Kia Optima I facelift (2002-2005) egr fuse Wiring diagrams

A/CON COMP FUSE AIR CON RELAY BLK WIRE BLU WIRE BRN WIRE COMPRESSOR) COND FUSIBLE LINK CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 CONDENSER FAN LOW RELAY CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR) COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 COOLING FAN LOW RELAY COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES JB-01 JB-02 JB-03 JC-07 MAIN FUSE ORG/ WIRE PNK WIRE RAD FUSIBLE LINK RED WIRE TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE WIPER/ WASHER SYSTEM YEL WIRE

12 B-01 (B) 15 B-01 (B) 13 22 B-01 (D) A/T B-01 (A) B-01 (B) B-01 (C) BLK WIRE BLU WIRE BRN WIRE C-01 (C) COND FUSIBLE LINK CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 CONDENSER FAN LOW RELAY CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR) COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 COOLING FAN LOW RELAY COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COOLANT TEMPERATURE SENSOR (ON REAR OF ENGINE) FROM ENGINE COMPARTMENT FUSE/RELAY BOX A/C RELAY (DIAGRAM 1 OF 2) GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER JB-02 JB-03 JC-07 M/T MAIN FUSE ORG/ WIRE PNK WIRE RAD FUSIBLE LINK RED WIRE SHORT CONNECTOR SC-05 WHT WIRE YEL WIRE

A/CON COMP FUSE AIR CON RELAY BLK WIRE BLU WIRE BRN WIRE COMPRESSOR) COND FUSIBLE LINK CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 CONDENSER FAN LOW RELAY CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR) COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 COOLING FAN LOW RELAY COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-01 GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES JB-01 JB-02 JB-03 JC-07 MAIN FUSE MAIN RELAY (BEHIND RIGHT SIDE OF DASH MID ORG/ WIRE PNK WIRE RAD FUSIBLE LINK RED WIRE TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE WIPER/ WASHER SYSTEM YEL WIRE

A/CON COMP FUSE AIR CON RELAY BLK WIRE BLU WIRE COMPRESSOR) COND FUSIBLE LINK CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 CONDENSER FAN LOW RELAY CONDENSER FAN MOTOR (BEHIND RIGHT SIDE OF RADIATOR) COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 COOLING FAN LOW RELAY COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES JB-02 JB-03 JC-07 MAIN FUSE MAIN RELAY (BEHIND RIGHT SIDE OF DASH ORG/ WIRE PNK WIRE RAD FUSIBLE LINK RED WIRE THERMISTOR (BEHIND RIGHT SIDE OF DASH) WHT WIRE YEL WIRE

2.7L 2.4L A/T 2.4L M/T BLK WIRE COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 COOLING FAN LOW RELAY COOLING FAN MOTOR (BEHIND LEFT SIDE OF RADIATOR) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (2.7L, 2.4L M/T) (BEHIND LOWER CENTER OF DASH) ENGINE CONTROLS SYSTEM (2.4L) ENGINE/TRANSAXLE CONTROL MODULE (2.4L A/T) GRN WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER JB-02 JB-03 JOINT CONNECTOR JC-07 RAD FUSE RED WIRE WHT WIRE YEL WIRE

2.4L A/T AIR CON CONTROL UNIT AIR CON RELAY AIR CON SWITCH DIGITAL CLOCK INSTRUMENT CLUSTER AIR CON SWITCH LEFT POWER MIRROR MOTOR RIGHT POWER MIRROR MOTOR AUDIO TRUNK ROOM LAMP AUTOMATIC A/C BLK WIRE BLU WIRE CONDENSER FAN HIGH RELAY 1 CONDENSER FAN HIGH RELAY 2 COOLING FAN HIGH RELAY 1 COOLING FAN HIGH RELAY 2 CRANK ANGLE SENSOR D/CLOCK FUSE D/LOCK FUSE DEFOGGER SYSTEM DIODE DOOR KEY HOLE ILLUMINATION DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER POWER SEAT ADJUSTER SWITCH EGR FUSE EGR SOLENOID ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE ETACS FROM FUEL PUMP FROM INJECTOR FUEL PUMP RELAY FUEL/TRUNK LID SWITCH TWO TURN UNLOCK RELAY GRN/BLK WIRE HAZARD RELAY HAZARD SWITCH IDLE SPEED ACTUATOR IGNITION KEY ILLUMINATION, DOOR WARNING SWITCH JB-01 JB-03 JB-05 JB-06 JB-06 JB-08 JB-08 JB-09 JB-10 JB-11 JB-11 JB-06 JB-06 JB-12 JB-13 JB-13 JB-12 JB-14 KEYLESS ENTRY UNIT LEFT DOOR COURTESY LAMP M/T MANUAL A/C MASS AIRFLOW SENSOR (2.4L) CRANKSHAFT POSITION ORG/ WIRE OVERHEAD CONSOLE MAP LAMP ROOM LAMP P/SEAT (DRIVE) FUSE PASSENGER POWER SEAT ADJUSTER SWITCH PNK (2.4L) (2.7L) WIRE PNK 2.4L 2.7L 2.4L WIRE PNK 2.7L PNK PNK WIRE PNK PNK (2.4L) (2.7L) (2.4L) (2.7L) WIRE PNK PNK PNK WIRE PNK WIRE POWER FUSE 1 POWER FUSE 2 PURGE SOLENOID VALVE CAMSHAFT POSITION SENSOR REAR DEFROSTER (POWER ANTENNA) REAR DEFROSTER RELAY RED WIRE RIGHT DOOR COURTESY LAMP ROOM FUSE RR HTD FUSE SENSOR (2.7L) SENSOR 4 SHUNT STOP FUSE HAZARD FUSE STOPLIGHT SWITCH T/LID FUSE P/SEAT (PASS) FUSE ECS FUSE TRUNK LID RELAY W/ SUN ROOF W/O SUN ROOF YEL WIRE YEL/BLK WIRE

10 11 12 13 14 15 16 17 PNK WIRE BLK WIRE BLK/ORG WIRE BLU WIRE BRN WIRE CANISTER CLOSE VALVE (UNDER LEFT REAR OF VEHICLE) EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BLOCK ENGINE COOLANT TEMPERATURE SENSOR (REAR OF CYLINDER HEAD) FUEL TEMPERATURE SENSOR GRN WIRE GRY WIRE HOT IN ON, START IGN COIL FUSE INJ FUSE INSTRUMENT CLUSTER SYSTEM J/C (BEHIND FRONT OF CENTER CONSOLE) JB-03 MANIFOLD ABSOLUTE PRESSURE SENSOR (ON INTAKE MANIFOLD) NCA WIRE ORG/ WIRE PNK 4 5 WIRE PNK PNK PNK 7 8 9 WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 9 WIRE PNK WIRE RED WIRE RED/BLK WIRE SENSOR 1 (ON FRONT CONV OUTLET) SENSOR 2 (ON EXH MANIFOLD) SENSOR FUSE TANK PRESSURE SENSOR (NEAR TOP OF FUEL TANK) WHT WIRE YEL WIRE

15 16 PNK WIRE BLK WIRE BLK/ORG WIRE BLU WIRE BRN WIRE EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BLOCK FUEL TEMPERATURE SENSOR (NEAR TOP OF FUEL TANK) HOT IN ON, START IGN COIL FUSE INJ FUSE J/C (BELOW FRONT OF CENTER CONSOLE) MAP SENSOR (ON INTAKE MANIFOLD) NCA WIRE ORG/ WIRE PNK 6 7 8 WIRE PNK 9 10 11 12 13 14 WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK PNK PNK PNK WIRE PNK WIRE RED WIRE RED/BLK WIRE SENSOR 1 (LEFT REAR SIDE OF ENGINE) SENSOR 2 (ON LEFT FRONT SIDE OF ENGINE) SENSOR FUSE TANK PRESSURE SENSOR (NEAR TOP OF FUEL TANK) WHT WIRE YEL WIRE

BLK WIRE BLK/ORG WIRE BLU WIRE BRN WIRE EGR FUSE ENGINE COMPARTMENT FUSE/RELAY BLOCK FUEL PUMP FUEL PUMP FUSE FUEL PUMP RELAY (BEHIND RIGHT SIDE OF DASH) FUEL TANK GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES INJ FUSE JB-01 JB-03 JB-13 JB-10 JUNCTION BLOCK KNOCK SENSOR 1 (ON ENGINE BLOCK) KNOCK SENSOR 2 (ON ENGINE BLOCK) NCA WIRE ORG/ WIRE PNK PNK 10 11 WIRE PNK PNK PNK PNK PNK 2 3 4 5 6 7 8 WIRE PNK WIRE RED WIRE SENSOR 1 (BOTTOM OF RIGHT EXHAUST MANIFOLD) SENSOR 2 (NEAR TOP OF LEFT EXHAUST MANIFOLD) SENSOR 3 (ON BOTTOM OF RIGHT EXHAUST MANIFOLD DOWNPIPE) SENSOR 4 (ON FRONT EXHAUST PIPE, UPSTREAM OF CATALYTIC CONVERTER) SENSOR FUSE TAN WIRE WHT WIRE YEL WIRE YEL/ORG WIRE