Kia Rio I facelift (2002-2005) Wiring diagram engine performance 1.6l

1 2 3 4 5 6 7 8 9 B-01 IGN 8 9 B-05 A/C ON RELAY B-09 B-10 BLK WIRE BLK/BLU WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BRN WIRE BRN/RED WIRE CONDENSER (LEFT REAR OF ENG, NEAR IGNITION COILS) COOLING FAN RELAY DIAG K-LINE GND GND GND BATT IGN IGN ECU FUSE EMS FUSE ENG RPM SIG ENGINE CONTROL MODULE (BELOW LEFT SIDE OF DASH) EVAP PURGE SOL ISC CTRL (OPEN) ISC CTRL (CLOSE) FUEL INJECTORS FUEL PUMP FUSE FUEL PUMP RELAY GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HOT AT ALL TIMES HOT IN ON OR START IG-COIL FUSE IGN COIL CTRL 1 IGN COIL CTRL 2 IGNITION COIL 1 IGNITION COIL 2 INJECT FUSE KNOCK SEN GND KNOCK SEN IN INJ 2 CTRL INJ 4 CTRL INJ 1 CTRL INJ 3 CTRL KNOCK SEN SHIELD MAF SEN GND MAF SEN IN MAIN RELAY NCA WIRE ORG/ WIRE PURGE SOLENOID (RIGHT FRONT OF ENG) RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHORT CONNECTOR SC-03 (BEHIND DASH, RIGHT OF STEERING COLUMN) SHORT CONNECTOR SC-05 (BELOW LEFT SIDE OF DASH) SPARK PLUGS TORQUE SIG TPS SIG TPS VOLTAGE WHT WIRE X-03 YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

BLK WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/YEL WIRE BRN WIRE BRN/RED WIRE DOWN GRN WIRE GRN/WHT WIRE GRN/YEL WIRE HEATED OXYGEN SENSOR HOT IN ON OR START HOT IN START INSTRUMENT CLUSTER SYSTEM ISC SOLENOID VALVE (RIGHT REAR OF ENG) KNOCK SENSOR (RIGHT SIDE OF ENG) MASS AIR FLOW SENSOR (TOP RIGHT REAR OF ENG) METER FUSE FUSE NCA WIRE PASSENGER COMPARTMENT FUSE BOX (BELOW LEFT SIDE OF DASH) RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHORT CONNECTOR SC-02 (BEHIND TOP LEFT OF DASH) SHORT CONNECTOR SC-05 (BELOW LEFT SIDE OF DASH) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION CONTROL MODULE (BELOW LEFT SIDE OF DASH) UP (+) WHT WIRE WHT/GRN WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

12 13 14 15 16 17 18 19 20 (PIN 21-24 NOT USED) WHEEL SPD SEN GND 9 10 FUEL TANK PRESS GND AIR CONDITIONING SYSTEM AIR TEMPERATURE SENSOR (RIGHT REAR OF ENG) B-02 B-04 BLK WIRE BLK/RED WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BLU/YEL WIRE BRN WIRE BRN/RED WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON REAR OF ENG) CANISTER CLOSE VALVE CANISTER CLOSE VALVE (BOTTOM REAR OF VEHICLE, NEAR CANISTER) CKP SEN GND IAT SEN SIG IN CKP SEN SIG IN COOLING FAN RLY CTRL MAIN RLY CTRL FUEL PMP RLY CTRL A/C RLY CTRL MIL CTRL COOLING FANS SYSTEM CRANKSHAFT POSITION SENSOR (ON REAR OF ENG) DPS SIG IN A/C SW SIG IN PWR STEERING SW IN HEADLIGHT SW SIG TCU MIL SIG IN ECT SEN GND ECT SEN SIG IN ENGINE CONTROL MODULE (BELOW LEFT SIDE OF DASH) ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENG) FUEL TANK PRESS IN GRN WIRE GRN/BLK WIRE INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LT GRN/RED WIRE LT GRN/YEL WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE POWER STEERING PRESSURE SWITCH (LEFT FRONT OF ENG) RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE TACHO- METER TANK PRESSURE SENSOR (BOTTOM REAR OF VEHICLE) TORQUE REDUCT CTRL P/N SIG IN TPS GND CMP GND TPS SIG IN CMP SIG IN WHEEL SPD SEN IN WHEEL- SPEED SENSOR (ON RIGHT FRONT WHEEL HOUSING) WHT WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE