Kia Optima II (2005-2008) egr fuse Wiring diagrams
This page contains all the electrical diagrams for the component. egr fuse, in which he is found in the car Kia Optima II (2005-2008). You can view various wiring diagrams where this component is used, as well as go to more detailed diagrams to see the complete connection and interaction in the system. All diagrams have links to quickly jump to the corresponding section with the component for easy viewing..
egr fuse wiring diagram (1 of 9)
A/CON COMP FUSE
AIR CON RELAY
BLK WIRE
BLU WIRE
BRN WIRE
COMPRESSOR)
COND FUSIBLE LINK
CONDENSER FAN HIGH RELAY 1
CONDENSER FAN HIGH RELAY 2
CONDENSER FAN LOW RELAY
CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR)
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
COOLING FAN LOW RELAY
COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR)
ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT)
GRN WIRE
GRN/ORG WIRE
GRY WIRE
HOT AT ALL TIMES
JB-01
JB-02
JB-03
JC-07
MAIN FUSE
ORG/ WIRE
PNK WIRE
RAD FUSIBLE LINK
RED WIRE
TRIPLE SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT)
WHT WIRE
WIPER/ WASHER SYSTEM
YEL WIRE
Go to component -> 2.4l, automatic a/c circuit, early production (2 of 2) -> EGR FUSE
egr fuse wiring diagram (2 of 9)
12 B-01 (B)
15 B-01 (B) 13
22 B-01 (D)
A/T
B-01 (A)
B-01 (B)
B-01 (C)
BLK WIRE
BLU WIRE
BRN WIRE
C-01 (C)
COND FUSIBLE LINK
CONDENSER FAN HIGH RELAY 1
CONDENSER FAN HIGH RELAY 2
CONDENSER FAN LOW RELAY
CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR)
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
COOLING FAN LOW RELAY
COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR)
ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT)
ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE)
FROM ENGINE COMPARTMENT FUSE/RELAY BOX A/C RELAY (DIAGRAM 1 OF 2)
GRN WIRE
GRN/ORG WIRE
GRY WIRE
HOT AT ALL TIMES
INSTRUMENT CLUSTER
JB-02
JB-03
JC-07
M/T
MAIN FUSE
ORG/ WIRE
PNK WIRE
RAD FUSIBLE LINK
RED WIRE
SHORT CONNECTOR SC-05
WHT WIRE
YEL WIRE
Go to component -> 2.4l, manual a/c circuit, early production (2 of 2) -> EGR FUSE
egr fuse wiring diagram (3 of 9)
A/CON COMP FUSE
AIR CON RELAY
BLK WIRE
BLU WIRE
BRN WIRE
COMPRESSOR)
COND FUSIBLE LINK
CONDENSER FAN HIGH RELAY 1
CONDENSER FAN HIGH RELAY 2
CONDENSER FAN LOW RELAY
CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR)
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
COOLING FAN LOW RELAY
COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT)
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-01
GRN WIRE
GRN/ORG WIRE
GRY WIRE
HOT AT ALL TIMES
JB-01
JB-02
JB-03
JC-07
MAIN FUSE
MAIN RELAY (BEHIND RIGHT SIDE OF DASH
MID
ORG/ WIRE
PNK WIRE
RAD FUSIBLE LINK
RED WIRE
TRIPLE SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT)
WHT WIRE
WIPER/ WASHER SYSTEM
YEL WIRE
Go to component -> 2.7l, automatic a/c circuit, early production (2 of 2) -> EGR FUSE
egr fuse wiring diagram (4 of 9)
A/CON COMP FUSE
AIR CON RELAY
BLK WIRE
BLU WIRE
COMPRESSOR)
COND FUSIBLE LINK
CONDENSER FAN HIGH RELAY 1
CONDENSER FAN HIGH RELAY 2
CONDENSER FAN LOW RELAY
CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR)
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
COOLING FAN LOW RELAY
COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT)
GRN WIRE
GRN/ORG WIRE
GRY WIRE
HOT AT ALL TIMES
JB-02
JB-03
JC-07
MAIN FUSE
MAIN RELAY (BEHIND RIGHT SIDE OF DASH
ORG/ WIRE
PNK WIRE
RAD FUSIBLE LINK
RED WIRE
THERMISTOR (BEHIND RIGHT SIDE OF DASH)
WHT WIRE
YEL WIRE
Go to component -> 2.7l, manual a/c circuit, early production (2 of 2) -> EGR FUSE
egr fuse wiring diagram (5 of 9)
2.7L 2.4L A/T 2.4L M/T
BLK WIRE
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
COOLING FAN LOW RELAY
COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT)
ENGINE CONTROL MODULE (2.7L, 2.4L M/T) (BEHIND LOWER CENTER OF DASH)
ENGINE/TRANSAXLE CONTROL MODULE (2.4L A/T)
GRN WIRE
HOT AT ALL TIMES
INSTRUMENT CLUSTER
JB-02
JB-03
JOINT CONNECTOR JC-07
RAD FUSE
RED WIRE
SC-05 (2.4L)
WHT WIRE
YEL WIRE
Go to component -> Cooling fan circuit, early production -> EGR FUSE
egr fuse wiring diagram (6 of 9)
1 2 (W/ CRUISE CONTROL) (W/O CRUISE CONTROL)
2.4L
A/T
AIR CON RELAY
AIR CON SWITCH AIR CON CONTROL UNIT
AUDIO TRUNK ROOM LAMP DIGITAL CLOCK INSTRUMENT CLUSTER
BLK WIRE
BLU WIRE
CONDENSER FAN HIGH RELAY 1
CONDENSER FAN HIGH RELAY 2
COOLING FAN HIGH RELAY 1
COOLING FAN HIGH RELAY 2
CRANKSHAFT POSITION SENSOR
D/CLOCK FUSE
D/LOCK FUSE
DEFOGGER SYSTEM
DIODE
DOOR LOCK RELAY
DOOR UNLOCK RELAY
DRIVER POWER SEAT ADJUSTER SWITCH
EGR FUSE
EGR SOLENOID
ENGINE CONTROL MODULE
ENGINE/TRANSAXLE CONTROL MODULE
ETACS
FROM FUEL PUMP FUSE (DIAGRAM 3 OF 5)
FROM INJECTOR FUSE (DIAGRAM 2 OF 5)
FUEL PUMP RELAY SENSOR 4
FUSE (DIAGRAM 5 OF 5)
GRN WIRE
HAZARD RELAY HAZARD SWITCH
HOMELINK
IDLE SPEED ACTUATOR
JB-01
JB-03
JB-05
JB-06
JB-06 JB-08
JB-06 JB-11
JB-08
JB-09 JB-12 GLASS ANTENNA
JB-10
JB-11 JB-13
JB-12
JB-13
JB-14
KEYLESS ENTRY UNIT REAR DEFROSTER REAR DEFROSTER
LEFT DOOR COURTESY LAMP
LEFT SUNVISOR LAMP
M/T
MANUAL A/C AUTOMATIC A/C
MASS AIR FLOW SENSOR
ORG/ WIRE
P/SEAT (DRIVE) FUSE
PASSENGER POWER SEAT ADJUSTER SWITCH TWO TURN UNLOCK RELAY
PNK (2.4L) (2.7L) WIRE
PNK 2.4L 2.7L 2.4L WIRE
PNK 2.7L PNK PNK WIRE
PNK PNK (2.4L) (2.7L) (2.4L) (2.7L) WIRE
PNK PNK PNK WIRE
PNK WIRE
POWER ANTENNA
POWER FUSE 1
POWER FUSE 2
PURGE SOLENOID VALVE CAMSHAFT POSITION SENSOR
REAR DEFROSTER RELAY
RED WIRE
RIGHT POWER MIRROR MOTOR LEFT POWER MIRROR MOTOR
RIGHT SUNVISOR LAMP ROOM LAMP MAP LAMP OVERHEAD CONSOLE
ROOM FUSE
RR HTD FUSE
SHUNT
STOP FUSE HAZARD FUSE
STOPLIGHT SWITCH
T/LID FUSE P/SEAT (PASS) FUSE ECS FUSE
TRUNK LID RELAY FUEL/TRUNK LID SWITCH
W/O SUN ROOF
YEL WIRE
YEL/BLK WIRE
Go to component -> Power distribution circuit, early production (4 of 5) -> EGR FUSE
egr fuse wiring diagram (7 of 9)
10 11 12 13 14 15 16 17 PNK WIRE
BLK WIRE
BLK/ORG WIRE
BLU WIRE
BRN WIRE
CANISTER CLOSE VALVE (UNDER LEFT REAR OF VEHICLE)
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT)
ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE)
FUEL TEMPERATURE SENSOR
GRN WIRE
GRY WIRE
HOT IN ON OR START
IGN COIL FUSE
INJ FUSE
INSTRUMENT CLUSTER SYSTEM
JB-01
JB-03
MANIFOLD ABSOLUTE PRESSURE SENSOR (ON INTAKE MANIFOLD)
NCA WIRE
ORG/ WIRE
PNK 4 5 WIRE
PNK PNK PNK 7 8 9 WIRE
PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 9 WIRE
PNK WIRE
RED WIRE
SC-04
SC-05
SENSOR 1 (ON LEFT REAR SIDE OF ENGINE)
SENSOR 2 (ON LEFT FRONT SIDE OF ENGINE)
SENSOR FUSE
TANK PRESSURE SENSOR (NEAR TOP OF FUEL TANK)
WHT WIRE
YEL WIRE
Go to component -> Wiring diagram engine performance 2.4l, a/t early production (2 of 4) -> EGR FUSE
egr fuse wiring diagram (8 of 9)
15 16 PNK WIRE
BLK WIRE
BLK/ORG WIRE
BLU WIRE
BRN WIRE
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT)
FUEL TEMPERATURE SENSOR (NEAR TOP OF FUEL TANK)
HOT IN ON OR START
IGN COIL FUSE
INJ FUSE
MAP SENSOR (ON INTAKE MANIFOLD)
MULTI-PURPOSE CHECK CONNECTOR
NCA WIRE
ORG/ WIRE
PNK 6 7 8 WIRE
PNK 9 10 11 12 13 14 WIRE
PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE
PNK PNK PNK PNK WIRE
PNK WIRE
RED WIRE
SC-04
SC-05
SENSOR 1 (ON LEFT REAR SIDE OF ENGINE)
SENSOR 2 (ON LEFT FRONT SIDE OF ENGINE)
SENSOR FUSE
TANK PRESSURE SENSOR (NEAR TOP OF FUEL TANK)
WHT WIRE
YEL WIRE
Go to component -> Wiring diagram engine performance 2.4l, m/t early production (2 of 3) -> EGR FUSE
egr fuse wiring diagram (9 of 9)
BLK WIRE
BLK/ORG WIRE
BLU WIRE
BRN WIRE
EGR FUSE
ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT)
FUEL PUMP
FUEL PUMP FUSE
FUEL PUMP RELAY (BEHIND RIGHT SIDE OF DASH)
FUEL TANK
GRN WIRE
GRN/ORG WIRE
GRY WIRE
HOT AT ALL TIMES
INJ FUSE
J/C 15
JB-01
JB-03
JB-13 JB-10
KNOCK SENSOR 1 (ON ENGINE BLOCK)
KNOCK SENSOR 2 (ON ENGINE BLOCK)
NCA WIRE
ORG/ WIRE
PNK PNK 10 11 WIRE
PNK PNK PNK PNK PNK 2 3 4 5 6 7 8 WIRE
PNK WIRE
RED WIRE
SENSOR 1 (ON RIGHT REAR SIDE OF ENGINE)
SENSOR 2 (ON LEFT FRONT SIDE OF ENGINE)
SENSOR 3 (ON RIGHT FRONT SIDE OF ENGINE)
SENSOR 4 (ON LEFT REAR SIDE OF ENGINE)
SENSOR FUSE
WHT WIRE
YEL WIRE
YEL/ORG WIRE
Go to component -> Wiring diagram engine performance 2.7l, early production (2 of 4) -> EGR FUSE
