Lincoln Aviator I (2002-2005) (near breakout to dual automatic temperature control module) Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 SCP - GND IGN RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ACT POT - 1 2 3 4 5 6 RS GND 1 2 3 4 5 VBC FB VAR SPEED IN HBR SWITCH IN MOTOR GROUND A/C CLUTCH RELAY A/C DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) CLUSTER POWER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 23 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (ON LEFT SIDE OF DASH) INBOARD INSTRUMENT CLUSTER J/C 1 J/C 2 2 1 9 10 11 LEFT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE MICROPROCESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE R DEF OUT BLOWER CTRL RLY R DEF SWITCH RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) RIGHT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) SUN LOAD SENS SUNLOAD SENSOR (AT TOP CENTER OF DASH) TAN/ LT GRN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBC FB SENS GND IN CAR TEMP CONTROL SW ACT POT WIPER ACT POT WIPER SCP + VBC HBR PASS MTR 2 PASS MTR 1 MOTOR DRV 1 MOTOR DRV 2 RS GND VBC OUT SUN LOAD R AMB TEMP SUN LOAD L VIO/YEL WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLK WIRE

AUXILIARY JUNCTION BOX (AJB) (RIGHT SIDE OF ENGINE COMPT, AT FENDER APRON) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE CARGO LAMP ASSEMBLY CARGO SPACE LAMP DOME ON OFF LOCKED OFF 1 2 3 DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT INTERIOR MAP LAMPS ASSEMBLY (ON FRONT OF ROOF) FUSE FUSE 25 GLOVE BOX LAMP) GRY WIRE HOMELINK MODULE HOMELINK MODULE (EARLY PRODUCTION) (ON FRONT OF ROOF) HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE HOT IN RUN OR START INBOARD INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX) JOINT CONNECTOR 4 (IN REAR AUXILIARY JUNCTION BOX) LATE PRODUCTION LEFT EXTERIOR REAR VIEW MIRROR LEFT FRONT FOOTWELL LAMP LEFT VANITY MIRROR LAMP LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH MICROPROCESSOR NEAR LEFT "B" PILLAR) ON WITH DOOR OPEN 5 6 MANUAL ON OFF ORG/ WIRE PNK WIRE PUDDLE LAMP RELAY REAR INTERIOR/ MAP LAMPS ASSEMBLY RED/WHT WIRE RIGHT EXTERIOR REAR VIEW MIRROR RIGHT FRONT FOOTWELL LAMP RIGHT VANITY MIRROR LAMP VIO WIRE YEL WIRE

A/C CLUTCH RELAY ACCESSORY DELAY RELAY AUDIO UNIT AUXILIARY A/C RELAY AUXILIARY TEMPERATURE ACTUATOR BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, FENDER APRON) BLK WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) TO FUSE 8 (DIAGRAM 4 OF 4) CENTRAL SECURITY MODULE (CSM) DK BLU WIRE DK GRN WIRE DRIVER MEMORY SEAT MODULE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE ELECTRONIC COMPASS ENGINE COOLING FAN RELAY FROM CIRCUIT BREAKER 62 (DIAGRAM 1 OF 4) FROM FUSE 1 (DIAGRAM 1 OF 4) FROM FUSE 23 (DIAGRAM 1 OF 4) FROM FUSE 26 (DIAGRAM 4 OF 4) FROM IGNITION RELAY (DIAGRAM 1 OF 4) FRONT AUXILIARY A/C SWITCH FUSE 1 FUSE 10 FUSE 15 FUSE 2 FUSE 21 FUSE 22 FUSE 27 FUSE 3 FUSE 30 FUSE 5 FUSE 8 GRY WIRE HIGH BEAM RELAY INBOARD INSTRUMENT CLUSTER INDICATOR FLASHER RELAY J/C 1 LOW TIRE PRESSURE MODULE LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTIFUNCTION SWITCH NAVIGATION ELECTRONIC CONTROL UNIT (ECU) MODULE NAVIGATION HEAD UNIT ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR WINDOW DEFROST RELAY RED WIRE ROOF OPENING PANEL MOTOR ASSEMBLY LEFT POWER SEAT SWITCH TO FUSE 14 (DIAGRAM 2 OF 4) VARIABLE ASSIST POWER STEERING (VAPS) MODULE VARIABLE ASSIST POWER STEERING (VAPS) MODULE PARKING AID MODULE (PAM) W/ GEN 2 CONNECTORS W/O GEN 2 CONNECTORS W/ NAV RADIO W/O NAV RADIO WHT WIRE WHT/VIO WIRE YEL WIRE