Lincoln Aviator I (2002-2005) j/c 1 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 SCP - GND IGN RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ACT POT - 1 2 3 4 5 6 RS GND 1 2 3 4 5 VBC FB VAR SPEED IN HBR SWITCH IN MOTOR GROUND A/C CLUTCH RELAY A/C DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) CLUSTER POWER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 23 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (ON LEFT SIDE OF DASH) INBOARD INSTRUMENT CLUSTER J/C 1 J/C 2 2 1 9 10 11 LEFT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE MICROPROCESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE R DEF OUT BLOWER CTRL RLY R DEF SWITCH RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) RIGHT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) SUN LOAD SENS SUNLOAD SENSOR (AT TOP CENTER OF DASH) TAN/ LT GRN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBC FB SENS GND IN CAR TEMP CONTROL SW ACT POT WIPER ACT POT WIPER SCP + VBC HBR PASS MTR 2 PASS MTR 1 MOTOR DRV 1 MOTOR DRV 2 RS GND VBC OUT SUN LOAD R AMB TEMP SUN LOAD L VIO/YEL WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLK WIRE

A/C CLUTCH RELAY ACCESSORY DELAY RELAY AUDIO UNIT AUXILIARY A/C RELAY AUXILIARY TEMPERATURE ACTUATOR BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, FENDER APRON) BLK WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) TO FUSE 8 (DIAGRAM 4 OF 4) CENTRAL SECURITY MODULE (CSM) DK BLU WIRE DK GRN WIRE DRIVER MEMORY SEAT MODULE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE ELECTRONIC COMPASS ENGINE COOLING FAN RELAY FROM CIRCUIT BREAKER 62 (DIAGRAM 1 OF 4) FROM FUSE 1 (DIAGRAM 1 OF 4) FROM FUSE 23 (DIAGRAM 1 OF 4) FROM FUSE 26 (DIAGRAM 4 OF 4) FROM IGNITION RELAY (DIAGRAM 1 OF 4) FRONT AUXILIARY A/C SWITCH FUSE 1 FUSE 10 FUSE 15 FUSE 2 FUSE 21 FUSE 22 FUSE 27 FUSE 3 FUSE 30 FUSE 5 FUSE 8 GRY WIRE HIGH BEAM RELAY INBOARD INSTRUMENT CLUSTER INDICATOR FLASHER RELAY J/C 1 LOW TIRE PRESSURE MODULE LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTIFUNCTION SWITCH NAVIGATION ELECTRONIC CONTROL UNIT (ECU) MODULE NAVIGATION HEAD UNIT ORG/ WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR WINDOW DEFROST RELAY RED WIRE ROOF OPENING PANEL MOTOR ASSEMBLY LEFT POWER SEAT SWITCH TO FUSE 14 (DIAGRAM 2 OF 4) VARIABLE ASSIST POWER STEERING (VAPS) MODULE VARIABLE ASSIST POWER STEERING (VAPS) MODULE PARKING AID MODULE (PAM) W/ GEN 2 CONNECTORS W/O GEN 2 CONNECTORS W/ NAV RADIO W/O NAV RADIO WHT WIRE WHT/VIO WIRE YEL WIRE

1257 1258 1259 1260 SIGNAL + SIGNAL - SIGNAL + SIGNAL - 1 1 1 1261 1262 1263 1264 SIGNAL + REF/GND SIGNAL + REF/GND 608 1003 1003 1390 AIR BAG IND CTRL VBATT VBATT TONE DRIVER 617 618 SIGNAL + REF/GND BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DATA BUS VBATT AIR BAG STAGE 2+ AIR BAG STAGE 2- DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRIVER 1 SIDE IMPACT SENSOR (UNDER DRIVER'S SEAT) DRIVER SAFETY BELT RETRACTOR PRETENSIONER (UNDER DRIVER'S SEAT) DRIVER'S SAFETY BELT BUCKLE SWITCH (UNDER DRIVER'S SEAT) DUAL AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (UNDER LEFT DASH PANEL) FUSE GRN WIRE GRY WIRE GRY/ORG WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER J/C 1 LOGIC GROUND LT BLU WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT LT MICRO- PROCESSOR NOTE: 1: UNBUCKLED 2: BUCKLED ORG/ WIRE PASSENGER 1 SIDE IMPACT SENSOR (UNDER FRONT PASSENGER'S SEAT) PASSENGER SAFETY BELT RETRACTOR PRETENSIONER (UNDER PASSENGER'S SEAT) PASSENGER'S SAFETY BELT BUCKLE SWITCH (UNDER PASSENGER'S SEAT) PNK/BLK WIRE PNK/ORG WIRE RED WIRE RED/ORG WIRE RED/WHT WIRE RESTRAINT CONTROL MODULE (RCM) (BELOW CENTER CONSOLE) SHORTING BAR TAN/BLK WIRE TWISTED PAIRS WIRES VIO/LT GRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

848 151 928 CRUISE CONTROL SYSTEM ANTI-THEFT SYSTEM AUDIO UNIT NAVIGATION HEAD UNIT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) BRN/WHT WIRE CAN VENT VSS IND CTRL RLY CTRL TPS OUT TX SIG EVAP PU FEPS IN RX SIG CD X 6 RADIO W/ GEN 2 CONN CHARGING SYSTEM A/C SYSTEM TRANSMISSION CONTROL SYSTEM COOL FAN V REF COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL/ ANTI- LOCK BRAKES SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK GRN/ ORG WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE EVAPORATIVE EMISSION (EVAP) CANISTER VENT VALVE (LEFT REAR OF VEHICLE) F PMP MTR SCP BUS + SCP BUS - FUSE 15 FUSE 39 FUSE 38 FUSE 37 FUSE 40 FUSE 41 FUSE 45 GROUND BATTERY SCC SCM C A/C SW GROUND GROUND GROUND GROUND PRES SW SCM A ACP SW IN MAF OUT IGN IGN GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT IN TANK PRESS IND INPUT J/C 1 LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MASS AIRFLOW (MAF) SENSOR (RIGHT FRONT OF ENGINE COMPARTMENT) ORG DK GRN/ WIRE ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER PCM DIODE PCM POWER RELAY FUSE 11 PNK/LT BLU WIRE PNK/YEL WIRE POWER STEERING PRESSURE SWITCH (IN FRONT OF ENG COMPT) POWERTRAIN CONTROL MODULE (AT RIGHT SIDE OF ENGINE FIREWALL) RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RETURN SCM B PSPS VREF SENS RTN ST MTR BOO SW TCS OCS SHIFT INTERLOCK SYSTEM SPD SW SPD SW RLY CTRL STARTING SYSTEM TAN/BLK WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE VAPOR MANAGE- MENT VALVE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/WHT WIRE VIO/YEL WIRE W/ IVD W/O GEN 2 CONN WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/WHT WIRE