Kia Optima III (2010-2013) module 4 hev fuse Wiring diagrams

1 2 C-CAN LOW C-CAN HIGH GROUND ON/START INPUT 1 2 MEMORY POWER PNK ON INPUT C-CAN HIGH C-CAN LOW WIRE 1 2 POWER POWER 1 2 PWR RELAY (-) PWR RELAY (+) 10 4 PNK WIRE 19 20 11 12 H-CAN HIGH H-CAN LOW C-CAN HIGH C-CAN LOW ACTIVE AIR FLAP ALT FUSE B+ GND BATTERY BATTERY, BATTERY FUSE BOX BLK WIRE BMS ASSEMBLY BMS CONTROL MODULE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM E WATER PUMP FUSE E/R FUSE, RELAY BOX GROUND GRY WIRE H-CAN HIGH H-CAN LOW HOT AT ALL TIMES HOT IN ON OR START HYBRID BATTERY (+) HYBRID CONTROL UNIT HYBRID INVERTER HYBRID POWER CONTROL UNIT HYBRID WATER PUMP I/P JUNCTION BOX I/P-A I/P-D I/P-G INVERTER FUSE LOW VOLTAGE DC-DC CONVERTER MAIN RELAY MAIN RLY MCU MODULE 4 HEV FUSE ON/START INPUT ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWER RELAY ASSEMBLY PRA PRE RLY PRECHARGE RELAY RED WIRE RED/WHT WIRE RLY GND VIB GND VOUT WHT WIRE WHT/BLK WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/ORG WIRE

B-CAN BATTERY POWER BLK WIRE BLU WIRE BLU/WHT WIRE BPM GND BPM PWR BPM SIG BRAKE FLUID LEVEL BRAKE FLUID LEVEL SENSOR (ON BRAKE MASTER CYLINDER RESERVOIR ASSEMBLY) BRAKE LIGHT SWITCH CAN LOW BATTERY POWER C-CAN HIGH BRAKE PEDAL MODULE BRN WIRE C-CAN HI C-CAN LOW CAN HI CAN LO CAN LOW CHG-K COMPUTER DATA LINES SYSTEM DRIVER DOOR SW ESC MODULE (BELOW BRAKE MASTER CYLINDER) FL SIGNAL RL SIGNAL RR VCC FR VCC FL VCC RL VCC RR SIGNAL FR SIGNAL FOOT PARKING BRAKE SWITCH GND C-CAN LOW BPM SIG GND CAN HIGH GRN WIRE GROUND GRY WIRE HAC RELAY CONTROL BRAKE SWITCH ESC OFF SWITCH ON HAC RELAY SIGNAL HIGH LOW HOT AT ALL TIMES HOT IN ON OR START HYDRAULIC POWER UNIT I/P JUNCTION BOX I/P-D I/P-E I/P-G IPS CONTROL MDPS FUSE MODULE MODULE 1 FUSE MODULE 4 HEV FUSE NCA WIRE ON/START IN ORG/ WIRE ORG/BLK WIRE PARKING BRAKE SWITCH PCM (LEFT (LEFT REAR OF SIDE OF DASH) ENGINE COMPT) PDM 2 FUSE PNK WIRE PNK/BLK WIRE POWER POWER BPM GND POWER CONNECTOR POWER PNK DISTRIBUTION SYSTEM PNK/ WIRE RED WIRE ROOM LP FUSE SMART KEY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) WHEEL SPEED ON/START INPUT WHT WIRE YAW RATE SENSOR (FRONT OF CENTER CONSOLE) YEL WIRE

1 2 3 POWER U POWER V POWER W 1 2 3 POWER W POWER V POWER U 1 2 POWER RELAY (-) POWER RELAY (+) 11 12 19 20 C-CAN HIGH C-CAN LOW H-CAN HIGH H-CAN LOW ALT FUSE B+ GND B-CAN TRANSCEIVER BATTERY BATTERY, BATTERY FUSE BOX BLK WIRE BLK/ORG WIRE BLU WIRE BMS ASSEMBLY BMS CONTROL MODULE BRN WIRE C-CAN TRANSCEIVER CHARGE IND COMPUTER DATA COMPUTER DATA LINES SYSTEM E/R FUSE, RELAY BOX GRN WIRE GRY WIRE HOT IN ON OR START HOT IN OR OR START HYBRID BATTERY (+) HYBRID CONTROL UNIT HYBRID INVERTER HYBRID POWER CONTROL UNIT HYBRID STARTER, GENERATOR MOTOR I/P JUNCTION BOX I/P-A I/P-D I/P-G INSTRUMENT CLUSTER INVERTER INVERTER FUSE LINES SYSTEM LOW HIGH LOWER VOLTAGE DC-DC CONVERTER MAIN RLY MCU MODULE 1 FUSE MODULE 4 HEV FUSE ORG/ WIRE ORG/BLK WIRE PNK 3 5 ON/START INPUT H-CAN HIGH H-CAN LOW PRA PRE RLY PRA MAIN+ RLY WIRE PNK WIRE PNK/WHT WIRE POWER RELAY ASSEMBLY PRA VOUT GND GND C-CAN HIGH C-CAN LOW PRA RLY GND PRA MAIN RLY GND PRA VIB GND PRECHARGE RLY RED WIRE RED/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 POWER U POWER V POWER W 1 2 3 POWER W POWER V POWER U 1 2 POWER RELAY (-) POWER RELAY (+) 30 11 12 19 20 START SIG C-CAN HIGH C-CAN LOW H-CAN HIGH H-CAN LOW 6 9 B+ FOB-IN ALT FUSE B+ GND BATTERY BATTERY, BATTERY FUSE BOX BLK WIRE BLK/ORG WIRE BLU WIRE BMS CONTROL MODULE COMPUTER DATA COMPUTER DATA LINES SYSTEM E/R FUSE, RELAY BOX FOB HOLDER FOB-IN GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START HYBRID CONTROL UNIT HYBRID INVERTER HYBRID POWER CONTROL UNIT HYBRID STARTER, GENERATOR MOTOR I/P JUNCTION BOX I/P-A I/P-D I/P-E INVERTER INVERTER FUSE LINES SYSTEM LOWER VOLTAGE DC-DC CONVERTER MAIN RLY MCU MODULE 4 HEV FUSE ORG/ WIRE ORG/BLK WIRE P/N SW PDM 2 FUSE PNK 3 5 ON/START INPUT H-CAN HIGH H-CAN LOW PRA PRE RLY PRA MAIN+ RLY WIRE PNK WIRE PNK/WHT WIRE POWER RELAY HYBRID ASSEMBLY BATTERY PRA VOUT GND GND C-CAN HIGH C-CAN LOW PRA RLY GND PRA MAIN RLY GND PRA VIB GND PRECHARGE RLY RED WIRE RED/WHT WIRE SMART KEY CONTROL MODULE (UNDER RIGHT SIDE OF DASH) START 1 FUSE START FEEDBACK START SIG START STOP BUTTON SWITCH TRANSAXLE RANGE SWITCH (TOP OF TRANSAXLE ASSEMBLY) BMS ASSEMBLY WHT WIRE WHT/BLK WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/ORG WIRE

1 2 3 PWR-W PWR-V PWR-U 1 2 ELTC A/C CPSR ELTC A/C CPSR 1 2 PWR RLY ASLY (-) PWR RLY ASLY (+) AIR CONDITIONING SYSTEM BLK WIRE BLK/ORG WIRE BLU WIRE BRN WIRE C-CAN (H) COMPUTER DATA LINES SYSTEM ENGINE ROOM FUSE, RELAY BOX (LEFT SIDE OF ENGINE COMPT) FUSE-INVERTER GND FUSE-INVERTER GND FUSE-MDL 4 HEV FUSE-INVERTER C-CAN (L) GRN WIRE HOT AT ALL TIMES HOT IN ON OR START HYBRID INVERTER HYBRID MOTOR HYBRID POWER CONTROL UNIT HYBRID STARTER, GENERATOR MOTOR I/P-A I/P-D INSTRUMENT PANEL JUNCTION BOX (ABOVE LEFT KICK PANEL) INVERTER FUSE LOW VOLTAGE DC-DC CONVERTER MCU MODULE 4 HEV FUSE ORG/ WIRE PNK RSLVR (+) TEMP SNSR SHIELD TEMP SNSR SIG H CAN (L) WIRE PNK WIRE PWR-U PWR-V PWR-W RED WIRE RSLVER SHIELD RSLVER SHIELD TEMP SNSR-GND RSLVER SNSR 1 RSLVER SNSR 2 RSLVER SNSR 3 RSLVER SNSR 4 RSLVR (+) RSLVR (+) TEMP SNSR SHIELD TEMP SNSR SIG RSLVR (-) RSLVR SHIELD RSLVR (SNSR 2) RSLVR (SNSR 1) RSLVR (SNSR 4) RSLVR (SNSR 3) RSLVR (SNSR 4) RSLVR (SNSR 3) RSLVR (-) TEMP SNSR SIG TEMP SNSR-GND TEMP SNSR-GND H CAN (H) TEMP SNSR-SHIELD TMP SNSR-SHIELD WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLU WIRE