Kia Optima II (2005-2008) defogger system Wiring diagrams

17 B-01 (B) 22 B-01 (D) 17 I-01 (A) 18 21 21 22 B-01 (A) 12 B-01 (B) 15 B-01 (B) 13 A/CON FUSE A/CON SW FUSE AIR CON CONTROL UNIT (UNDER CENTER OF DASH) AIR QUALITY SENSOR (FRONT OF RADIATOR) AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) B-01 (A) B-01 (B) B-01 (B) B-01 (B) B-01 (C) 4 BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-01 ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE A/T ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (NEAR REAR PACKAGE TRAY) INSTRUMENT CLUSTER INTAKE ACTUATOR (BEHIND RIGHT SIDE OF DASH) J/C-06 J/C-05 JB-01 JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) M/T MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SC-06 SHORT CONNECTOR SC-05 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON COMP FUSE A/CON FUSE A/CON SW FUSE AIR CON RELAY AIR CON SWITCH BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE CLUSTER FUSE COMPRESSOR) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH THERMISTOR (BEHIND RIGHT SIDE OF DASH) TO ENGINE COMPARTMENT FUSE/RELAY BOX EGR FUSE (DIAGRAM 2 OF 2) TRIPLE SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 8 9 PNK PNK WIRE A/CON FUSE A/CON SW FUSE AIR QUALITY SENSOR (FRONT OF RADIATOR) AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) B-01 (F) B-01 (M) B-01 (P) 18 23 24 25 29 40 B-01 (V) BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) AIR CON CONTROL UNIT (UNDER CENTER OF DASH) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (NEAR REAR PACKAGE TRAY) INTAKE ACTUATOR (BEHIND RIGHT SIDE OF DASH) J/C 05 J/C 06 JB-01 JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SC-06 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON FUSE A/CON SW FUSE AIR CON SWITCH B-01 (M) BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) INSTRUMENT CLUSTER CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (ECM) (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HIGH LOW HOT AT ALL TIMES HOT AT ALL TIMES JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 MID MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK 8 9 B-01 (V) 23 B-01 (P) 18 23 24 25 29 40 B-01 (F) 25 24 WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH TRIPLE SWITCH (RIGHT FRONT OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE YEL/ORG WIRE

A/C CONTROL MODULE A/CON FUSE A/CON SW FUSE ACTIVE IN-CAR, HUMIDITY SENSOR (FOREWORD OF HVAC ASSEMBLY) AMBIENT TEMPERATURE SENSOR (CENTER OF FRONT RADIATOR SUPPORT) BLK WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MTR FUSE BLOWER RELAY BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BRN WIRE BRN/BLK WIRE BRN/ORG WIRE COMPUTER DATA LINES SYSTEM COOL WARM F/B VENT DEF F/B FRE REC F/B GND GND CRUISE CONTROL SYSTEM DEFOGGER SYSTEM EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN ON HTD SWITCH I/P JUNCTION BOX (LEFT END OF DASH) I/P-A I/P-B I/P-C I/P-D I/P-E I/P-G INPUT INPUT ILL- INTAKE ACTUATOR (BEHIND RIGHT SIDE OF DASH) J/C K LINE MEMORY FUSE MODE ACTUATOR (BEHIND LEFT SIDE OF DASH) MODULE 2 FUSE MOTOR ORG/ WIRE ORG/BLK WIRE PHOTO SENSOR AUTO LIGHT, PHOTO SENSOR (RIGHT SIDE OF DASH) PNK/BLK WIRE POWER CONNECTOR POWER TRANSISTOR RED WIRE RED/ORG WIRE SENS TEMPERATURE ACTUATOR (BEHIND RIGHT SIDE OF DASH) WATER TEMPERATURE SENSOR (RIGHT SIDE OF DASH) WHT WIRE YEL WIRE YEL/BLK WIRE

1 1 2 2 3 3 PNK PNK WIRE 10 10 JB-10 JB-10 AIR CONDITIONING SYSTEM BLK WIRE BLU WIRE CHARGING STARTING/CHARGING SYSTEM SYSTEM CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM DOOR DOOR LOCKS LOCKS SYSTEM SYSTEM DOOR KEY HOLE ILLUMINATION (W/O BURGLAR ALARM) DOOR LOCKS SYSTEM ELECTRONIC POWER STEERING SYSTEM ETACS ETACS FUSE GRN WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START ILLUM ILLUM INTERIOR LIGHTS LIGHTS SYSTEM SYSTEM JB-07 JB-10 JB-13 JB-14 JC-17 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) ORG/ WIRE PNK PNK PNK WIRE PNK WIRE POWER WINDOWS SYSTEM WARNING SYSTEM YEL WIRE

2 3 4 5 DEFOGGER RLY PWR WIN RLY CTRL 7 8 9 10 11 12 DR UNLK RLY CTRL ANTI-THEFT SYSTEM B/ALARM RLY CTRL BCM (BEHIND LEFT SIDE OF DASH) BLK WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BRN WIRE BRN/BLK WIRE BRN/ORG WIRE CLUSTER FUSE COMPUTER DATA LINES D/CLOCK FUSE DEFOGGER SYSTEM DEFOGGER SYSTEM POWER WINDOWS SYSTEM DOOR LOCKS SYSTEM DOOR SWITCH DOOR SWITCH DOOR SWITCH TRUNK SWITCH HOOD SWITCH DRIVER SEAT BUCKLE SWITCH EXTERIOR LIGHTS SYSTEM WIPER/WASHER SYSTEM GRN WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE HEAD LAMP RLY HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ON MODULE 2 FUSE HOT IN ON OR ACC HOT IN ON OR START I/P JUNCTION BOX (LEFT END OF DASH) I/P-A I/P-B I/P-D I/P-E ILL CONTROL SEAT BELT IND GROUND JOINT CONNECTOR KEY ILLUMINATION SWITCH MEMORY FUSE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK TRUNK ID RLY CTRL WIRE PNK WIRE PNK/BLK WIRE POWER CONNECTOR RED WIRE RED/BLK WIRE RED/ORG WIRE SEAT BELT/ KEY OPERATING WARNING SRS CONTROL MODULE (FRONT OF CENTER CONSOLE) STARTING/CHARGING SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM STARTING/CHARGING SYSTEM WHT WIRE WHT/BLK WIRE WIPER/WASHER SYSTEM YEL WIRE YEL/BLK WIRE YEL/ORG WIRE

A/C CONTROL MODULE A/CON FUSE A/CON SW FUSE BLK WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MTR FUSE BLOWER RELAY BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BRN WIRE BRN/BLK WIRE BRN/ORG WIRE DEFOGGER SYSTEM EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN ON I/P JUNCTION BOX (LEFT END OF DASH) I/P-A I/P-B I/P-C I/P-D I/P-E I/P-G INPUT ILL- GATE DRAIN F/B F/B F/B SENS+ MOTOR+ SIG SWITCH GND INTAKE ACTUATOR (BEHIND RIGHT SIDE OF DASH) MEMORY FUSE MODE ACTUATOR (BEHIND LEFT SIDE OF DASH) MODULE 2 FUSE ORG/ WIRE ORG/BLK WIRE POWER CONNECTOR POWER TRANSISTOR RED WIRE RED/ORG WIRE SIG TEMPERATURE ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE YEL/BLK WIRE

1 2 (W/ CRUISE CONTROL) (W/O CRUISE CONTROL) 2.4L A/T AIR CON RELAY AIR CON SWITCH AIR CON CONTROL UNIT AUDIO TRUNK ROOM LAMP DIGITAL CLOCK INSTRUMENT CLUSTER BLK WIRE BLU WIRE CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 CRANKSHAFT POSITION SENSOR D/CLOCK FUSE D/LOCK FUSE DEFOGGER SYSTEM DIODE DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER POWER SEAT ADJUSTER SWITCH EGR FUSE EGR SOLENOID ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE ETACS FROM FUEL PUMP FUSE (DIAGRAM 3 OF 5) FROM INJECTOR FUSE (DIAGRAM 2 OF 5) FUEL PUMP RELAY SENSOR 4 FUSE (DIAGRAM 5 OF 5) GRN WIRE HAZARD RELAY HAZARD SWITCH HOMELINK IDLE SPEED ACTUATOR JB-01 JB-03 JB-05 JB-06 JB-06 JB-08 JB-06 JB-11 JB-08 JB-09 JB-12 GLASS ANTENNA JB-10 JB-11 JB-13 JB-12 JB-13 JB-14 KEYLESS ENTRY UNIT REAR DEFROSTER REAR DEFROSTER LEFT DOOR COURTESY LAMP LEFT SUNVISOR LAMP M/T MANUAL A/C AUTOMATIC A/C MASS AIR FLOW SENSOR ORG/ WIRE P/SEAT (DRIVE) FUSE PASSENGER POWER SEAT ADJUSTER SWITCH TWO TURN UNLOCK RELAY PNK (2.4L) (2.7L) WIRE PNK 2.4L 2.7L 2.4L WIRE PNK 2.7L PNK PNK WIRE PNK PNK (2.4L) (2.7L) (2.4L) (2.7L) WIRE PNK PNK PNK WIRE PNK WIRE POWER ANTENNA POWER FUSE 1 POWER FUSE 2 PURGE SOLENOID VALVE CAMSHAFT POSITION SENSOR REAR DEFROSTER RELAY RED WIRE RIGHT POWER MIRROR MOTOR LEFT POWER MIRROR MOTOR RIGHT SUNVISOR LAMP ROOM LAMP MAP LAMP OVERHEAD CONSOLE ROOM FUSE RR HTD FUSE SHUNT STOP FUSE HAZARD FUSE STOPLIGHT SWITCH T/LID FUSE P/SEAT (PASS) FUSE ECS FUSE TRUNK LID RELAY FUEL/TRUNK LID SWITCH W/O SUN ROOF YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE C/LIGHTER FUSE DEFOGGER SYSTEM GRN WIRE HOT IN ACC OR ON JB-09 JC-17 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT POWER MIRROR MOTOR ORG/ WIRE POWER MIRROR SWITCH RED WIRE RIGHT POWER MIRROR MOTOR WHT WIRE YEL WIRE