Kia Optima I facelift (2002-2005) jb-11 Wiring diagrams

17 B-01 (B) 22 B-01 (D) 17 I-01 (A) 18 21 21 22 B-01 (A) 12 B-01 (B) 15 B-01 (B) 13 A/CON FUSE A/CON SW FUSE AIR CON CONTROL UNIT (UNDER CENTER OF DASH) AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) AQS (AT LOWER FRONT CENTER OF VEHICLE) B-01 (A) B-01 (B) B-01 (B) B-01 (B) B-01 (C) 4 BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-01 ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE A/T ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (UNDER CENTER REAR OF VEHICLE) INSTRUMENT CLUSTER INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C G-11 J/C-06 J/C-05 JB-01 JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) M/T MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SHORT CONNECTOR SC-05 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

A/T ABS CONTROL UNIT AIR BAG CONTROL UNIT (AT LOWER CENTER OF DASH, ON FLOOR TUNNEL) BLK WIRE BLU WIRE BRN/ORG WIRE CHECK CONNECTOR (BEHIND LEFT SIDE OF DASH) CLUSTER FUSE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE (BEHIND LOWER EPS UNIT (BEHIND LOWER CENTER OF DASH) FUEL TANK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START J/C 05 JB-01 JB-06 JB-11 JB-15 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) KEYLESS ENTRY UNIT LT BLU WIRE M/T ORG/ WIRE ORG/BLK WIRE PNK WIRE SC-01 SUNROOF FUSE WHT/BLK WIRE YEL WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON COMP FUSE A/CON FUSE A/CON SW FUSE AIR CON RELAY AIR CON SWITCH BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE CLUSTER FUSE COMPRESSOR) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) THERMISTOR (BEHIND RIGHT SIDE OF DASH) TO ENGINE COMPARTMENT FUSE/RELAY BOX EGR FUSE (DIAGRAM 2 OF 2) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 8 9 PNK PNK WIRE A/CON FUSE A/CON SW FUSE AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) AQS (AT LOWER FRONT CENTER OF VEHICLE) B-01 (F) B-01 (M) B-01 (P) 18 23 24 25 29 40 B-01 (V) BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-10 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) AIR CON CONTROL UNIT (UNDER CENTER OF DASH) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (UNDER CENTER REAR OF VEHICLE) INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SC-06 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

ABS CONTROL UNIT AIR BAG CONTROL UNIT (AT LOWER CENTER OF DASH, ON FLOOR TUNNEL) BLK WIRE BLU WIRE BRN/ORG WIRE CHECK CONNECTOR (BEHIND LEFT SIDE OF DASH) CLUSTER FUSE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) EPS UNIT (BEHIND LOWER CENTER OF DASH) FUEL PUMP RELAY (BEHIND RIGHT FUEL TANK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START J/C 05 JB-01 JB-06 JB-11 JB-15 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) KEYLESS ENTRY UNIT LT BLU WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE SC-01 SIDE OF DASH) SUNROOF FUSE TCM (BEHIND LOWER CENTER OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON FUSE A/CON SW FUSE AIR CON SWITCH B-01 (M) BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) INSTRUMENT CLUSTER CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (ECM) (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HIGH LOW HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MID MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK 8 9 B-01 (V) 23 B-01 (P) 18 23 24 25 29 40 B-01 (F) 25 24 WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

ABS 1 FUSE ABS 2 FUSE ABS CONTROL UNIT (AT RIGHT REAR OF ENGINE COMPARTMENT) ABS FUSE ABS IND. BLK WIRE BLK/ORG WIRE BLU WIRE BRAKE FLUID LEVEL SENSOR (ON BRAKE MASTER CYLINDER RESERVOIR ASSEMBLY) BRAKE IND BRN WIRE BRN/ORG WIRE CLUSTER FUSE CRUISE CONTROL SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) JB-03 ENGINE CONTROL MODULE (2.7L) (BEHIND LOWER CENTER OF DASH) GRN WIRE GRN/BLK WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ON OR START INSTRUMENT CLUSTER J/C 06 JB-06 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT FRONT WHEEL SPEED SENSOR (ON LEFT FRONT STEERING KNUCKLE) LEFT REAR WHEEL SPEED SENSOR (ON LEFT REAR BRAKE BACKING PLATE) MULTI-PURPOSE CHECK CONNECTOR ORG/ WIRE PNK WIRE RED WIRE SC-01 SC-06 STOP FUSE STOPLIGHT SWITCH (ABOVE BRAKE PEDAL, ON BRACKET) TCS OFF IND TCS SWITCH TRANSMISSIONS SYSTEM WHT WIRE

2.4L 2.4L A/T 2.7L 2 3 4 5 6 7 8 9 10 11 12 3 4 F-11 F-11 4 1 (W/O AIR BAG) (W/ AIR BAG) A/T ANTI-LOCK BRAKES SYSTEM BACK-UP FUSE BLK WIRE BRN WIRE BRN/BLK WIRE CLOCKSPRING/ COMBINATION SWITCH CLUSTER FUSE CLUTCH SWITCH (ABOVE CLUTCH PEDAL) CRUISE CONTROL SWITCH CRUISE CONTROL UNIT (AT RIGHT REAR CORNER OF ENGINE COMPARTMENT) CRUISE IND CRUISE REMOTE CONTROL SWITCH ELECTRONIC POWER STEERING SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) EPS FUSE F-10 GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START INSTRUMENT CLUSTER JB-01 JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-03 JB-06 JB-08 JB-09 JB-11 JOINT CONNECTOR JOINT CONNECTOR SC-01 JUNCTION BLOCK JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LT BLU WIRE M/T M/T A/T ORG/ WIRE PNK WIRE SET/ COAST RESUME/ ACCEL SHORT CONNECTOR SC-01 SHORT CONNECTOR SC-06 SPEED SENSOR (ON TOP OF TRANSAXLE) STARTING/ CHARGING SYSTEM STOP FUSE STOPLIGHT SWITCH (ABOVE BRAKE PEDAL, ON BRACKET) WHT WIRE WHT/BLK WIRE YEL WIRE

1 8 PNK WIRE A/C SIG A/C SYSTEM B-01 BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHECK ENGINE IND CLOSE CLUSTER FUSE CONDENSER COOLING FANS SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR SOL EGR SOLENOID (RIGHT REAR OF ENGINE COMPT) IDLE SPEED ACTUATOR (ON THROTTLE BODY) ENGINE COMPARTMENT FUSE/RELAY BLOCK ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) F PMP CTRL PURGE SOL IGN COIL 1 FAN RLY FAN RLY A/C REL IGN COIL 2 FUEL INJECTORS FUEL PUMP FUEL TANK GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION COIL 2 (TOP FRONT OF ENGINE) (CENTER OF FIREWALL) IGNITION FAILURE SENSOR IGNITION SWITCH INJ 1 INJ 3 PNK WIRE INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM JB-03 JB-03 PNK PNK WIRE JB-07 JUNCTION BLOCK JB-07 PNK JB-01 ENGINE COMPARTMENT FUSE/RELAY BLOCK WIRE JB-11 JUNCTION BLOCK LOCK LT GRN/BLK WIRE MAIN FUSE MIL CTRL P/S SW RLY CTRL NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK BATTERY GROUND INJ 2 INJ 4 WIRE PNK BATTERY GROUND WIRE PNK GEN FR A/C PRES WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK WIRE PNK/BLK WIRE POWER STEERING SWITCH (ON POWER STEERING OIL PUMP) RED WIRE RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM GEN G TAN WIRE TAN/BLK WIRE TO SPARK PLUGS WHT WIRE YEL WIRE YEL/ORG WIRE

A/C REL CTRL CCV CNTRL ABS CONTROL UNIT (RIGHT REAR OF ENGINE COMPT) AIR CONDITIONING SYSTEM B-01 BLK WIRE BLK/ORG WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHCK ENG IND CHECK ENGINE IND FUEL LAMP CMP SIG IN CMP SENS GRD COM NTWK HI COM NTWK LO COOLING FANS SYSTEM CYLINDER 3/6 CYLINDER 2/5 CYLINDER 1/4 ENG SPD SIG FAN REL CTRL ENGINE COMPARTMENT FUSE/RELAY BLOCK ENGINE CONTROL MODULE (ECM) (BEHIND LOWER CENTER OF DASH) FUEL GAUGE FUEL PMP REL GRN WIRE GRN/ORG WIRE GROUND HOT IN ON OR START HOT IN ON OR START CLUSTER FUSE IG-COIL FUSE IGNITION COIL (LEFT REAR OF ENGINE) INSTRUMENT CLUSTER JB-03 JB-11 JUNCTION BLOCK MCA NCA WIRE ORG/ WIRE PNK FTP SENS WIRE PNK WIRE RED WIRE RIGHT FRONT WHEEL SENSOR (WITHOUT ABS/TCS) SENS GROUND SENS PWR PNK WIRE SPARK PLUGS TACH TANK PRESSURE SENSOR (NEAR TOP OF FUEL TANK) TRANSAXLE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) UNUSED) B-01 W/ ABS/TCS WHEEL SPD IN A/C SIG INPUT A/C ON INPUT A/C PRESS WHL SPD IN WHL SPD IN FAN REL CTRL WHT WIRE YEL WIRE