Kia K5 I facelift (2013-2015) smart junction box Wiring diagrams

A/C CONTROL MODULE ACTIVE AIR FLAP BLK WIRE BLU WIRE BLU/ORG WIRE C-CAN HIGH C-CAN LOW C/FAN FUSE C/FAN PWR CTRL C/FAN RELAY COMPUTER COMPUTER DATA CONDITIONING COOLING FAN COOLING FAN CONTROLLER CURRENT DETECTING DATA LINES E/R FUSE, RELAY BOX E/R-A E/R-B ECT GROUND ECT SIGNAL ECU 1 FUSE ELECTRIC WATER PUMP EMS BOX ENGINE CONTROL RELAY ENGINE COOLANT TEMPERATURE SENSOR ENGINE RLY CTRL EWP FUSE EWP RELAY GROUND HOT AT ALL TIMES HOT IN ON HOT IN ON OR START HYBRID FUSE, RELAY BOX HYBRID WATER PUMP I/P-D JOINT CONNECTOR UMC LINES SYSTEM MEMORY POWER MODULE 3 FUSE MODULE 6 FUSE MODULE 7 FUSE NCA WIRE ON/START ON/START INPUT ORG/ WIRE PCM PNK WIRE POWER PROCESSING PWN DRIVER RED WIRE SENSOR SENSOR 1 FUSE SIGNAL SMART JUNCTION BOX SYSTEM WATER PUMP F/B WHT WIRE YEL WIRE

26 VFS ATM SOLENOID BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM DOWN SHIFT E/R FUSE, RELAY BOX FEEDBACK GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GROUND GRY WIRE H-CAN HIGH H-CAN LOW HOT AT ALL TIMES HOT IN ON OR START I/P-E I/P-F INPUT SPD SIG INPUT SPD SPLY INPUT SPEED SENSOR LINE VFS MEMORY POWER MODULE 4 FUSE OD VFS OIL TEMP SNSR (-) OIL TEMPERATURE SENSOR ON/START INPUT ORG/ WIRE OUTPUT SPD SIG OUTPUT SPD SPLY OUTPUT SPEED SENSOR P/N SWITCH PCM PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RED/BLK WIRE RIGHT END OF DASH) SELECT SWITCH SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SMART KEY CONTROL MODULE SOL PWR 1 SOL PWR 2 SS A SS B START FUSE START SIGNAL T/CON VFS TCU 1 FUSE TCU 2 FUSE TRANSAXLE RANGE SWITCH UD VFS UP SHIFT WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLU WIRE

26 VFS ATM SOLENOID BLK WIRE BLU WIRE BLU/ORG WIRE BRN WIRE C-CAN HIGH C-CAN LOW COMPUTER DATA LINES SYSTEM DOWN SHIFT E/R FUSE, RELAY BOX GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GROUND GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-F INPUT SPD SIG INPUT SPD SPLY INPUT SPEED SENSOR LINE VFS MEMORY POWER MODULE 4 FUSE OD VFS OIL TEMP SNSR (-) OIL TEMPERATURE SENSOR ON/START INPUT ORG/ WIRE OUTPUT SPD SIG OUTPUT SPD SPLY OUTPUT SPEED SENSOR P/N SWITCH (P N POSITION SWITCH CLOSE) PCM PNK WIRE RED WIRE RED/BLK WIRE SELECT SWITCH SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SS A SS B STARTING/ CHARGING SYSTEM T/CON VFS TCU 1 FUSE TCU 2 FUSE TRANSAXLE RANGE SWITCH UD VFS UP SHIFT V SOL 1 V SOL 2 WHT WIRE WHT/BLK WIRE YEL WIRE

26 VFS APT SNSR SUPPLY BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE SW FUSE BRN WIRE E/R FUSE, RELAY BOX ETC MOTOR, THROTTLE POSITION SENSOR ETC OUT (-) ETC OUTPUT (+) EWGA DC MTR OUT (+) EWGA FDBK SNSR SIG EWGA FEEDBACK GND FTPS GND FTPS SIG GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-D IGN COIL CTRL CYL 2 IGN COIL CTRL CYL 4 INPUT CIRCUIT LINE VFS MAP SNSR 2 SIG MODULE 3 FUSE MOTOR OD VFS ON/START IN ORG/ WIRE OTS SIG P/N SW PCM (LEFT SIDE OF ENGINE COMP) PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE RIGHT END OF DASH) SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SNSR SIG STARTING/ CHARGING SYSTEM STOP LAMP SWITCH STOP LMP SW STOP LP SIG STOP SIGNAL ELECTRONIC MODULE T/CON VFS TCU 1 FUSE TCU 2 FUSE TPS SUPPLY TRANSAXLE RANGE SWITCH UD VFS WHT WIRE YEL WIRE

??? ??? ACT ECO IN BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE C-CAN TRANSCEIVER CHECK ENGINE IND CLOCK- SPRING CLUSTER FUSE COMPUTER DATA LINES SYSTEM CRUISE CRUISE ON/OFF CRUISE OUT DES DN SELECT ECO IND GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-E I/P-F ILL INSTRUMENT CLUSTER LEAK CURRENT AUTOCUT DEVICE MEMORY 1 FUSE MICOM ORG/ WIRE PNK WIRE PNK/BLK WIRE RED WIRE REG RES+ RIGHT CRUISE REMOTE CONTROL SWITCH RIGHT TRIP ECO REMOTE CONTROL SWITCH S GND SET- SMART JUNCTION BOX TRIP TRIP OUT TRIP SW(-) W/ STEERING WHEEL HEATER W/O STEERING WHEEL HEATER WHT WIRE YEL WIRE

26 VFS APT SNSR SUPPLY BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRAKE SW FUSE BRN WIRE E/R FUSE, RELAY BOX ETC MOTOR, THROTTLE POSITION SENSOR ETC OUT (-) ETC OUTPUT (+) FTPS GND FTPS SIG GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-D IGN COIL CTRL CYL 2 IGN COIL CTRL CYL 4 INPUT CIRCUIT LINE VFS MODULE 3 FUSE MOTOR OD VFS ON/START IN ORG/ WIRE P/N SW PCM (LEFT SIDE OF ENGINE COMP) PNK WIRE PNK/BLK WIRE RED WIRE RIGHT END OF DASH) SIGNAL 1 SIGNAL 2 SIGNAL 3 SIGNAL 4 SMART JUNCTION BOX SNSR SIG STARTING/ CHARGING SYSTEM STOP LAMP SWITCH STOP LMP SW STOP LP SIG STOP SIGNAL ELECTRONIC MODULE T/CON VFS TCU 1 FUSE TCU 2 FUSE THROTTLE POSITION SENSOR TPS SUPPLY TRANSAXLE RANGE SWITCH UD VFS WHT WIRE YEL WIRE

??? ??? ACT ECO IN BLK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BRN WIRE C-CAN TRANSCEIVER CHECK ENGINE IND CLOCKSPRING CLUSTER FUSE COMPUTER DATA LINES SYSTEM CRUISE CRUISE ON/OFF CRUISE OUT DES DN SELECT ECO IND GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ON OR START I/P-E I/P-F ILL INSTRUMENT CLUSTER LEAK CURRENT AUTOCUT DEVICE MCU MEMORY 1 FUSE ORG/ WIRE PNK WIRE PNK/BLK WIRE RED WIRE REG RES+ RIGHT CRUISE REMOTE CONTROL SWITCH RIGHT TRIP ECO REMOTE CONTROL SWITCH S GND SET- SMART JUNCTION BOX STEERING WHEEL) TRIP TRIP OUT TRIP SW(-) W/ STEERING WHEEL HEATER W/O STEERING WHEEL HEATER WHT WIRE YEL WIRE

??? ??? B+ GND BATTERY AMBIENT TEMPERATURE SENSOR BATTERY C/FAN FUSE BATTERY PWR BATTERY PWR PNK ON/START INPUT WIRE BLK WIRE BLK/ORG WIRE BLOWER F/B BLU WIRE BLU/WHT WIRE BLWR F/B BMS ASSEMBLY BMS BLOWER MOTOR BMS BLOWER MOTOR RELAY BMS CONTROL MODULE BMS FUSE BRN WIRE C-CAN (H) C-CAN (L) RLY GND COMPUTER DATA LINES SYSTEM CONTROL E/R FUSE, RELAY BOX FAN SPD FAN SPED GRY WIRE H-CAN (H) H-CAN (L) PRE RLY HOT AT ALL TIMES I/P-A INVERTER LEFT "C" PILLAR) MAIN RELAY MAIN RLY ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWER RELAY ASSEMBLY PPL PRCHRG RLY PWR IN RED WIRE RED/WHT WIRE SIG SMART JUNCTION BOX TO HYBRID BATTERY MODULE 1 (DIAGRAM 3 OF 6) TO HYBRID BATTERY MODULE 9 (DIAGRAM 5 OF 6) TO HYBRID BATTERY SAFETY PLUG (DIAGRAM 4 OF 6) VIB GND VOUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/ORG WIRE

??? ??? B-CAN BLK WIRE BLK/GRN WIRE BLU WIRE BLU/BLK WIRE BLU/WHT WIRE BMS ASSEMBLY BMS CONTROL MODULE BRN WIRE BRN/BLK WIRE C-CAN CHARGE IND CLUSTER FUSE COMPUTER DATA LINES SYSTEM FROM BMS CONTROL MODULE (DIAGRAM 2 OF 6) FROM BMS CONTROL MODULE (DIAGRAM 3 OF 6) FROM HYBRID BATTERY MODULE 3 (DIAGRAM 3 OF 6) GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRY/ORG WIRE HOT IN ON OR START HYBRID BATTERY MODULE 4 HYBRID BATTERY MODULE 5 HYBRID BATTERY SAFETY PLUG HYBRID BATTERY THERMISTOR I/P-E INSTRUMENT CLUSTER LT GRN WIRE MCU NCA WIRE ORG/ WIRE PNK WIRE PNK/BLK WIRE POWER RED WIRE SENSOR SIG SMART JUNCTION BOX TEMP SIG (GND) TEMP SIG (SIG) TO HYBRID BATTERY MODULE 6 (DIAGRAM 5 OF 6) TRANSCEIVER/ WHT WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/ORG WIRE

B-CAN TRANSCEIVER BLK WIRE BLK/ORG WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BRN WIRE CAMSHAFT POSITION SENSOR 2 CHECK ENGINE IND CLUSTER FUSE COMPUTER DATA LINES SYSTEM CRANKSHAFT POSITION SENSOR FUEL PUMP MOTOR FUEL SENDER GRN WIRE GRY WIRE HOT IN ON OR START I/P-E INJECTORS (LEFT SIDE OF ENGINE) INSTRUMENT CLUSTER KNOCK SENSOR LEFT "C" PILLAR) MANIFOLD ABSOLUTE PRESSURE SENSOR MCU ORG/ WIRE PNK WIRE RED WIRE SMART JUNCTION BOX WHT WIRE WHT/ORG WIRE YEL WIRE YEL/ORG WIRE