELLITE RADIO RECEIVER SMART JUNCTION THX AUDIO/ NAVIGATION AUDIO UNIT TO CIGAR LIGHTER (DIAGRAM 3 OF 3) UNLOCK ALL RELAY VIO WIRE WHT WIRE WIPER BLOWER RUN/PARK RELAY MOTOR RELAY YEL WIRE

6 SPEED TRANSMISSION BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLU WIRE BRN WIRE BSI SOL CMD FLOOR SHIFTER FUSE 14 FUSE 19 GRN WIRE GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INHIBIT LATE PRODUCTION LED SW BKLGT O/D PARK RED WIRE SHIFT LOCK SOLENOID SJB LOGIC SMART JUNCTION BOX (SJB) (BASE OF LEFT "A" PILLAR) VIO WIRE VIO/GRY WIRE

6 SPEED TRANSMISSION BLK WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/ORG WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE CRANKSHAFT POSITION SENSOR (LOWER LEFT REAR OF ENGINE BLOCK) ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (LEFT REAR OF ENGINE) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (FRONT OF ENGINE) GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HEATED POSITIVE CRANKCASE VENTILATION (PCV) VALVE IGNITION TRANSFORMER CAPACITOR 1 (TOP REAR OF RIGHT CYLINDER HEAD) IGNITION TRANSFORMER CAPACITOR 2 (TOP REAR OF LEFT CYLINDER HEAD) LOCK START NCA WIRE ORG/ WIRE ORG/GRY WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BLU WIRE WHT/BRN WIRE YEL WIRE YEL/ORG WIRE YEL/VIO WIRE