Automatic a/c circuit for Lincoln Aviator I (2002-2005)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 SCP - GND IGN RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ACT POT - 1 2 3 4 5 6 RS GND 1 2 3 4 5 VBC FB VAR SPEED IN HBR SWITCH IN MOTOR GROUND A/C CLUTCH RELAY A/C DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) CLUSTER POWER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 23 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (ON LEFT SIDE OF DASH) INBOARD INSTRUMENT CLUSTER J/C 1 J/C 2 2 1 9 10 11 LEFT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE MICROPROCESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE R DEF OUT BLOWER CTRL RLY R DEF SWITCH RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) RIGHT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) SUN LOAD SENS SUNLOAD SENSOR (AT TOP CENTER OF DASH) TAN/ LT GRN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBC FB SENS GND IN CAR TEMP CONTROL SW ACT POT WIPER ACT POT WIPER SCP + VBC HBR PASS MTR 2 PASS MTR 1 MOTOR DRV 1 MOTOR DRV 2 RS GND VBC OUT SUN LOAD R AMB TEMP SUN LOAD L VIO/YEL WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLK WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR 22 9 57 LED A/C CLU RLY SCCS A/C CLUTCH SOLENOID (RIGHT SIDE OF ENGINE, ON A/C COMPRESSOR) AIR BAG SLIDING CONTACT AUDIO/CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) AUXILIARY MODE ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) AUXILIARY TEMPERATURE ACTUATOR (AT LEFT REAR OF VEHICLE) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLIMATE GND COOL DK BLU/LT GRN WIRE DK GRN/YEL WIRE FAN UP TEMP UP FAN DN FRONT AUXILIARY A/C SWITCH (IN OVERHEAD CONSOLE) FUSE 10 FUSE 33 GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE OF ENGINE FIREWALL) REAR AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY RED/BLK WIRE RED/ORG WIRE TAN WIRE TAN/ LT GRN WIRE TEMP DN WARM WHT WIRE YEL WIRE YEL/BLK WIRE