Kia Optima I facelift (2002-2005) cluster fuse Wiring diagrams

A/T ABS CONTROL UNIT AIR BAG CONTROL UNIT (AT LOWER CENTER OF DASH, ON FLOOR TUNNEL) BLK WIRE BLU WIRE BRN/ORG WIRE CHECK CONNECTOR (BEHIND LEFT SIDE OF DASH) CLUSTER FUSE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE ENGINE/TRANSAXLE CONTROL MODULE (BEHIND LOWER EPS UNIT (BEHIND LOWER CENTER OF DASH) FUEL TANK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START J/C 05 JB-01 JB-06 JB-11 JB-15 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) KEYLESS ENTRY UNIT LT BLU WIRE M/T ORG/ WIRE ORG/BLK WIRE PNK WIRE SC-01 SUNROOF FUSE WHT/BLK WIRE YEL WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON COMP FUSE A/CON FUSE A/CON SW FUSE AIR CON RELAY AIR CON SWITCH BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE CLUSTER FUSE COMPRESSOR) D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) THERMISTOR (BEHIND RIGHT SIDE OF DASH) TO ENGINE COMPARTMENT FUSE/RELAY BOX EGR FUSE (DIAGRAM 2 OF 2) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

ABS CONTROL UNIT AIR BAG CONTROL UNIT (AT LOWER CENTER OF DASH, ON FLOOR TUNNEL) BLK WIRE BLU WIRE BRN/ORG WIRE CHECK CONNECTOR (BEHIND LEFT SIDE OF DASH) CLUSTER FUSE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) EPS UNIT (BEHIND LOWER CENTER OF DASH) FUEL PUMP RELAY (BEHIND RIGHT FUEL TANK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START J/C 05 JB-01 JB-06 JB-11 JB-15 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) KEYLESS ENTRY UNIT LT BLU WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE SC-01 SIDE OF DASH) SUNROOF FUSE TCM (BEHIND LOWER CENTER OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE

17 I-01 (A) 3 5 PNK WIRE A/CON FUSE A/CON SW FUSE AIR CON SWITCH B-01 (M) BLK WIRE BLK/ORG WIRE BLOWER FUSE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY (BEHIND RIGHT SIDE OF DASH) BLOWER SWITCH BLU WIRE BRN WIRE BRN/ORG WIRE C-01 (C) INSTRUMENT CLUSTER CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) ENGINE CONTROL MODULE (ECM) (BEHIND LOWER CENTER OF DASH) ETACS (ON JUNCTION BLOCK) ETACS FUSE GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRY WIRE HIGH LOW HOT AT ALL TIMES HOT IN ON HOT IN ON, START INTAKE ACTUATOR (BEHIND RIGHT END OF DASH) J/C 05 J/C 06 JB-01 JB-02 JB-03 JB-05 JB-09 JB-10 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) MID MODE ACTUATOR (BEHIND CENTER OF DASH) NCA WIRE OFF ORG/ WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK PNK 8 9 B-01 (V) 23 B-01 (P) 18 23 24 25 29 40 B-01 (F) 25 24 WIRE PNK PNK WIRE PNK SC-06 WIRE PNK WIRE RED WIRE RESISTOR (BEHIND RIGHT SIDE OF DASH) TEMP ACTUATOR (BEHIND RIGHT SIDE OF DASH) TEMP SWITCH (BEHIND RIGHT SIDE OF DASH) TRIPLE SWITCH (ON TOP OF A/C RECEIVER-DRIER ASSEMBLY) WHT WIRE YEL WIRE YEL/ORG WIRE

ABS 1 FUSE ABS 2 FUSE ABS CONTROL UNIT (AT RIGHT REAR OF ENGINE COMPARTMENT) ABS FUSE ABS IND. BLK WIRE BLK/ORG WIRE BLU WIRE BRAKE FLUID LEVEL SENSOR (ON BRAKE MASTER CYLINDER RESERVOIR ASSEMBLY) BRAKE IND BRN WIRE BRN/ORG WIRE CLUSTER FUSE CRUISE CONTROL SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) JB-03 ENGINE CONTROL MODULE (2.7L) (BEHIND LOWER CENTER OF DASH) GRN WIRE GRN/BLK WIRE HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN ON OR START INSTRUMENT CLUSTER J/C 06 JB-06 JB-11 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LEFT FRONT WHEEL SPEED SENSOR (ON LEFT FRONT STEERING KNUCKLE) LEFT REAR WHEEL SPEED SENSOR (ON LEFT REAR BRAKE BACKING PLATE) MULTI-PURPOSE CHECK CONNECTOR ORG/ WIRE PNK WIRE RED WIRE SC-01 SC-06 STOP FUSE STOPLIGHT SWITCH (ABOVE BRAKE PEDAL, ON BRACKET) TCS OFF IND TCS SWITCH TRANSMISSIONS SYSTEM WHT WIRE

BLK WIRE BLU WIRE BURGLAR ALARM RELAY (ON JUNCTION BLOCK) CLUSTER FUSE D/CLOCK FUSE DRL FUSE ETACS FUSE GRN WIRE HAZARD FUSE HAZARD RELAY HOOD SWITCH (AT RIGHT FRONT CORNER OF ENGINE COMPARTMENT) HOT AT ALL TIMES HOT IN JB-01 JB-02 JB-02 ENGINE COMPT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) JB-06 JB-09 JB-13 PNK WIRE JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) KEYLESS ENTRY UNIT (BEHIND LOWER CENTER OF DASH) LEFT FRONT DOOR SWITCH RIGHT FRONT DOOR SWITCH LEFT REAR DOOR SWITCH ORG/ WIRE ORG/BLK WIRE PNK WIRE RED/ORG WIRE RIGHT REAR DOOR SWITCH STARTING/ CHARGING SYSTEM TRUNK UNLOCK SWITCH JC-05 YEL WIRE

1 1 2 2 3 3 PNK PNK WIRE 10 10 JB-10 JB-10 AIR CONDITIONING SYSTEM BLK WIRE BLU WIRE CHARGING STARTING/CHARGING SYSTEM SYSTEM CLUSTER FUSE D/CLOCK FUSE DEFOGGER SYSTEM DOOR DOOR LOCKS LOCKS SYSTEM SYSTEM DOOR KEY HOLE ILLUMINATION (W/O BURGLAR ALARM) DOOR LOCKS SYSTEM ELECTRONIC POWER STEERING SYSTEM ETACS ETACS FUSE GRN WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START ILLUM ILLUM INTERIOR LIGHTS LIGHTS SYSTEM SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEMS JB-07 JB-10 JB-13 JB-14 JC-17 JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) ORG/ WIRE PNK PNK WIRE PNK WIRE POWER WINDOWS SYSTEM WARNING SYSTEM YEL WIRE

2.4L 2.4L A/T 2.7L 2 3 4 5 6 7 8 9 10 11 12 3 4 F-11 F-11 4 1 (W/O AIR BAG) (W/ AIR BAG) A/T ANTI-LOCK BRAKES SYSTEM BACK-UP FUSE BLK WIRE BRN WIRE BRN/BLK WIRE CLOCKSPRING/ COMBINATION SWITCH CLUSTER FUSE CLUTCH SWITCH (ABOVE CLUTCH PEDAL) CRUISE CONTROL SWITCH CRUISE CONTROL UNIT (AT RIGHT REAR CORNER OF ENGINE COMPARTMENT) CRUISE IND CRUISE REMOTE CONTROL SWITCH ELECTRONIC POWER STEERING SYSTEM ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPT) EPS FUSE F-10 GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START INSTRUMENT CLUSTER JB-01 JB-01 ENGINE COMPARTMENT FUSE/RELAY BOX (AT LEFT SIDE OF ENGINE COMPARTMENT) JB-03 JB-06 JB-08 JB-09 JB-11 JOINT CONNECTOR JOINT CONNECTOR SC-01 JUNCTION BLOCK JUNCTION BLOCK (BEHIND LEFT SIDE OF DASH) LT BLU WIRE M/T M/T A/T ORG/ WIRE PNK WIRE SET/ COAST RESUME/ ACCEL SHORT CONNECTOR SC-01 SHORT CONNECTOR SC-06 SPEED SENSOR (ON TOP OF TRANSAXLE) STARTING/ CHARGING SYSTEM STOP FUSE STOPLIGHT SWITCH (ABOVE BRAKE PEDAL, ON BRACKET) WHT WIRE WHT/BLK WIRE YEL WIRE

1 8 PNK WIRE 10 11 12 13 14 15 16 17 PNK WIRE A/C PRES A/C SYSTEM AIR FLOW SENS CMP SENS SENS GROUND P/N INPUT AIR TEMP SENS B-01 BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHECK ENGINE IND CLOSE CLUSTER FUSE CONDENSER COOLING FANS SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR SOL ENGINE COMPARTMENT FUSE/RELAY BLOCK MAIN FUSE ENGINE/TRANSAXLE CONTROL MODULE (E/TCM) (BEHIND LOWER CENTER OF DASH) F PMP CTRL A/C REL MIL CTRL SPARK TIMING INJ 3 FAN RLY FAN RLY FUEL INJECTORS FUEL PUMP FUEL TANK GEN FR INJ 2 GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES ECU FUSE HOT IN ON OR START IGN COIL 1 IGN COIL 2 PNK WIRE IGNITION COIL 1 (TOP REAR OF ENGINE) IGNITION COIL 2 (TOP FRONT OF ENGINE) (CENTER OF FIREWALL) IGNITION FAILURE SENSOR IGNITION SWITCH INJ 1 INJ 4 INSTR CLUSTER SYSTEM INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM JB-01 PNK 6 5 PNK WIRE JB-03 JB-07 JUNCTION BLOCK JB-07 PNK JB-01 ENGINE COMPARTMENT FUSE/RELAY BLOCK WIRE JB-11 PNK C-01 WIRE JUNCTION BLOCK LOCK LT GRN/BLK WIRE MEM PWR B-01 NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK FUEL LVL WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 9 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER STEERING SWITCH (ON POWER STEERING PUMP) (BELOW CENTER CONSOLE) PURGE SOL CCV PURGE SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) RED WIRE RED/BLK WIRE STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TO SPARK PLUGS WHT WIRE YEL WIRE YEL/ORG WIRE

1 8 PNK WIRE A/C SIG A/C SYSTEM B-01 BLK WIRE BLU WIRE BRN WIRE BRN/ORG WIRE C-01 CHECK ENGINE IND CLOSE CLUSTER FUSE CONDENSER COOLING FANS SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) ECM CONTROL RELAY (BEHIND RIGHT SIDE OF DASH) EGR SOL EGR SOLENOID (RIGHT REAR OF ENGINE COMPT) IDLE SPEED ACTUATOR (ON THROTTLE BODY) ENGINE COMPARTMENT FUSE/RELAY BLOCK ENGINE CONTROL MODULE (BEHIND LOWER CENTER OF DASH) F PMP CTRL PURGE SOL IGN COIL 1 FAN RLY FAN RLY A/C REL IGN COIL 2 FUEL INJECTORS FUEL PUMP FUEL TANK GRN WIRE GRN/ORG WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION COIL 2 (TOP FRONT OF ENGINE) (CENTER OF FIREWALL) IGNITION FAILURE SENSOR IGNITION SWITCH INJ 1 INJ 3 PNK WIRE INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM JB-03 JB-03 PNK PNK WIRE JB-07 JUNCTION BLOCK JB-07 PNK JB-01 ENGINE COMPARTMENT FUSE/RELAY BLOCK WIRE JB-11 JUNCTION BLOCK LOCK LT GRN/BLK WIRE MAIN FUSE MIL CTRL P/S SW RLY CTRL NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK BATTERY GROUND INJ 2 INJ 4 WIRE PNK BATTERY GROUND WIRE PNK GEN FR A/C PRES WIRE PNK PNK PNK PNK PNK PNK PNK 1 2 3 4 5 6 7 8 WIRE PNK WIRE PNK/BLK WIRE POWER STEERING SWITCH (ON POWER STEERING OIL PUMP) RED WIRE RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM GEN G TAN WIRE TAN/BLK WIRE TO SPARK PLUGS WHT WIRE YEL WIRE YEL/ORG WIRE