Kia Optima III facelift (2013-2015) e/r fuse, relay box Wiring diagrams

26 VFS ATM SOLENOID ATM SOLENOID (TOP OF TRANSAXLE) BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM DOWN SHIFT E/R FUSE, RELAY BOX GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) HOT IN ON OR START I/P-F INPUT SPEED INPUT SPEED SENSOR LINE VFS MEMORY POWER MODULE 4 FUSE OD VFS OIL TEMP SENSOR OIL TEMPERATURE SENSOR ON/START INPUT ORG/ WIRE OUTPUT SPEED (+) OUTPUT SPEED SENSOR OUTPUT SPEED SIGNAL OUTPUT SPEED SUPPLY INPUT SPEED SIGNAL INPUT SPEED SUPPLY P/N SWITCH (P N POSITION SWITCH CLOSE) PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK MEMORY POWER WIRE PNK WIRE POSITION SWITCH) RED WIRE RED/BLK WIRE SELECT SWITCH SIGNAL SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SMART JUNCTION BOX (ABOVE LEFT KICK PANEL) SS A SS B STARTING/ CHARGING SYSTEM SUPPLY T/CON VFS TCU 1 FUSE TCU 2 FUSE TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UD VFS UP SHIFT V SOL 1 V SOL 2 WHT WIRE WHT/BLK WIRE YEL WIRE

26 VFS ATM SOLENOID ATM SOLENOID (TOP OF TRANSAXLE) BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BOX (ABOVE LEFT KICK PANEL) BRN WIRE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM DOWN SHIFT E/R FUSE, RELAY BOX E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) FEEDBACK FEEDBACK START FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GROUND GRY WIRE H-CAN HIGH H-CAN LOW HOT AT ALL TIMES HOT IN ON OR START I/P-E I/P-F INPUT SPD SIG INPUT SPD SPLY INPUT SPEED SENSOR LINE VFS MEMORY POWER MODULE 4 FUSE OD VFS OIL TEMP SNSR (-) OIL TEMPERATURE SENSOR ON/START INPUT ORG/ WIRE OUTPUT SPD SIG OUTPUT SPD SPLY OUTPUT SPEED SENSOR P/N SWITCH PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK SOL PWR 2 WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RED/BLK WIRE RIGHT END OF DASH) SELECT SWITCH SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION SMART JUNCTION BOX SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (RIGHT END OF DASH) SOL PWR 1 SS A SS B START FUSE START SIGNAL T/CON VFS TCU 1 FUSE TCU 2 FUSE TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UD VFS UP SHIFT WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLU WIRE

26 VFS ATM SOLENOID ATM SOLENOID (TOP OF TRANSAXLE) BLK WIRE BLU WIRE BLU/ORG WIRE BRN WIRE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM DOWN SHIFT E/R FUSE, RELAY BOX E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-F INPUT SPD SIG INPUT SPD SPLY INPUT SPEED SENSOR LINE VFS MEMORY POWER MODULE 4 FUSE OD VFS OIL TEMP SNSR (-) OIL TEMPERATURE SENSOR ON/START INPUT ORG/ WIRE OUTPUT SPD SIG OUTPUT SPD SPLY OUTPUT SPEED SENSOR P/N SWITCH (P N POSITION SWITCH CLOSE) PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK MEMORY POWER WIRE PNK WIRE RED WIRE RED/BLK WIRE SELECT SWITCH SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SS A SS B STARTING/ CHARGING SYSTEM T/CON VFS TCU 1 FUSE TCU 2 FUSE TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) UD VFS UP SHIFT V SOL 1 V SOL 2 WHT WIRE WHT/BLK WIRE YEL WIRE

ALT (FR) ALT COM AMS FUSE ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLU WIRE BLU/ORG WIRE BRK LT SW BRK TEST SW BRN WIRE C/FAN RLY CTRL HI C/FAN RLY CTRL HI IMMO IND C/FAN RLY CTRL LO CKP GND CKP SIG CMP 1 GND CMP 1 SIG CMP 1 SIG CMP 2 SIG CMP 2 GND CMP 2 SIG COMPT) COOLING FANS SYSTEM COOLING FANS SYSTEM ANTI-THEFT SYSTEM E/R FUSE, RELAY BOX E/R-A E/R-B ECU 1 FUSE ECU 4 FUSE EMS BOX ENG CTRL RLY ON ENG RLY CTRL ENGINE CONTROL RELAY EXHAUST MANIFOLD) F/PUMP FUSE FUEL PUMP RELAY FUSE (DIAGRAM 3 OF 6) GRN BLK/ WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES E/R FUSE, HOT IN ON OR START IMMO IND INJ CTRL 2 HI INJ CTRL 2 HI INJ CTRL 2 LO INJ CTRL 2 LO INJ CTRL 3 HI INJ CTRL 3 HI INJ CTRL 3 LO ON/START IN INJ CTRL 3 LO PNK ON/START IN WIRE INJECTOR FUSE INJECTORS (LEFT SIDE OF ENGINE) KNOCK SENSOR KNOCK SENSOR (LEFT SIDE OF ENGINE) LIN DIAG DATA LINE LIN DIAG DATA LINE C/FAN RLY CTRL LO NCA WIRE ORG/ WIRE OXYGEN SENSOR (DOWN) OXYGEN SENSOR (DOWN) (IN EXHAUST, DOWNSTREAM OF CATALYTIC CONVERTER) OXYGEN SENSOR (UP) OXYGEN SENSOR (UP) (EXHAUST MANIFOLD) PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK PNK 23 24 25 26 27 28 29 WIRE PNK WIRE PNK/BLK WIRE RED WIRE RELAY BOX AMS FUSE (LEFT SIDE OF ENGINE SHIELD SHIELD SNSR GND CMP 1 GND CMP 2 GND SNSR 1 FUSE SNSR 3 FUSE SNSR GND STARTING/CHARGING SYSTEM TO IGN COIL FUSE (DIAGRAM 3 OF 6) TO IGN COIL FUSE (DIAGRAM 3 OF 6) TO SNSR 2 FUSE (DIAGRAM 3 OF 6) TO SNSR 2 VACUUM PUMP FUSE WHT WIRE WIPER "P" IN WIPER "P" IN ALT (FR) ALT (COM) WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM STARTING/CHARGING SYSTEM YEL WIRE YEL/ORG WIRE

16 17 18 19 20 21 22 23 24 25 26 27 28 29 PNK WIRE 26 VFS APT SNSR SUPPLY BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE SW FUSE BRN WIRE COMPT) E/R FUSE, E/R FUSE, RELAY BOX ETC MOTOR, THROTTLE POSITION SENSOR ETC OUT (-) ETC OUTPUT (+) EWGA DC MTR OUT (+) EWGA FDBK SNSR SIG EWGA FEEDBACK GND FTPS GND FTPS SIG GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-D IGN COIL CTRL CYL 2 IGN COIL CTRL CYL 4 INPUT CIRCUIT LINE VFS MAP SNSR 2 SIG MODULE 3 FUSE MOTOR OD VFS ON/START IN ORG/ WIRE OTS SIG P/N SW PCM (LEFT SIDE OF ENGINE COMP) PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE RELAY BOX RIGHT END OF DASH) SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SMART JUNCTION BOX (ABOVE LEFT KICK PANEL) SNSR SIG STARTING/ CHARGING SYSTEM STOP LAMP SWITCH STOP LAMP SWITCH (BASE OF BRAKE PEDAL ASSEMBLY) STOP LMP SW STOP LP SIG STOP SIGNAL ELECTRONIC MODULE STOP SIGNAL ELECTRONIC MODULE (RIGHT END OF DASH) T/CON VFS TCU 1 FUSE TCU 2 FUSE TPS SUPPLY TRANSAXLE RANGE SWITCH UD VFS WHT WIRE YEL WIRE

ALT (FR) ALT COM AMS FUSE AMS FUSE (LEFT SIDE OF ENGINE ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLU WIRE BLU/ORG WIRE BRK LT SW BRK TEST SW BRN WIRE C/FAN RLY CTRL HI C/FAN RLY CTRL HI IMMO IND C/FAN RLY CTRL LO CHGINJ CKP GND CKP SIG CMP 1 GND CMP 1 SIG CMP 1 SIG CMP 2 SIG CMP 2 GND CMP 2 SIG COMPT) COOLING FANS SYSTEM COOLING FANS SYSTEM ANTI-THEFT SYSTEM E/R FUSE, E/R FUSE, RELAY BOX E/R-A E/R-B ECU 1 FUSE ECU 4 FUSE EMS BOX ENG CTRL RLY CTRL ENG CTRL RLY ON IN ENGINE CONTROL RELAY EXHAUST MANIFOLD) F/PUMP FUSE FUEL PUMP MOTOR FUEL PUMP RELAY FUEL SENDER FUEL SENDER, FUEL PUMP MOTOR FUSE (DIAGRAM 3 OF 6) GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START IMMO IND INJ CTRL 2 HI INJ CTRL 2 HI INJ CTRL 2 LO INJ CTRL 2 LO INJ CTRL 3 HI INJ CTRL 3 HI INJ CTRL 3 LO ON/START IN INJ CTRL 3 LO INJECTOR FUSE INJECTORS (LEFT SIDE OF ENGINE) INSTRUMENT CLUSTER SYSTEM KNOCK SENSOR KNOCK SENSOR (LEFT SIDE OF ENGINE) LEFT "C" PILLAR) LIN DIAG DATA LINE LIN DIAG DATA LINE C/FAN RLY CTRL LO NCA WIRE ON/START IN ORG/ GRN WIRE ORG/ WIRE OXYGEN SENSOR (DOWN) OXYGEN SENSOR (DOWN) (IN EXHAUST, DOWNSTREAM OF CATALYTIC CONVERTER) OXYGEN SENSOR (UP) OXYGEN SENSOR (UP) (EXHAUST MANIFOLD) PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK WIRE PNK/BLK WIRE RED WIRE RELAY BOX SHIELD SHIELD SNSR GND CMP 1 GND CMP 2 GND SNSR 1 FUSE SNSR 3 FUSE SNSR GND STARTING/CHARGING SYSTEM TO IGN COIL FUSE (DIAGRAM 3 OF 6) TO IGN COIL FUSE (DIAGRAM 3 OF 6) TO SNSR 2 FUSE (DIAGRAM 3 OF 6) TO SNSR 2 WHT WIRE WIPER "P" IN WIPER "P" IN ALT (FR) ALT (COM) WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM STARTING/CHARGING SYSTEM YEL WIRE YEL/ORG WIRE

10 11 12 PNK WIRE 13 14 15 16 17 18 PNK WIRE 26 VFS APT SNSR SUPPLY BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE SW FUSE BRN WIRE E/R FUSE, E/R FUSE, RELAY BOX ETC MOTOR, THROTTLE POSITION SENSOR ETC OUT (-) ETC OUTPUT (+) EXTERIOR LIGHTS FTPS GND FTPS SIG GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-D IGN COIL CTRL CYL 2 IGN COIL CTRL CYL 4 INPUT CIRCUIT LINE VFS MODULE 3 FUSE MOTOR OD VFS ON/START IN ORG/ WIRE P/N SW PCM (LEFT SIDE OF ENGINE COMP) PNK 7 8 9 WIRE PNK WIRE PNK/BLK WIRE RED WIRE RELAY BOX RIGHT END OF DASH) SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SMART JUNCTION BOX (ABOVE LEFT KICK PANEL) SNSR SIG STARTING/ CHARGING SYSTEM STOP LAMP SWITCH STOP LAMP SWITCH (BASE OF BRAKE PEDAL ASSEMBLY) STOP LMP SW STOP LP SIG STOP SIGNAL ELECTRONIC MODULE STOP SIGNAL ELECTRONIC MODULE (RIGHT END OF DASH) SYSTEM T/CON VFS TCU 1 FUSE TCU 2 FUSE THROTTLE POSITION SENSOR TPS SUPPLY TRANSAXLE RANGE SWITCH UD VFS WHT WIRE YEL WIRE

5 7 PPL B+ GND BATTERY AMBIENT TEMPERATURE SENSOR BATTERY C/FAN FUSE BATTERY PWR BATTERY PWR PNK ON/START INPUT WIRE BLK WIRE BLK/ORG WIRE BLOWER F/B BLU WIRE BLU/WHT WIRE BLWR F/B BMS ASSEMBLY BMS BLOWER MOTOR BMS BLOWER MOTOR RELAY BMS CONTROL MODULE BMS FUSE BRN WIRE C-CAN (H) C-CAN (H) C-CAN (L) RLY GND MAIN RLY GND FAN SPED C-CAN (L) COMPUTER DATA LINES SYSTEM CONTROL E/R FUSE, RELAY BOX E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) FAN SPD FAN SPED GND GND 15 16 17 18 19 20 21 22 23 24 25 26 GRY WIRE H-CAN (H) H-CAN (L) HOT AT ALL TIMES HOT AT ALL TIMES SMART JUNCTION BMS BOX FUSE (ABOVE LEFT KICK PANEL) I/P-A INVERTER LEFT "C" PILLAR) MAIN RELAY MAIN RLY ORG/ WIRE ORG/BLK WIRE PNK TO HYBRID BATTERY SAFETY PLUG (DIAGRAM 4 OF 6) WIRE PNK WIRE PNK/WHT WIRE POWER RELAY ASSEMBLY PPL PRCHRG RLY PRE RLY PWR IN RED WIRE RED/WHT WIRE RLY GND SIG SMART JUNCTION BOX TO HYBRID BATTERY MODULE 1 (DIAGRAM 3 OF 6) TO HYBRID BATTERY MODULE 9 (DIAGRAM 5 OF 6) TO HYBRID BATTERY SAFETY PLUG (DIAGRAM 4 OF 6) VIB GND VIB GND GND VOUT VOUT SIG WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/ORG WIRE

13 8 25 START FEEDBACK 3 2 1 PWM SIG GND 6 9 B+ FOB-IN BATTERY POWER BLK WIRE BLU WIRE BLU/ORG WIRE BRAKE LT SW BRAKE SW C-CAN (H) C-CAN (H) C-CAN (L) C-CAN (L) CLUTCH PRESS SNSR (GND) CLUTCH PRESS SNSR (PWR) CLUTCH PRESS SNSR (SIG) CLUTCH PRESSURE SENSOR COMPUTER DATA LINES SYSTEM E/R FUSE, RELAY BOX E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) FOB HOLDER FOB-IN GND GND GND GRN WIRE GRN/ORG WIRE GRY WIRE H-CAN (H) H-CAN (H) H-CAN (L) H-CAN (L) HEV ECU FUSE HEV ECU FUSE FUSE HOT AT ALL TIMES HOT IN ON OR START HYBRID CONTROL UNIT HYBRID POWER CONTROL UNIT I/P-D I/P-E I/P-F ON/START INPUT PDM 2 FUSE PNK ON/START INPUT BATTERY POWER BATTERY POWER WIRE PNK WIRE PWM RED WIRE RIGHT END OF DASH) SIG SMART JUNCTION BOX SMART JUNCTION BOX (ABOVE LEFT KICK PANEL) SMART KEY CONTROL MODULE SMART KEY CONTROL MODULE (RIGHT END OF DASH) START FEEDBACK START FUSE START SIG START STOP BUTTON SWITCH TRANSAXLE RANGE SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE) WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/ORG WIRE

A/C PRESSURE TRANSDUCER (RIGHT FRONT OF ENGINE COMPT) ACCELERATION POSITION SENSOR (BASE OF ACCELERATOR PEDAL ASSEMBLY) APS 1 GND APS 1 SPLY APS 2 GND APS 2 SIG APS 2 SPLY APT SENS GND APT SENS SIG BLK WIRE BLK/ORG WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BRN WIRE CKPS 2 SIG CKPS GND CKPS GND VEHICLE SPD INPUT CMPS 2 GND CMPS 2 SIG E/R FUSE, RELAY BOX E/R FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) E/R-B ECTS GND ECTS SIG ECU 3 FUSE ECU 4 FUSE EMS BOX EMS BOX (IN ENGINE ROOM RELAY BOX) ENG CTRL RLY "ON" IN FTPS SIG IAT SENS APT SENS SIG ENG CTRL RLY ON IN ESC MODULE ESC MODULE (LEFT REAR OF ENGINE COMPT) FTPS SIG FTPS/APT PWR FUEL SENDER FUEL TANK PRESSURE SENSOR FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START IAT SENS INJ CTRL 1 INJ CTRL 1 INJ CTRL 3 INJ CTRL 4 INJ CTRL 2 INJ CTRL 2 INJ CTRL 3 INJ CTRL 4 KNOCK SENS GND KNOCK SENS SIG KNOCK SENS SIG APS 2 GND ECTS GND CMPS 2 SIG MAP SENS SIG MAP SENS SPLY MEMORY PWR NCA WIRE NVLD DATA LINE ON/START IN ORG/ WIRE PCM PCM (LEFT SIDE OF ENGINE COMPT) PNK WIRE RED WIRE TPS 2 SIG TPS GND TPS GND APS 1 SPLY APS 1 GND VEHICLE SPD INPUT VIP VRC WHT WIRE YEL WIRE YEL/ORG WIRE