Kia Optima I facelift (2002-2005) jb-10 Wiring diagrams

17 B-01 (B) 22 B-01 (D) 17 I-01 (A) 18 21 21 22 B-01 (A) 12 B-01 (B) 15 B-01 (B) 13 A/CON FUSE A/CON SW FUSE AIR CON CONTROL UNIT (UNDER CENTER OF DASH) AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) AQS (AT LOWER FRONT CENTER OF VEHICLE) B-01 (A) B-01 (B) B-01 (B) B-01 (B) B-01 (C) 4 BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-01 ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE A/T ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (UNDER CENTER REAR OF VEHICLE) INSTRUMENT CLUSTER INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C G-11 J/C-06 J/C-05 JB-01 JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) M/T MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SHORT CONNECTOR SC-05 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON COMP FUSE A/CON FUSE A/CON SW FUSE AIR CON RELAY AIR CON SWITCH BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE CLUSTER FUSE COMPRESSOR) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) THERMISTOR (BEHIND RIGHT SIDE OF DASH) TO ENGINE COMPARTMENT FUSE/RELAY BOX EGR FUSE (DIAGRAM 2 OF 2) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 8 9 PNK PNK WIRE A/CON FUSE A/CON SW FUSE AMBIENT SENSOR (IN FRONT OF CONDENSER FAN SHROUD) AQS (AT LOWER FRONT CENTER OF VEHICLE) B-01 (F) B-01 (M) B-01 (P) 18 23 24 25 29 40 B-01 (V) BLK WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE BRN/ORG WIRE C-10 (C) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE EVAPORATOR SENSOR (BEHIND RIGHT SIDE OF DASH) G-01 (B) AIR CON CONTROL UNIT (UNDER CENTER OF DASH) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE GRY/BLK WIRE HIGH BLOWER RELAY (BEHIND RIGHT END OF DASH) HOT AT ALL TIMES HOT IN ON HUMIDITY SENSOR (UNDER CENTER REAR OF VEHICLE) INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-02 JB-05 JB-09 JB-10 JB-11 JC-08 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE ORG/ WIRE PHOTO SENSOR (ON TOP CENTER OF DASH) PNK 3 5 WIRE PNK PNK WIRE PNK WIRE POWER TRANSISTOR (BEHIND RIGHT SIDE OF DASH) RED WIRE SC-06 TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE WIPER FUSE YEL WIRE YEL/ORG WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON FUSE A/CON SW FUSE AIR CON SWITCH B-01 (M) BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) INSTRUMENT CLUSTER CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (ECM) (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HIGH LOW HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MID MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK 8 9 B-01 (V) 23 B-01 (P) 18 23 24 25 29 40 B-01 (F) 25 24 WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

A/T BACK-UP FUSE BLK WIRE GRN WIRE HOT IN ON OR START INSTRUMENT CLUSTER SYSTEM JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) JB-03 JB-06 JB-08 JB-10 JB-13 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT REAR COMBINATION LAMP LEFT BACK-UP LAMP M/T PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RIGHT REAR COMBINATION LAMP RIGHT BACK- UP LAMP TRANSMISSIONS SYSTEM WHT WIRE

1 1 2 2 3 3 PNK PNK WIRE 10 10 JB-10 JB-10 AIR CONDITIONING SYSTEM BLK WIRE BLU WIRE CHARGING STARTING/CHARGING SYSTEM SYSTEM CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM DOOR DOOR LOCKS LOCKS SYSTEM SYSTEM DOOR KEY HOLE ILLUMINATION (W/O BURGLAR ALARM) DOOR LOCKS SYSTEM ELECTRONIC POWER STEERING SYSTEM ETACS ETACS FUSE GRN WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START ILLUM ILLUM INTERIOR LIGHTS LIGHTS SYSTEM SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEMS JB-07 JB-10 JB-13 JB-14 JC-17 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) ORG/ WIRE PNK PNK WIRE PNK WIRE POWER WINDOWS SYSTEM WARNING SYSTEM YEL WIRE

AIR CON CONTROL UNIT AIR CON SWITCH AUTOMATIC A/C BLK WIRE BLU WIRE ETACS JB-01 JB-06 JB-07 JB-10 JB-12 JOINT CONNECTOR JC-05 JOINT CONNECTOR JC-06 JOINT CONNECTOR JC-17 JOINT CONNECTOR JC-18 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT POWER MIRROR HEATER MANUAL A/C REAR DEFROSTER REAR DEFROSTER RELAY REAR HTD FUSE RED WIRE RIGHT POWER MIRROR HEATER

1 2 3 4 5 6 7 8 SOLENOID CTRL SOLENOID CTRL 1 N-03 1 Q-01 2.4L B-01 BLK WIRE BRN WIRE C-01 CRUISE CONTROL UNIT (AT RIGHT REAR CORNER OF ENGINE COMPARTMENT) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DIAGNOSIS VSS INPUT ON INPUT GROUND ELECTRONIC TIME, ALARM CONTROL SYSTEM (ETACS) EPS FUSE EPS SOLENOID (ON POWER STEERING RACK HYDRAULIC CONTROL UNIT) EPS UNIT (BEHIND LOWER CENTER OF DASH) HOT IN ON I-01 INSTRUMENT CLUSTER JB-08 POWER DISTRIBUTION SYSTEM JB-09 JB-10 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) M/T A/T SHORT CONNECTOR SC-02 SPEED SENSOR (ON TOP OF TRANSAXLE) SPEEDOMETER WHT WIRE WHT/BLK WIRE

2.4L A/T AIR CON CONTROL UNIT AIR CON RELAY AIR CON SWITCH DIGITAL CLOCK INSTRUMENT CLUSTER AIR CON SWITCH LEFT POWER MIRROR MOTOR RIGHT POWER MIRROR MOTOR AUDIO TRUNK ROOM LAMP AUTOMATIC A/C BLK WIRE BLU WIRE CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 CRANK ANGLE SENSOR D/CLOCK FUSE D/LOCK FUSE DEFOGGER SYSTEM DIODE DOOR KEY HOLE ILLUMINATION DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER POWER SEAT ADJUSTER SWITCH EGR FUSE EGR SOLENOID ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE ETACS FROM FUEL PUMP FROM INJECTOR FUEL PUMP RELAY FUEL/TRUNK LID SWITCH TWO TURN UNLOCK RELAY GRN/BLK WIRE HAZARD RELAY HAZARD SWITCH IDLE SPEED ACTUATOR IGNITION KEY ILLUMINATION, DOOR WARNING SWITCH JB-01 JB-03 JB-05 JB-06 JB-06 JB-08 JB-08 JB-09 JB-10 JB-11 JB-11 JB-06 JB-06 JB-12 JB-13 JB-13 JB-12 JB-14 KEYLESS ENTRY UNIT LEFT DOOR COURTESY LAMP M/T MANUAL A/C MASS AIRFLOW SENSOR (2.4L) CRANKSHAFT POSITION ORG/ WIRE OVERHEAD CONSOLE MAP LAMP ROOM LAMP P/SEAT (DRIVE) FUSE PASSENGER POWER SEAT ADJUSTER SWITCH PNK (2.4L) (2.7L) WIRE PNK 2.4L 2.7L 2.4L WIRE PNK 2.7L PNK PNK WIRE PNK PNK (2.4L) (2.7L) (2.4L) (2.7L) WIRE PNK PNK PNK WIRE PNK WIRE POWER FUSE 1 POWER FUSE 2 PURGE SOLENOID VALVE CAMSHAFT POSITION SENSOR REAR DEFROSTER (POWER ANTENNA) REAR DEFROSTER RELAY RED WIRE RIGHT DOOR COURTESY LAMP ROOM FUSE RR HTD FUSE SENSOR (2.7L) SENSOR 4 SHUNT STOP FUSE HAZARD FUSE STOPLIGHT SWITCH T/LID FUSE P/SEAT (PASS) FUSE ECS FUSE TRUNK LID RELAY W/ SUN ROOF W/O SUN ROOF YEL WIRE YEL/BLK WIRE

2.4L 2.4L 2.7L CANISTER CLOSE VALVE A/BAG FUSE A/BAG IND FUSE A/CON FUSE AIR BAG CONTROL UNIT AUTOMATIC A/C MANUAL A/C BLOWER RELAY BRN WIRE BURGLAR ALARM RELAY BURGLAR ALARM RELAY A/T CLUSTER FUSE COOLING FAN LOW RELAY CRUISE CONTROL UNIT STOP LIGHT SWITCH CRUISE CONTROL UNIT WASHER MOTOR AQS DATA LINK CONNECTOR DRIVER BUCKLE SWITCH ENGINE/ CONTROL MODULE (ECM) (2.4L) ETACS ETACS FUSE FROM BLOWER RELAY (DIAGRAM 2 OF 5) FROM COOLING FAN HIGH RELAY 2 (DIAGRAM 4 OF 5) FROM IGNITION SWITCH (DIAGRAM 1 OF 5) FUSE GRN WIRE HAZARD SWITCH HIGH BLOWER RELAY AIR CON SWITCH HOME LINK IGNITION LOCK SWITCH INHIBITOR SWITCH (A/T) INSTRUMENT CLUSTER JB-01 JB-02 JB-03 JB-03 JB-01 JB-05 JB-09 JB-10 JB-11 JB-11 PNK WIRE JB-14 JB-15 JOINT CONNECTOR SC-01 PNK PNK WIRE JOINT CONNECTOR SC-06 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT SEAT WARMER SWITCH M/T ORG/ WIRE PASSENGER BUCKLE SWITCH PASSENGER PRESENCE DETECTION SENSOR PNK JB-05 WIRE PNK PNK PNK PNK WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE RED WIRE RIGHT SEAT WARMER SWITCH S/HTD FUSE SENSOR 1 SENSOR 2 SENSOR 2 SENSOR 3 SENSOR 1 SENSOR FUSE STARTER RELAY SUN ROOF RELAY AIR CON CONTROL UNIT (AUTOMATIC A/C) T/SIG FUSE TEMP SWITCH DIGITAL CLOCK AUTO LIGHT CONTROL UNIT W/ B/ALARM W/ IGN LOCK SWITCH W/O B/ALARM W/O IGN LOCK SWITCH WIPER FUSE WIPER MOTOR WIPER RELAY YEL WIRE