Kia Rio III (2011-2015) on/start in Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 ON/START IN 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 K-LINE ATM SOLENOID AUTO LIGHT SENSOR GND AUTO LIGHT SENSOR PWR AUTO LIGHT SENSOR SIG AUTO LIGHT SW B-CAN HI B-CAN LO B/ALARM HORN RLY CTRL B/ALARM RLY CTRL BCM BCM (UNDER LEFT SIDE OF DASH) BLK WIRE BLU WIRE BLU/BLK WIRE BRAKE SWITCH BRN WIRE BRN/ORG WIRE COMPUTER DATA LINES SYSTEM DEDICATED DRL LAMP DEDICATED DRL LAMP ON/START INPUT DEFOGGER SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS DOOR LOCKS, ANTI-THEFT SYSTEMS STARTING/CHARGING SYSTEM FRT WASHER SW ON GRN WIRE GRN/ORG WIRE GROUND (DRL ENABLE) CRASH INPUT GROUND (SIDE A/BAG) GRY WIRE GRY/BLK WIRE HAZARD FUSE HAZARD SWITCH HAZARD SWITCH PWR WDW DR SW UNLK PWR WDW DR SW LK INT (VOLUME) HEAD LAMP LOW SIG HEAD LAMP LOW SWITCH HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM SHIFT INTERLOCK SYSTEM HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-A I/P-B INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM HEADLIGHTS SYSTEM INT (VOLUME) INTERIOR LAMP INTERIOR LP PWR K LINE LH FRT TURN SIG LP LH REAR TURN SIG LP LH TURN SIG LP SW MODULE 2 FUSE ON/START IN ON/START INPUT ORG/ WIRE PARKING BRAKE PASS DR KEY UNLK SIG PASS DR KEY UNLK SIG INTERIOR LP PWR INTERIOR LAMP PNK WIRE POWER CONNECTOR POWER WINDOWS SYSTEM PWR WDW DR SW LK PWR WDW DR SW UNLK REAR DEF SW SIG REAR INT WIPER SW REAR WASHER SW ON REAR WIPER SW ON RED WIRE RED/BLK WIRE RH FRT TURN SIG LP RH REAR TURN SIG LP RH TURN SIG LP SW ROOM LP FUSE SHIFT INTERLOCK SYSTEM STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM DEFOGGER SYSTEM TURN POWER WHT WIRE WIPER INT SW WIPER, MIST SWITCH WIPER/WASHER SYSTEM YEL WIRE YEL/ORG WIRE

1 2 5 6 7 8 1 2 3 4 MOTOR + MOTOR - 1 2 MEMORY PWR GND 1 7 8 ON/START IN C-CAN HIGH C-CAN LOW 14 PNK I/P-B WIRE B-CAN TRANS CEIVER BLK WIRE BLU WIRE BRN WIRE C-CAN HIGH C-CAN LOW C-CAN TRANSCEIVER CLUSTER FUSE COMPUTER DATA LINES SYSTEM E/R JUNCTION BOX EPS CONTROL MODULE EPS CONTROL MODULE (UNDER LEFT SIDE OF DASH) EPS IND EPS MOTOR GRN WIRE HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-A I/P-B INSTRUMENT CLUSTER MDPS 2 FUSE MDPS FUSE MEMORY PWR MICOM MOTOR MULTI FUSE NCA WIRE ON/START IN PNK PNK WIRE PNK WIRE PWM PWM GND RED WIRE TORQUE SENSOR WHT WIRE

AUTO AUTO LIGHT SENSOR AUTO LIGHT SW B-CAN HI B-CAN LO PNK POWER WIRE BCM BLK WIRE BLU WIRE BLU/BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DASH PANEL) DEDICATED DRL LP DIMMER, PASSING SWITCH DRL ENABLE DRL LAMP HI E/R-EGGGA E/R-EGGGB FRONT FOG LAMP SWITCH GRY WIRE GRY/BLK WIRE H/LP FUSE H/LP HI FUSE H/LP HI SW FRONT FOG LP SW ON H/LP LO SIG H/LP LO SW H/LP RLY CTRL HI FRONT FOG LP RLY CTRL H/LP RLY CTRL LO HEAD HEAD LAMP (LO) RELAY HEAD TAIL AUTO OFF HEAD- LAMP HI RELAY HIGH PASS HIGH HOT AT ALL TIMES LEFT H/LP FUSE LEFT HEAD- LAMP LIGHT SWITCH MULTIFUNCTION SWITCH NCA WIRE OFF ON/START IN ORG/ WIRE PASS PCB FUSE, RELAY BOX PNK WIRE RED WIRE RED/BLK WIRE RIGHT H/LP FUSE RIGHT HEAD- LAMP SIG TAIL OFF WHT WIRE YEL WIRE

B-CAN BATTERY PWR BLK WIRE BLU WIRE BRN WIRE C-CAN C-CAN HI C-CAN LO CLUSTER FUSE COMPUTER DATA LINES SYSTEM EPS CONTROL MODULE GRN WIRE HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P JUNCTION BOX (BEHIND LEFT SIDE OF DASH) I/P-B I/P-C INSTRUMENT CLUSTER LEFT/RIGHT FRONT TIRE PRESSURE SENSOR LEFT/RIGHT REAR TIRE PRESSURE SENSOR MICOM ON/START IN PNK ON/START IN WIRE PNK WIRE POWER CONNECTOR RED WIRE RESISTOR ROOM LP FUSE TIRE PRESSURE MONITORING MODULE TIRE PRESSURE MONITORING MODULE (BEHIND RIGHT SIDE OF DASH) TPMS TREAD IND TRANSCEIVER/ WHT WIRE

47 48 49 50 51 CMPS (EXHAUST) SIG AMS FUSE BATTERY BATTERY GROUND BATTERY SENSOR BATTERY SNSR + SENSOR (LEFT REAR OF ENGINE COMPT) LIN LINE BATTERY, BATTERY FUSE BOX BLK WIRE BLK/ORG WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BRN (OR GRN) WIRE BRN WIRE C-CAN HI C-CAN HI IMMO DATA LINK LIN COMMUNICATION ENGINE RPM OUT VEHICLE SPEED IN C-CAN LO C-CAN LO CKPS GND CKPS SIG CMPS (INTAKE) GND CCV CTRL CKPS GND CKPS SIG CMPS (EXHAUST) SIG CMPS (INTAKE) GND CMPS (INTAKE) SIG START SIG IN CMPS (INTAKE) SIG START SIG IN ON/START IN COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR CRANKSHAFT POSITION SENSOR (LEFT REAR OF ENGINE) CRANKSHAFT POSITION SENSOR (W/ ISG) (LEFT REAR OF ENGINE) CVVT INTAKE E/R-EGGGA E/R-EGGGB ENGINE CHECK IND ENGINE CONTROL RELAY ENGINE CTRL RLY ON IN ENGINE RPM OUT FUEL PUMP 1 RELAY FUSE FUSE FUSE FUSE GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES IGNITION COIL CTRL CYL 1 IGNITION COIL CTRL CYL 3 EGGG-AK IGNITION COIL CTRL CYL 4 IGNITION COIL CTRL CYL 4 ENGINE CTRL RLY ON IN IMMO DATA LINK INJECTOR FUSE JUMPER WIRE 1 LIN COMMUNICATION LIN LINE ON/START IN ORG/ WIRE PCB FUSE, RELAY BOX PCB FUSE, RELAY BOX (INTEGRAL TO ENGINE ROOM JUNCTION BOX) PCM PCM (LEFT REAR OF ENGINE COMPT) PNK 16 17 WIRE PNK CVVT INTAKE IGNITION COIL CTRL CYL 1 WIRE PNK WIRE RED WIRE SNSR START RLY LO CTRL STARTING/ CHARGING SYSTEM VEHICLE SPEED IN VIS CTRL W/ ISG W/ SMART KEY/IMMO W/O SMART KEY/IMMO W/O ISG WHT (OR BRN) WIRE WHT WIRE WIPER SW IN (ACTIVE HI) ENGINE CTRL RLY CTRL FUEL PUMPER 1 RLY CTRL WIPER/ WASHER SYSTEM YEL WIRE

33 34 PNK WIRE ATM SHIFT LEVER SWITCH BLK WIRE BLU WIRE BLU/BLK WIRE BRN WIRE BRN/BLK WIRE DOWN SHIFT GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE INPUT SPEED OIL TEMPERATURE ON/START IN ORG/ WIRE OUTPUT SPEED (+) P/N SW PNK WIRE RED WIRE SELECT SWITCH SENSOR SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SS A SS B STARTING/ CHARGING SYSTEM TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UP SHIFT VFS OD VFS T/CON VIS LINE VIS UD WHT WIRE YEL WIRE

13 14 15 16 17 18 19 20 21 22 23 24 PNK WIRE 8 9 10 11 12 PNK WIRE ACCEL PEDAL POSITION SENSOR ACCEL PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL ASSEMBLY) ALTERNATOR PWM APS 1 GND APS 1 SIG APS 1 SUPPLY APS 2 GND APS 2 SIG APS 2 SUPPLY APT SIG EGGG-MK APT SIG W/ ISG APT/RPS SUPPLY BLK WIRE BLU WIRE BLU/BLK WIRE BPS GND BPS SIG BPS SIG TPS SUPPLY APS 1 SUPPLY MAP/FTPS SUPPLY CMPS SUPPLY BPS/CKPS SUPPLY BRN WIRE BRN/BLK WIRE C-CAN TRANSCEIVER CLUSTER FUSE CMPS SUPPLY COMPUTER DATA LINES SYSTEM ECM (LEFT REAR OF EMS COM ENG CTRL RLY ON ENG CTRL RLY ON MEMORY POWER ENGINE CHECK ENGINE CHECK IND ENGINE COMPT) ENGINE EMS OF DASH) RPM COM ENGINE RPM ETC MOTOR, THROTTLE POSITION SENSOR ETC MOTOR, THROTTLE POSITION SENSOR (THROTTLE BODY) FTPS GND FTPS GND BPS GND TPS.1 SIG FUEL LEVEL IN GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I/P JUNCTION BOX I/P-B IMMO IND IMMO MODULE IND INSTRUMENT CLUSTER ISG SW ISG SW IND MAP/FTPS SUPPLY MEMORY POWER MICOM MOTOR NEUTRAL SW NEUTRAL SWITCH NEUTRAL SWITCH INSTRUMENT CLUSTER ON/START IN ORG/ WIRE PNK ISG SW IND WIRE PNK ON/START IN SENSOR SIG APS 2 SIG APS 1 GND WIRE PNK WIRE POWER CONNECTOR RED WIRE REGULATOR ROOM LP FUSE SENSOR GND SENSOR SIG SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (UNDER LEFT SIDE SMART KEY) THROTTLE POSITION SENSOR TPS GND TPS GND TPS.2 SIG PNK WIRE TPS SUPPLY TPS.1 SIG TPS.2 SIG W/ ISG W/ SMART KEY W/O SMART KEY WHT WIRE WIPER SW IN WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM PNK WIRE YEL (OR YEL/ORG) WIRE YEL WIRE YEL/ORG WIRE