Kia Rio III (2011-2015) pcm Wiring diagrams

A/T A/V, NAVIGATION HEAD UNIT ATM SHIFT LEVER ILL AUDIO B/UP LP FUSE BACK UP LAMP BACK-UP LAMP SWITCH BACK-UP LAMP SWITCH (TOP OF TRANSAXLE) BCM BCM (UNDER LEFT SIDE OF DASH) BLK WIRE BRN WIRE E/R-EGGGB EGGG-AA ENGINE ROOM JUNCTION BOX GRN WIRE HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-E IND LEFT REAR COMBINATION LAMP (IN) LEFT REAR COMBINATION LAMP (IN) BACK-UP LAMP M/T NAVIGATION NCA WIRE ON/START INPUT ORG/ WIRE PCB FUSE, RELAY BOX PCB FUSE, RELAY BOX (INTEGRAL TO PCM PCM (LEFT REAR OF ENGINE COMPT) PNK EGGG-AA WIRE PNK WIRE POSI SW CODE R IND RED WIRE RIGHT REAR COMBINA- TION LAMP (IN) RIGHT REAR COMBINATION LAMP (IN) RIGHT REAR COMBINATION LAMP (IN) BACK-UP LAMP SIG (1) SIG (2) SIG 3 SIG 4 TCU FUSE TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UVO AUDIO UVO AUDIO NAVIGATION

A/C CONTROL MODULE A/C CONTROL MODULE (AUTO A/C) A/T A/V, NAVIGATION A/V, NAVIGATION HEAD UNIT ABS 1 FUSE ALT FUSE ALT FUSE FUSE AUDIO BCM BCM (UNDER LEFT SIDE OF DASH) BLK WIRE BLU WIRE BRN WIRE COMPT) DATA LINK CONNECTOR DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) E/R JUNCTION BOX ECM (LEFT REAR OF ENGINE COMPT) EGGG-AK EGGG-MK FUSE HEAD UNIT HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-B I/P-C I/P-E IMMOBILIZER MODULE IMMOBILIZER MODULE (W/O SMART KEY) INSTRUMENT CLUSTER M/T MULTI FUSE MULTI- MULTIPURPOSE CHECK CONNECTOR NAVIGATION PCM PCM (LEFT REAR OF ENGINE COMPT) PNK WIRE RED WIRE SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (IF EQUIPPED) STOP LAMP FUSE VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR (TOP OF TRANSAXLE) YEL/ORG WIRE

A/C A/T A/V, LOW NAVIGATION DC-DC HEAD UNIT CONVERTER A/V, NAVIGATION HEAD UNIT ALT FUSE ALTERNATOR ALTERNATOR EPS CONTROL MODULE AMS FUSE AUDIO AUDIO FUSE AUTO A/C MANUAL A/C B+1 FUSE B+2 FUSE BATT- ERY BATTERY BATTERY BATTERY SENSOR BCM BLK WIRE BLOWER FUSE BLOWER RELAY BLU WIRE BODY GROUND MOTOR BRN WIRE BURGLAR ALARM HORN RELAY C/FAN FUSE CONTROL MODULE CONVERTER) COOLING BLOWER FAN (LO) RELAY RELAY COOLING FAN (LO) RELAY COOLING FAN HI RELAY DATA LINK CONNECTOR DIGITAL CLOCK DOOR TIRE PRESSURE WARNING MONITORING SWITCH MODULE DOOR WARNING SWITCH E/R JUNCTION BOX E/R JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPT) E/R-EGGGA E/R-EGGGA PNK WIRE E/R-EGGGB ECU VM FUSE EGGG-AK EGGG-MK ENGINE CONTROL RELAY EPS CONTROL MODULE ESC MODULE FOG LP FRT FUSE FOG LP STOP LP FUSE FRT FUSE FRONT FOG LAMP RELAY FUEL PUMP 1 RELAY FUSE FUSE BOX FUSE FUSE FUSE HORN RELAY GRN WIRE H/LP FUSE H/LP HI FUSE HAC RELAY HEAD LAMP (LO) RELAY HEAD- LAMP HI RELAY HORN FUSE HORN RELAY I/P BOX JUNCTION I/P BOX JUNCTION (BEHIND LEFT SIDE OF DASH) I/P-A I/P-A W/ ISG I/P-B I/P-C I/P-D I/P-E I/P-E W/O ISG I/P-F INSTRU- DIGITAL A/C MENT CONTROL CLOCK CLUSTER MODULE INSTRU- MENT CLUSTER INVERTER INVERTER (W/ ISG, A/T) INVERTER FUSE LOW DC-DC LUGGAGE BCM LAMP LUGGAGE LAMP M/T MDPS FUSE MULTIFUSE MULTIPURPOSE CHECK CONNECTOR NCA WIRE PCB FUSE, RELAY BOX PCB FUSE, RELAY BOX BOX PCB FUSE, RELAY BOX BOX (INTEGRAL TO ENGINE ROOM JUNCTION BOX) PCM PNK PNK WIRE PNK WIRE POWER CONNECTOR POWER CONNECTOR ROOM LP FUSE PRESSURE MONITORING MODULE RED WIRE RELAY ROOM LP FUSE RR B+2 FUSE HTD FUSE RR HTD FUSE SMART KEY CONTROL MODULE START MOTOR START RELAY STOP LAMP RELAY STOP LAMP SWITCH STOP LP FUSE TIRE) TO I/P JUNCTION BOX (DIAGRAM 3 OF 5) TO I/P TO I/P JUNCTION JUNCTION BOX BOX (DIAGRAM (DIAGRAM 3 OF 5) 3 OF 5) TO IGNITION SWITCH (DIAGRAM 4 OF 5) TO IGNITION TO PDM SWITCH RELAY BOX (DIAGRAM (DIAGRAM 4 OF 5) 5 OF 5) TO MODULE 1 FUSE (DIAGRAM 2 OF 5) TO PDM RELAY BOX (DIAGRAM 5 OF 5) W/ ISG W/ ISG, A/T W/ SMART KEY W/O ISG W/O SMART KEY W/O W/ PNK SMART SMART KEY KEY WIRE WHT WIRE YEL WIRE

A/C CONTROL MODULE A/T A/V, NAVIGATION HEAD UNIT ATM SHIFT LEVER ILL AUDIO AUDIO A/V, BCM NAVIGATION LEVER HEAD UNIT ILL AUTO A/C B/UP LP FUSE BCM BCM SMART KEY CONTROL (AUTO A/C) MODULE (W/ SMART KEY) BELOW RELAY BLK WIRE BLU WIRE BRN WIRE CLUSTER IONIZER DRIVER BELOW CCS SEAT RELAY WARMER MODULE DRIVER CCS SEAT WARMER MODULE E/R-EGGGA E/R-EGGGB EGGG-AA ESCL ESCL (ACC) RELAY FROM IGNITION SWITCH (DIAGRAM 4 OF 5) FROM PCB FUSE, RELAY BOX (DIAGRAM 1 OF 5) FROM WIPER FRT FUSE (DIAGRAM 5 OF 5) FROM WIPER FRT FUSE (DIAGRAM 5 OF 5) HTD STRG FUSE FRONT FOG LAMP RELAY FRONT WIPER MOTOR FRONT WIPER RELAY FUEL PUMP 1 RELAY FUSE FUSE PNK (DIAGRAM 1 OF 5) WIRE GRN WIRE HEAD- LAMP HI RELAY HTD STRG FUSE I/P-A I/P-B I/P-C I/P-E I/P-F I/P-F PNK WIRE JUMPER WIRE 1 LEFT ATM REAR SHIFT COMBI- NATION LAMP (IN) LEFT REAR COMBI- NATION LAMP (IN) MANUAL A/C AUTO A/C MULTIFUNCTION SWITCH NAVI NAVI UVO AUDIO NCA WIRE ORG/ WIRE PCB FUSE, RELAY BOX PCM PDM RELAY BOX PDM RELAY BOX (UNDER LEFT SIDE OF DASH) ESCL PNK WIRE RAIN FRONT WIPER SENSOR RELAY RELAY RAIN SENSOR RAIN SENSOR RELAY REAR WIPER MOTOR REAR WIPER RELAY RED WIRE RELAY RIGHT REAR COMBI- NATION LAMP (IN) SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (UNDER LEFT SIDE OF DASH) STEERING WHEEL HEATER SUNROOF MOTOR TO HID STRG FUSE (DIAGRAM 5 OF 5) TRANSAXLE PCM REAR RANGE WIPER SWITCH RELAY TRANSAXLE RANGE SWITCH UVO AUDIO W/ SMART KEY WHT WIRE WIPER FRT FUSE WIPER RR FUSE YEL WIRE

22 44 VFS OD 99 95 INPUT SPEED SIG OUTPUT SPEED PWR ATM SHIFT LEVER SWITCH ATM SHIFT LEVER SWITCH DOWN SHIFT ATM SOLENOID VALVE ATM SOLENOID VALVE (TOP OF TRANSAXLE) BLK WIRE BLU WIRE BRN WIRE CCP CAN HI CCP-CAN HI COMPUTER DATA LINES SYSTEM CCP-CAN LO EGGG-AK COMPUTER DATA LINES SYSTEM DOWN SHIFT DOWN SHIFT EGGG-AA E/R JUNCTION BOX E/R-EGGGB ECU VM FUSE EGGG-AA EGGG-AA 68 5 3 PNK ON/START INPUT MEMORY POWER MEMORY POWER WIRE EGGG-AK PNK (+) OIL TEMP SENSOR (-) WIRE FUSE GND EGGG-AK GRN WIRE GRN/BLK WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-E I/P-E PNK WIRE INPUT SPEED INPUT SPEED PWR INPUT SPEED SIG MEMORY POWER MEMORY POWER EGGG-AK OIL TEMP SENSOR ON/START INPUT OUTPUT SPEED (+) OUTPUT SPEED PWR OUTPUT SPEED SIG PCB FUSE, RELAY BOX PCB FUSE, RELAY BOX (INTEGRAL TO ENGINE ROOM JUNCTION BOX) PCM PCM (LEFT REAR OF ENGINE COMPT) PNK (+) OIL TEMP SENSOR (-) WIRE PNK 75 74 94 WIRE PNK ON/START INPUT WIRE PNK SIGNAL 4 WIRE PNK WIRE RED WIRE SELECT SW SELECT SWITCH SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SOLENOID PWR 1 SOLENOID PWR 2 SS A SS B SS B EGGG-AA STARTING/ CHARGING SYSTEM TCU FUSE TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UP SHIFT VFS LINE VFS OD VFS T/CON VFS UD WHT WIRE YEL WIRE

47 48 49 50 51 CMPS (EXHAUST) SIG AMS FUSE BATTERY BATTERY GROUND BATTERY SENSOR BATTERY SNSR + SENSOR (LEFT REAR OF ENGINE COMPT) LIN LINE BATTERY, BATTERY FUSE BOX BLK WIRE BLK/ORG WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BRN (OR GRN) WIRE BRN WIRE C-CAN HI C-CAN HI IMMO DATA LINK LIN COMMUNICATION ENGINE RPM OUT VEHICLE SPEED IN C-CAN LO C-CAN LO CKPS GND CKPS SIG CMPS (INTAKE) GND CCV CTRL CKPS GND CKPS SIG CMPS (EXHAUST) SIG CMPS (INTAKE) GND CMPS (INTAKE) SIG START SIG IN CMPS (INTAKE) SIG START SIG IN ON/START IN COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR CRANKSHAFT POSITION SENSOR (LEFT REAR OF ENGINE) CRANKSHAFT POSITION SENSOR (W/ ISG) (LEFT REAR OF ENGINE) CVVT INTAKE E/R-EGGGA E/R-EGGGB ENGINE CHECK IND ENGINE CONTROL RELAY ENGINE CTRL RLY ON IN ENGINE RPM OUT FUEL PUMP 1 RELAY FUSE FUSE FUSE FUSE GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES IGNITION COIL CTRL CYL 1 IGNITION COIL CTRL CYL 3 EGGG-AK IGNITION COIL CTRL CYL 4 IGNITION COIL CTRL CYL 4 ENGINE CTRL RLY ON IN IMMO DATA LINK INJECTOR FUSE JUMPER WIRE 1 LIN COMMUNICATION LIN LINE ON/START IN ORG/ WIRE PCB FUSE, RELAY BOX PCB FUSE, RELAY BOX (INTEGRAL TO ENGINE ROOM JUNCTION BOX) PCM PCM (LEFT REAR OF ENGINE COMPT) PNK 16 17 WIRE PNK CVVT INTAKE IGNITION COIL CTRL CYL 1 WIRE PNK WIRE RED WIRE SNSR START RLY LO CTRL STARTING/ CHARGING SYSTEM VEHICLE SPEED IN VIS CTRL W/ ISG W/ SMART KEY/IMMO W/O SMART KEY/IMMO W/O ISG WHT (OR BRN) WIRE WHT WIRE WIPER SW IN (ACTIVE HI) ENGINE CTRL RLY CTRL FUEL PUMPER 1 RLY CTRL WIPER/ WASHER SYSTEM YEL WIRE

19 20 PNK WIRE APS 1 GND APS 2 GND BLK WIRE BLU WIRE BLU/BLK WIRE BRN WIRE BRN/BLK WIRE CONDENSER ECT SIG EGGG-AA EGGGINJ ENGINE COOLANT TEMPERATURE SENSOR FPCV (-) FTPS SIG FUEL LEVEL IN GRN WIRE GRN/ORG WIRE GRY WIRE IGNITION COIL 1 IGNITION COIL 2 IGNITION COIL 3 IGNITION COIL 4 IN SPEED PWR IN SPEED SIG INJECTOR 1 INJECTOR 1 CTRL INJECTOR 2 INJECTOR 2 CTRL INJECTOR 3 INJECTOR 3 CTRL INJECTOR 4 INJECTOR 4 CTRL INJECTOR 4 INJECTOR 3 KNOCK SENSOR KNOCK SENSOR (LEFT SIDE OF ENGINE) KNOCK SENSOR GND KNOCK SENSOR SIG NERNST VOLTAGE ORG/ WIRE OUT SPEED PWR OUT SPEED SIG PCM PCM (LEFT REAR OF ENGINE COMPT) PNK WIRE PUMPING CURRENT RED WIRE SENSOR SIG SOLENOID POWER 1 SOLENOID POWER 2 SS A TOP OF ENGINE) TRIM RESISTOR VERTUAL GND WHT WIRE YEL WIRE

10 11 12 13 14 15 PNK WIRE 33 34 PNK WIRE ACCEL PEDAL POSITION SENSOR ACCEL PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL ASSEMBLY) ALTERNATOR PWM APS 1 SIG APS 1 SUPPLY APS 2 SIG APS 2 SUPPLY BLK WIRE BLU WIRE BLU/BLK WIRE BRAKE TEST SW BRN WIRE BRN/BLK WIRE CHARGING DOWN SHIFT ECT GND EGGG-AA GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE INJECTOR 1 CTRL INJECTOR 2 CTRL INJECTOR 3 CTRL INJECTOR 4 CTRL MAP/FTPS SUPPLY NCA WIRE OIL CONTROL VALVE 1 OIL CONTROL VALVE 1 (FRONT LEFT OF ENGINE) OIL CONTROL VALVE 2 OIL CONTROL VALVE 2 (TOP FRONT OF ENGINE) OIL TEMP SENSOR ORG/ WIRE OXYGEN SENSOR (DOWN) OXYGEN SENSOR (DOWN) (IN EXHAUST, AFTER CATALYTIC CONVERTER) OXYGEN SENSOR (UP) OXYGEN SENSOR (UP) (IN EXHAUST MANIFOLD) PCM PCM (LEFT PCSV CTRL PNK WIRE REAR OF ENGINE COMPT) RED WIRE SELECT SW SENSOR GND SENSOR HEATER SS B START RLY (HI) OUT STARTING/ SYSTEM TPS 1 SIG TPS 2 SIG TPS GND TPS SUPPLY UP SHIFT VFS LINE VFS OD VFS T/CON VFS UD WHT WIRE YEL WIRE

38 39 40 41 42 43 44 45 46 EGGG-AK A/C PRESSURE TRANSDUCER ALTERNATOR COM APT GND PNK SENSOR SIG WIRE APT SIG APT/RPS SUPPLY BLK WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BPS SIG BPS/CKPS SUPPLY BRAKE BOOSTER VACUUM PRESSURE SENSOR BRAKE BOOSTER VACUUM PRESSURE SENSOR (W/ ISG) (BRAKE MASTER CYLINDER) BRAKE LIGHT SW BRAKE LIGHT SW EGGG-AK BRN WIRE BRN/ORG WIRE C-CAN TRANSCEIVER C/FAN RLY CTRL HI FUEL PUMPER 1 RLY CTRL CCV CTRL C/FAN RLY CTRL LO CLUSTER FUSE CMPS (EXHAUST) GND SENSOR GND CMPS SUPPLY CMPS SUPPLY BPS/CKPS SUPPLY APT/RPS SUPPLY ALTERNATOR COM COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM CVVT EXHAUST CVVT EXHAUST IGN COIL CTRL CYL 2 DEFOGGER SYSTEM EGGINJ ELEC LOAD DEFROSTER EMS COM ENG CTRL RLY ON IN ENGINE CHECK ENGINE CHECK IND ENGINE COMPT) ENGINE EMS OF DASH) RPM COM ENGINE RPM ETC OUT (+) BPS GND ETC OUT (-) FTPS GND FTPS GND BPS SIG APT SIG GND MEMORY POWER GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P-B IAT SIG IGN COIL CTRL CYL 2 IMMO IND IMMOBILIZER MODULE IND INSTRUMENT CLUSTER ISG SW MAP SENSOR (ON THROTTLE BODY) MEMORY POWER MICOM ORG/ WIRE PCM PCM (LEFT REAR OF PNK ISG SW IND C/FAN RLY CTRL HI FUEL PUMPER 1 RLY CTRL CCV CTRL WIRE PNK ISG SW IND WIRE PNK WIRE POWER CONNECTER POWER CONNECTOR RAIL PRESSURE SENSOR RAIL PRESSURE SENSOR (UNDER INTAKE MANIFOLD) RED WIRE REGULATOR ROOM LP FUSE RPS GND RPS SIG SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (UNDER LEFT SIDE SMART KEY) W/ SMART KEY W/ SMART KEY/IMMO W/ SMART KEY/IMMO W/O SMART KEY/IMMO W/O SMART KEY W/O SMART KEY/IMMO WHT WIRE YEL (OR YEL/ORG) WIRE YEL WIRE YEL/ORG WIRE