Kia Optima I facelift (2002-2005) egr sol Wiring diagrams

1 8 PNK WIRE 10 11 12 13 14 15 16 17 PNK WIRE A/C PRES A/C SYSTEM AIR FLOW SENS CMP SENS SENS GROUND P/N INPUT AIR TEMP SENS B-01 BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHECK ENGINE IND CLOSE CLUSTER FUSE CONDENSER COOLING FANS SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR SOL ENGINE COMPARTMENT FUSE/RELAY BLOCK MAIN FUSE ENGINE/TRANSAXLE CONTROL MODULE (E/TCM) (BEHIND LOWER CENTER OF DASH) F PMP CTRL A/C REL MIL CTRL SPARK TIMING INJ 3 FAN RLY FAN RLY FUEL INJECTORS FUEL PUMP FUEL TANK GEN FR INJ 2 GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES ECU FUSE HOT IN ON OR START IGN COIL 1 IGN COIL 2 PNK WIRE IGNITION COIL 1 (TOP REAR OF ENGINE) IGNITION COIL 2 (TOP FRONT OF ENGINE) (CENTER OF FIREWALL) IGNITION FAILURE SENSOR IGNITION SWITCH INJ 1 INJ 4 INSTR CLUSTER SYSTEM INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM JB-01 PNK 6 5 PNK WIRE JB-03 JB-07 JUNCTION BLOCK JB-07 PNK JB-01 ENGINE COMPARTMENT FUSE/RELAY BLOCK WIRE JB-11 PNK C-01 WIRE JUNCTION BLOCK LOCK LT GRN/BLK WIRE MEM PWR B-01 NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK FUEL LVL WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 9 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER STEERING SWITCH (ON POWER STEERING PUMP) (BELOW CENTER CONSOLE) PURGE SOL CCV PURGE SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) RED WIRE RED/BLK WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TO SPARK PLUGS WHT WIRE YEL WIRE YEL/ORG WIRE

1 8 PNK WIRE A/C SIG A/C SYSTEM B-01 BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHECK ENGINE IND CLOSE CLUSTER FUSE CONDENSER COOLING FANS SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR SOL EGR SOLENOID (RIGHT REAR OF ENGINE COMPT) IDLE SPEED ACTUATOR (ON THROTTLE BODY) ENGINE COMPARTMENT FUSE/RELAY BLOCK ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) F PMP CTRL PURGE SOL IGN COIL 1 FAN RLY FAN RLY A/C REL IGN COIL 2 FUEL INJECTORS FUEL PUMP FUEL TANK GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION COIL 2 (TOP FRONT OF ENGINE) (CENTER OF FIREWALL) IGNITION FAILURE SENSOR IGNITION SWITCH INJ 1 INJ 3 PNK WIRE INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM JB-03 JB-03 PNK PNK WIRE JB-07 JUNCTION BLOCK JB-07 PNK JB-01 ENGINE COMPARTMENT FUSE/RELAY BLOCK WIRE JB-11 JUNCTION BLOCK LOCK LT GRN/BLK WIRE MAIN FUSE MIL CTRL P/S SW RLY CTRL NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK BATTERY GROUND INJ 2 INJ 4 WIRE PNK BATTERY GROUND WIRE PNK GEN FR A/C PRES WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK WIRE PNK/BLK WIRE POWER STEERING SWITCH (ON POWER STEERING OIL PUMP) RED WIRE RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM GEN G TAN WIRE TAN/BLK WIRE TO SPARK PLUGS WHT WIRE YEL WIRE YEL/ORG WIRE