Lincoln Aviator I (2002-2005) fuse 23 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 SCP - GND IGN RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ACT POT - 1 2 3 4 5 6 RS GND 1 2 3 4 5 VBC FB VAR SPEED IN HBR SWITCH IN MOTOR GROUND A/C CLUTCH RELAY A/C DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) CLUSTER POWER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 23 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (ON LEFT SIDE OF DASH) INBOARD INSTRUMENT CLUSTER J/C 1 J/C 2 2 1 9 10 11 LEFT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE MICROPROCESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE R DEF OUT BLOWER CTRL RLY R DEF SWITCH RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) RIGHT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) SUN LOAD SENS SUNLOAD SENSOR (AT TOP CENTER OF DASH) TAN/ LT GRN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBC FB SENS GND IN CAR TEMP CONTROL SW ACT POT WIPER ACT POT WIPER SCP + VBC HBR PASS MTR 2 PASS MTR 1 MOTOR DRV 1 MOTOR DRV 2 RS GND VBC OUT SUN LOAD R AMB TEMP SUN LOAD L VIO/YEL WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLOCK COMPASS COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM DAYTIME RUNNING LAMPS (DRL) MODULE (LEFT REAR SIDE DEFOGGER SYSTEM POWER WINDOWS SYSTEM INTERIOR LIGHTS SYSTEM DK BLU WIRE DK GRN/VIO WIRE ELECTRONIC COMPASS FUEL TANK SENDING UNIT (INSIDE FUEL TANK) FUSE 15 FUSE 20 FUSE 23 FUSE 30 GND ILLUM HIGH BEAM RPA FAULT KEY WARNING SW IN COMPASS - COMPASS + ACC FEED GRY/LT BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START IGNITION SWITCH INBOARD, OUTBOARD INSTRUMENT CLUSTER INTERIOR LIGHTS INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM NAVIGATION SYSTEM JOINT CONNECTOR 1 KEY IN IGNITION LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MESSAGE CENTER SWITCH OF ENGINE COMPT) OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE BLOCK) ORG/ WIRE ORG/YEL WIRE PARK BRAKE SWITCH (UNDER DRIVER SIDE DASH PANEL) PNK/BLK WIRE PNK/LT BLU WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE SUPPLEMENTAL RESTRAINTS SYSTEM SYSTEM TAN/ORG WIRE V IGN VIO/ORG WIRE WASHER FLUID LEVEL SWITCH (RIGHT FRONT OF ENGINE COMPT) WHT/BLK WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

AIR BAG IND BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 15 BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND RIGHT REAR SEAT) CHIME DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRIVER BUCKLE SIGNAL DRIVER SAFETY BELT BUCKLE SWITCH (UNDER DRIVER SEAT) FUSE 12 FUSE 15 FUSE 23 FUSE 30 GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN IGNITION RUN/ACC IGNITION RUN/START IGNITION SWITCH INDICATOR INSTRUMENT CLUSTER KEY IN IGNITION LEFT FRONT DOOR AJAR SWITCH LF DR AJAR LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/VIO WIRE ORG/ WIRE PASS BUCKLE SIGNAL PASSENGER SAFETY BELT BUCKLE SWITCH (UNDER PASSENGER SEAT) PNK WIRE PNK/BLK WIRE RED WIRE RED/LT GRN WIRE RESTRAINTS CONTROL MODULE (BELOW CENTER CONSOLE) SEAT BELT WARNING UBP VBATT VIO WIRE WASHER FLUID LEVEL WASHER FLUID LEVEL SWITCH (RIGHT FRONT OF ENGINE COMPT) WHT WIRE YEL WIRE YEL/BLK WIRE

ABS CONTROL MODULE AUXILIARY A/C RELAY AUXILIARY JUNCTION BOX (AJB) (RIGHT SIDE OF ENGINE COMPT, AT FENDER APRON) BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLOWER MOTOR RELAY HORN RELAY BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) CIRCUIT BREAKER 62 DAYTIME RUNNING LAMPS (DRL) MODULE DK GRN WIRE FOUR WHEEL DRIVE CONTROL MODULE REAR WIPER MOTOR ASSEMBLY FROM FUSE 19 (DIAGRAM 1 OF 4) FROM FUSE 6 (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 1 FUSE 11 FUSE 12 FUSE 13 FUSE 16 FUSE 17 FUSE 18 FUSE 2 FUSE 9 FUSE 20 FUSE 19 FUSE 23 FUSE 24 FUSE 36 FUSE 26 FUSE 27 FUSE 3 OPEN FUSE 33 FUSE 34 FUSE 29 FUSE 30 FUSE 35 FUSE 4 FUSE 5 FUSE 10 FUSE 7 FUSE 6 FUSIBLE LINK A FUSIBLE LINK B (12 GA- FUSIBLE LINK C GENERATOR GRY WIRE IGNITION RELAY J/C 1 (IN BJB) LEFT HID HEADLAMP RELAY LEFT TURN RIGHT TURN TRAILER TOW TRAILER TOW RELAY RELAY LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH ORG/ WIRE PCM RELAY PNK WIRE REAR AUXILIARY JUNCTION BOX (AJB) (IN RIGHT REAR OF CARGO AREA) REAR WINDOW DEFROST RELAY RED WIRE RIGHT HID HEADLAMP RELAY RIGHT REAR POWER POINT STARTER MOTOR STARTER MOTOR RELAY TAN WIRE TO ACCESSORY DELAY RELAY (DIAGRAM 3 OF 4) TO FUSE 10 (DIAGRAM 3 OF 4) TO FUSE 11 (DIAGRAM 1 OF 4) TO FUSE 15 (DIAGRAM 3 OF 4) TO FUSE 16 (DIAGRAM 4 OF 4) TO FUSE 26 (DIAGRAM 1 OF 4) TO FUSE 5 (DIAGRAM 3 OF 4) TO IGNITION SWITCH (DIAGRAM 2 OF 4) TRAILER ELECTRONIC BRAKE CONTROL MODULE LEFT FRONT POWER WINDOW MOTOR TRAILER TOW BATTERY CHARGE RELAY TRAILER TOW REVERSING LAMPS RELAY TRAILER TOW PARKING LAMP RELAY VIO WIRE WHT WIRE WINDSHIELD WIPER MOTOR YEL WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE SHIFT MODULE (BELOW CENTER CONSOLE) BRAKE APPLIED CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CONS GND FUSE 13 FUSE 14 FUSE 20 FUSE 23 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION SWITCH KEY IN/OUT KEY REMOVAL INHIBIT SOLENOID LT BLU WIRE LT GRN WIRE OD SW PARK DET SW PWM DIM PNK WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE OF ENGINE FIREWALL) PRNDL RED WIRE TAN WIRE VBATT IGN W/ IVD WHT WIRE YEL WIRE

BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 29 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LOWER LEFT SIDE OF TRANSMISSION) DK GRN WIRE FUSE 12 FUSE 23 IGNITION SWITCH LOCK LT BLU WIRE LT GRN/VIO WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE FIREWALL) RED WIRE RED/LT BLU WIRE RUN WIRE STARTER MOTOR WHT/PNK WIRE YEL WIRE YEL/LT BLU WIRE