Lincoln Aviator I (2002-2005) blk Wiring diagrams

ABS CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BPP SIG VPWR RR WHEEL SPEED - RR WHEEL SPEED + BRAKE APPLIED RELAY BRAKE BOOSTER SENSOR (ON FRONT OF BRAKE BOOSTER) BRAKE FLUID LEVEL SWITCH (MOUNTED ON TOP OF BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION SENSOR (ON FRONT OF BRAKE BOOSTER) BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE FUSE 10 FUSE 14 FUSE 22 FUSE 21 FUSE 5 GND BST PWR BP PWR BP GND BP SIG GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START INTERACTIVE VEHICLE DYNAMICS (IVD) SWITCH (BEHIND CENTER OF DASH) IVD OFF IVD ON LEFT FRONT WHEEL SPEED SENSOR LEFT REAR WHEEL SPEED SENSOR LF WHEEL SPEED + LF WHEEL SPEED - GND LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT NCA WIRE ORG/ WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PRIMARY BRAKE PRESSURE SENSOR (ON BRAKE MASTER CYLINDER) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR RIGHT REAR WHEEL SPEED SENSOR SCP + OFF LED SCP - STEERING POSITION SENSOR (ON STEERING COLUMN) STEERING RATE SENSOR TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE YAW RATE SENSOR (BELOW CENTER CONSOLE) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BPS SIG BPP SW BRAKE FLUID LEVEL SWITCH (MOUNTED ON TOP OF BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION SWITCH (BPP) (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FLUID LEVEL RTN FLUID LEVEL SW FUSE 10 FUSE 14 FUSE 22 FUSE 45 FUSE 5 GRN WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START LEFT FRONT WHEEL SPEED SENSOR LF WHEEL SPEED + LF WHEEL SPEED - GND LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE ORG/ WIRE PNK/LT BLU WIRE REAR AXLE SPEED - REAR AXLE SPEED + REAR AXLE SPEED SENSOR RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SCP+ TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBATT RF WHEEL SPEED - RF WHEEL SPEED + VIO/WHT WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 SCP - GND IGN RUN/START 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ACT POT - 1 2 3 4 5 6 RS GND 1 2 3 4 5 VBC FB VAR SPEED IN HBR SWITCH IN MOTOR GROUND A/C CLUTCH RELAY A/C DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) CLUSTER POWER COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MODULE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 23 FUSE 30 FUSE 36 FUSE 37 GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR (ON LEFT SIDE OF DASH) INBOARD INSTRUMENT CLUSTER J/C 1 J/C 2 2 1 9 10 11 LEFT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE MICROPROCESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE R DEF OUT BLOWER CTRL RLY R DEF SWITCH RED/WHT WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) RIGHT TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) SUN LOAD SENS SUNLOAD SENSOR (AT TOP CENTER OF DASH) TAN/ LT GRN WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VBC FB SENS GND IN CAR TEMP CONTROL SW ACT POT WIPER ACT POT WIPER SCP + VBC HBR PASS MTR 2 PASS MTR 1 MOTOR DRV 1 MOTOR DRV 2 RS GND VBC OUT SUN LOAD R AMB TEMP SUN LOAD L VIO/YEL WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/BLK WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR 22 9 57 LED A/C CLU RLY SCCS A/C CLUTCH SOLENOID (RIGHT SIDE OF ENGINE, ON A/C COMPRESSOR) AIR BAG SLIDING CONTACT AUDIO/CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) AUXILIARY MODE ACTUATOR (LEFT SIDE, BEHIND REAR SEATS) AUXILIARY TEMPERATURE ACTUATOR (AT LEFT REAR OF VEHICLE) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLIMATE GND COOL DK BLU/LT GRN WIRE DK GRN/YEL WIRE FAN UP TEMP UP FAN DN FRONT AUXILIARY A/C SWITCH (IN OVERHEAD CONSOLE) FUSE 10 FUSE 33 GRY/LT BLU WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE OF ENGINE FIREWALL) REAR AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY RED/BLK WIRE RED/ORG WIRE TAN WIRE TAN/ LT GRN WIRE TEMP DN WARM WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND RIGHT REAR SEAT) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DRIVER MEMORY SEAT MODULE (IN BOTTOM OF DRIVER SEAT) DRIVER SIDE CLIMATE CONTROLLED SEAT MODULE (IN BOTTOM OF DRIVER SEAT) DUAL AUTOMATIC TEMPERATURE CONTROL MODULE FOUR-WHEEL DRIVE CONTROL MODULE (BELOW CENTER CONSOLE) FUSE 16 HOT AT ALL TIMES LOW TIRE PRESSURE MODULE (UNDER RIGHT REAR PASSENGER SEAT) LT BLU WIRE LT BLU/WHT WIRE NAVIGATION ELECTRONIC CONTROL UNIT MODULE (BOTTOM OF REAR CARGO AREA) NCA WIRE ORG/ WIRE OUTBOARD INSTRUMENT CLUSTER PARKING AID MODULE (IN RIGHT REAR END OF CARGO AREA) PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE OF ENGINE FIREWALL) TAN WIRE TAN/ORG WIRE VARIABLE ASSIST POWER STEERING MODULE (BEHIND RIGHT SIDE OF DASH) WHT WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE

17 46 SIG RTN SENSOR SIG BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE COOLING FAN ENGINE COOLING FAN MOTOR (IN FRONT OF ENGINE COMPARTMENT) ENGINE COOLING FAN RELAY (IN AUXILIARY JUNCTION BOX) FUSE 8 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES LT GRN WIRE LT GRN/RED WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE OF ENGINE FIREWALL) RED WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE BPS BPS IN BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) BRN/WHT WIRE CANCEL OFF COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/ORG WIRE FUSE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START J/C 2 (IN BATTERY JUNCTION BOX) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE OUTBOARD INSTRUMENT CLUSTER PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE OF ENGINE FIREWALL) RED WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) SCC SCCS SCM A SCM B SCM C SCP BUS (+) SCP+ SET- SET+ RES SPEED CONTROL ACTUATOR (RIGHT SIDE OF ENGINE COMPARTMENT, ON FENDER) SPEED CONTROL SWITCH SPEED CTRL SW GND TAN WIRE TAN/ORG WIRE VBATT VIO/YEL WIRE W/ IVD W/O IVD WHT/LT BLU WIRE

1 2 3 4 VPWR GND TX SIG RX SIG BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 26 GRY/ORG WIRE HOT IN RUN OR START ORG/ WIRE PASSIVE ANTI-THEFT (PATS) POWERTRAIN CONTROL MODULE (AT RIGHT SIDE OF ENGINE FIREWALL) RED WIRE RED/YEL WIRE STARTER MOTOR RELAY TX OUT RX IN WHT/LT GRN WIRE YEL WIRE

ANTI- THEFT HOOD SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT, ON FENDER) ANTI-THEFT ALARM INHIBIT SWITCH (IN DRIVER DOOR, NEAR LATCH ASSEMBLY) AUXILIARY JUNCTION BOX (AJB) (RIGHT SIDE OF ENGINE COMPT, AT FENDER APRON) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (CSM) (BEHIND RIGHT REAR SEAT) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 16 FUSE 2 FUSE 22 FUSE 9 GRY WIRE GRY/RED WIRE HEADLAMP SW HEADLIGHTS SYSTEM HORNS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES LEFT FRONT DOOR AJAR SWITCH (NEAR LEFT ``B" PILLAR) LEFT REAR DOOR AJAR SWITCH LIFTGATE AJAR SWITCH LIFTGATE DISARM SWITCH (IN CENTER OF TAILGATE) LIFTGATE GLASS AJAR SWITCH LIFTGATE LOCK ACTUATOR LIFTGATE LOCK ACTUATOR RELAY LR DOOR AJAR LIFTGATE AJAR DRV DIS SW GROUND LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE ORG/ WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWER WINDOWS SYSTEM RED WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE VIO WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

1/2 3/4 5/6 7/8 9/0 BLK WIRE BRN WIRE DRIVER SIDE DOOR LOCK SWITCH GRY/RED WIRE KEY PAD SWITCH ASSEMBLY LEFT FRONT DOOR LOCK ACTUATOR LEFT REAR DOOR LOCK ACTUATOR LICENSE PLATE ASSEMBLY LIFTGATE DOOR LOCK SWITCH LOCK LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE NEAR LEFT "B" PILLAR) ORG/ WIRE PASSENGER SIDE DOOR LOCK SWITCH PNK PNK WIRE PNK WIRE PNK/ (BETWEEN RIGHT SIDE ``A", ``B" PILLARS) WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/ORG WIRE RIGHT FRONT DOOR LOCK ACTUATOR RIGHT REAR DOOR LOCK ACTUATOR TAN WIRE UNLK UNLK LOCK YEL WIRE