Isuzu Axiom I (2001-2004) i-24 Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 C-38 1 9 A-1 2 10 A-1 4 H/L TRANSFER SWITCH ASSEMBLY 6 PNK WIRE 7 PNK WIRE 8 7 DATALINK CONNECTOR (LOWER LEFT SIDE OF DASH) 8 PNK WIRE A/T CIRCUIT ABS OUT AUTO IND TOD IND AUTOMATIC TRANSMISSION MODE SWITCH (LEFT SIDE OF TRANSMISSION) BLK WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/YEL WIRE BRAKE SW MTR POS 4 MTR POS 2 LAMPS ON ATM B IN AXLE ENGAGE BRAKE SWITCH (ON TOP OF BRAKE PEDAL SUPPORT) BRN WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE C-26 C-26 (LEFT SIDE OF ENGINE COMPT) C-26 (LEFT SIDE OF ENGINE COMPT) H-L SHIFT MOTOR ASSEMBLY CHECK TOD IND REAR IND AUTO IND CLUTCH SOL +V REF SENS GRND IGNITION TPS IN DATA E-34 ENCODER SWITCHES ENG SPEED GROUND GROUND TOD IN FRONT AXLE MOTOR ACTUATOR (LEFT SIDE OF AXLE) FRONT IND REAR IND FSS SIG ABS ACTIVE BATTERY MOTOR H-L FUSE 11 METER FUSE 14 BACK UP/ TURN FUSE 14 TOD FUSE 6 STOP LAMP FUSE/ RELAY BOX (RIGHT SIDE OF ENGINE COMPT) GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GROUND GROUND MOTOR L-H GRY WIRE GRY/BLU WIRE GRY/RED WIRE H-L SHIFT MOTOR HOT AT ALL TIMES HOT IN ON OR START I-24 ILLUM INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS LT BLU WIRE LT GRN/RED WIRE LT GRN/WHT WIRE METER ASSEMBLY ORG/BLK WIRE ORG/WHT WIRE P-15 (TOP OF TRANSFER CASE) PNK WIRE PNK/BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) FRONT IND RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RPM OUT RSS SIG SHIFT-ON- THE-FLY CONTROLLER (BEHIND RADIO) TOD TORQUE ON DEMAND (TOD) SWITCH TORQUE-ON- DEMAND (TOD) CONTROL UNIT (BELOW LEFT SIDE OF DASH) TPS OUT TRANSFER CLUTCH SOLENOID (IN THE TRANSFER CASE) VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/VIO WIRE YEL/WHT WIRE

ABS INDICATOR LIGHT ABS OUTPUT BLK WIRE BLU WIRE BRAIDED BRAKE FLUID LEVEL SWITCH (IN BRAKE FLUID RESERVOIR) BRAKE SWITCH (BEHIND DASH, ON BRAKE PEDAL SUPPORT) C-10/P-10 (RIGHT SIDE OF ENGINE COMPT) C-26 (LEFT SIDE OF ENGINE COMPT) C-5 C-6 1 2 BATTERY GROUND DASH FUSE BOX (ON LEFT OF DASH, BEHIND TRIM PANEL) ELECTRONIC HYDRAULIC CONTROL UNIT (EHCU) (ON RIGHT REAR CORNER OF ENGINE COMPT) FUSE C-11 METER FUSE C-6 STOP LIGHT FUSE EB-18 ABS FUSE/RELAY BOX (ON RIGHT SIDE OF ENGINE COMPARTMENT) GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START I-24 INSTRUMENT CLUSTER SYSTEM (BRAKE INDICATOR CIRCUIT) LEFT FRONT SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE METER ASSEMBLY ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE PNK 14 11 WIRE PNK WIRE REAR SPEED SENSOR (BENEATH REAR OF VEHICLE, ON TOP OF DIFFERENTIAL) RED WIRE RIGHT FRONT SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) T.O.D. CONTROL UNIT (BELOW LEFT SIDE OF DASH) VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/BLK WIRE

13 PNK/ 12 PNK/ I-22 WIRE 2 1 DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) A/T OIL TEMPERATURE SENSOR AUTOMATIC TRANSMISSION BLK WIRE BLK/BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRAIDED BRAKE SWITCH (ON TOP OF BRAKE PEDAL SUPPORT) BRN WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE C-26 (LEFT SIDE OF ENGINE COMPT) CIRCUIT DASH FUSE BOX (LEFT SIDE OF DASH) FUSE 6 STOPLAMP E-21 (LEFT SIDE OF ENGINE) THROTTLE VALVE ASSEMBLY (ON THROTTLE BODY ASSEMBLY) E-23 (RIGHT SIDE OF ENGINE) E-40 E-42 ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (RIGHT FRONT OF ENGINE) FUSE 11 METER FUSE 12 ENGINE FUSE 13 PCM B/U FUSE 14 BACK UP/ TURN LIGHT FUSE/ RELAY BOX (RIGHT SIDE OF ENGINE COMPT) FUSE/ RELAY BOX (RIGHT SIDE OF ENGINE COMPT) FUSE 15 PCM GRN WIRE GRN/RED WIRE GRN/WHT WIRE GROUND ECT IN IGNITION TRANS POS TRANS POS TRANS POS TRANS POS GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN ON OR START I-24 INTERIOR LIGHTS SYSTEM B-9 (UNDER CENTER CONSOLE) LT BLU WIRE METER ASSEMBLY CHECK TRANS IND A/T OIL TEMP IND MULTI-PLEXED INDICATOR CONTROL UNIT (UNDER REAR OF CENTER CONSOLE) ORG/ WIRE ORG/BLK WIRE PCM MAIN RELAY PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE PNK/YEL WIRE POWER DRIVE IND WINTER DRIVE IND POWER/ WINTER SWITCH (PART OF SWITCH UNIT) POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) PRESSURE CONTROL SOLENOID PSC- BRAKE/TCC PSC+ ETC GRD BATTERY DATA RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID THROTTLE POSITION SENSOR 1 BRAKE BAND APPLY SOLENOID THROTTLE POSITION SENSOR 2 TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION SPEED SENSOR (ON TOP OF TRANSMISSION) VIO WIRE VIO/GRN WIRE VIO/RED WIRE VIO/WHT WIRE WHT WIRE WHT/GRN WIRE WINTER POWER YEL WIRE YEL/BLK WIRE YEL/VIO WIRE

BATTERY BLK WIRE BLK/RED WIRE CHARGING SYSTEM WARNING LIGHT DASH FUSE BOX FUSE C-11 METER FUSE EB-16 MAIN FUSE EB-3 ACG-S FUSE/ RELAY BOX (RIGHT SIDE OF ENGINE COMPT) GENERATOR GRN/YEL WIRE HOT IN ON OR START I-24 JUNCTION CONNECTOR METER ASSEMBLY P-10/C-10 (RIGHT SIDE OF ENGINE COMPT) P-2 P-3 P-6 P-7 P-9 (RIGHT SIDE OF ENGINE COMPT) RED WIRE STARTING SYSTEM (STARTER SOLENOID) WHT WIRE WHT/BLU WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 C-44 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 C-45 ACTUATOR G-SENSOR BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/BLU WIRE BRN/WHT WIRE C-10/P-10 (RIGHT SIDE OF ENGINE COMPT) C-26 (LEFT SIDE OF ENGINE COMPT) DASH FUSE BOX (ON LEFT OF DASH, BEHIND TRIM PANEL) E-34 FUSE 11 METER FUSE 21 ACTIVE RIDE G-SENSOR (BELOW LEFT REAR OF VEHICLE) GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES OPTION FUSE BOX (RIGHT SIDE OF ENGINE COMPT) FUSE 6 STOP LAMP HOT IN ON OR START I-22 I-24 I-24 METER ASSEMBLY ILLUMINATION INTELLIGENT SUSPENSION CONTROL UNIT (BELOW CENTER OF DASH) INTELLIGENT SUSPENSION MODE SWITCH INTELLIGENT SUSPENSION WARNING SYSTEM LIGHT LEFT FRONT ACTUATOR ASSEMBLY (ON TOP OF LEFT FRONT SHOCK) LEFT REAR ACTUATOR ASSEMBLY (ON TOP OF LEFT REAR SHOCK) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED WIRE RED/WHT WIRE RIGHT FRONT ACTUATOR ASSEMBLY (ON TOP OF RIGHT FRONT SHOCK) RIGHT REAR ACTUATOR ASSEMBLY (ON TOP OF RIGHT REAR SHOCK) SPORT MODE INDICATOR LIGHT TRANSFER CASE) VEHICLE SPEED SENSOR VERTICAL G-SENSOR VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/RED WIRE

10 I-22 10.1 OHMS 3 I-22 ECT SENSOR (ON RIGHT FRONT OF ENGINE) 11 I-24 12 I-24 7 I-23 13 I-24 15 I-24 16 I-24 17 I-24 22 I-24 25 I-24 26 I-24 27 I-24 30 I-24 2 4 I-22 6 I-23 16 I-23 FUEL TANK UNIT (BENEATH REAR OF VEHICLE, IN TOP OF FUEL TANK) 7 PNK WIRE 8 PNK WIRE 9 I-23 A/T FLUID INDICATOR LIGHT ABS INDICATOR LIGHT AIR BAG READINESS INDICATOR LIGHT BLK WIRE BLK/RED WIRE BLU WIRE BLU/RED WIRE BLU/YEL WIRE BRAKE FLUID LEVEL SWITCH (IN RESERVOIR) BRAKE SYSTEM WARNING LIGHT C-26 (LEFT SIDE OF ENGINE COMPT) 28 I-24 CHARGING SYSTEM WARNING LIGHT CHECK TRANS INDICATOR LIGHT DIODE BOX B E-34 ELECTRONIC HYDRAULIC CONTROL UNIT (RIGHT REAR CORNER OF ENGINE COMPT) ELECTRONIC SUSPENSION SYSTEM ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FUEL GAUGE FUEL TANK SENDER FUSE/ RELAY BOX (ON RIGHT SIDE OF ENGINE COMPT) GAUGE ASSEMBLY GRN WIRE GRY WIRE I-24 INTELLIGENT SUSPENSION SYSTEM WARNING LIGHT LOW FUEL WARNING LIGHT LT BLU WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LIGHT OIL PRESSURE INDICATOR LIGHT ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PARKING BRAKE SWITCH PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED WIRE REDUCED POWER INDICATOR LIGHT SEAT BELT REMINDER LIGHT SPEEDOMETER/ ODOMETER/ TRIP METER SPORT MODE TACHOMETER TRANSMISSION SYSTEMS VIO WIRE WHT WIRE WHT/BLK WIRE WHT/GRN WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

A/C COMPRESSOR RELAY A/C THERMO- SWITCH RELAY ALARM, RELAY CONTROL UNIT ALTERNATOR ANTI- THEFT HORN AUTO A/C CONTROL UNIT BATTERY P-4 BLK WIRE BLK/RED WIRE BLOWER MOTOR BLU WIRE BLU/WHT WIRE BRAKE SWITCH BRN WIRE C-37 C-5 C.B. 21 POWER WINDOW CONDENSER FAN RELAY CYCLING SWITCH DASH FUSE BOX DASH FUSE BOX (ON LEFT OF DASH, BEHIND TRIM PANEL) DATA LINK CONNECTOR DOME LAMP DRIVER'S LUMBAR SEAT SWITCH DRIVER'S POWER SEAT SWITCH DUAL PRESSURE SWITCH E-34 ELECTRONIC BRAKE CONTROL MODULE FOG LAMP RELAY FUEL PUMP RELAY FUSE 1 FUSE 1 HAZARD FUSE 10 FOG LAMP FUSE 13 PCM BACKUP FUSE 14 TOD FUSE 15 PCM FUSE 16 MAIN FUSE 17 FUSE 18 ABS FUSE 19 FUSE 2 AUDIO FUSE 2 HORN FUSE 20 CON- DENSER FAN FUSE 21 SEMI ACTIVE SUS FUSE 3 ACG-S FUSE 4 TAIL FUSE 5 BLOWER FUSE 6 BLOWER FUSE 6 STOP LAMP FUSE 7 A/C FUSE 7 DOOR LOCK FUSE/RELAY BOX GENERATOR GPS RECEIVER UNIT GRN WIRE GRN/WHT WIRE GRN/YEL WIRE HAZARD WARNING SWITCH HEATER-A/C RELAY I-13 I-12 I-18 I-16 I-19 I-24 I-42 I-41 IN-CAR TEMPERATURE SENSOR INTELLIGENT SUSPENSION CONTROL UNIT INTAKE ACTUATOR MAX HI RELAY AUTO A/C CONTROL UNIT J/C KEY REMINDER SWITCH (IGNITION SWITCH) LEFT FRONT POWER WINDOW, DOOR LOCK SWITCH KEYLESS ENTRY, ANTI-THEFT CONTROL UNIT LEFT HEADLIGHT RELAY LEFT REAR DOOR COURTESY LIGHT RIGHT REAR DOOR COURTESY LIGHT LT GRN WIRE LT GRN/WHT WIRE MAP LAMP METER ASSEMBLY MID CONTROL UNIT MID DISPLAY AUDIO, SWITCH ASSEMBLY OPTION FUSE BOX (ON RIGHT SIDE OF ENGINE COMPT) ORG/ WIRE P-2 P-9 PCM MAIN RELAY PNK PNK PNK C-46 WIRE PNK WIRE POWER WINDOW RELAY POWERTRAIN CONTROL MODULE REAR DEFOGGER RELAY FUSE 5 ROOM LAMP COIL RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT POWER SEAT SWITCH RIGHT HEADLIGHT RELAY SOCKET STARTER RELAY STARTER SOLENOID TAILLIGHT RELAY TO ACCESSORY POWER RELAY (DIAGRAM 2 OF 3) TO STARTER SWITCH (DIAGRAM 2 OF 3) TOD CONTROL UNIT TRIPLE PRESSURE SWITCH WHT WIRE WHT/BLK WIRE WHT/RED WIRE YEL WIRE

1 1 GROUND LAMP CTRL 1 1 HIGH LOW 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 DLC OUTPUT AIR BAG READINESS INDICATOR LAMP BLK WIRE BLK/RED WIRE BRN WIRE C-11 METER FUSE C-22 SRS FUSE DASH FUSE BOX (ON LEFT OF DASH, BEHIND TRIM PANEL) DRIVER'S INFLATOR MODULE DRIVER'S SEAT BELT SWITCH (OPEN WITH SEAT BELT BUCKLED) GRN WIRE GRN/YEL WIRE GRY WIRE HIGH LOW HOT IN ON OR START I-24 IGNITION METER ASSEMBLY PASSENGER'S INFLATOR MODULE RED WIRE SEAT INPUT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER FRONT OF CENTER CONSOLE) SERIAL DATA SRS COIL ASSEMBLY STEERING WHEEL) WARNING SYSTEMS YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE

12 I-42 18 I-41 8 I-42 15 I-41 16 I-41 22 I-41 BATTERY ALARM, RELAY CONTROL UNIT (ON RIGHT SIDE OF DASH) ANTI-THEFT, DOOR LOCKS SYSTEM B-9 (UNDER CENTER CONSOLE) BEEPER BLK WIRE BLK/WHT WIRE DASH FUSE BOX (ON LEFT OF DASH BEHIND FUSE 11 METER DRIVER'S SEAT BELT SWITCH DRVRS BELT UNBLKD IN DRVRS DOOR OPEN INPUT ENGINE CONTROLS, ANTI-THEFT SYSTEMS FUSE 4 TAIL FUSE 7 DOOR LOCK FUSE/ RELAY BOX (RIGHT SIDE OF ENGINE COMPT) FUSE 2 HORN GAUGE ASSEMBLY GRN WIRE GRN/RED WIRE GRN/YEL WIRE GROUND HEAD HEADLIGHT SWITCH HOT AT ALL TIMES HOT IN ON OR START I-24 I-35 IGNITION SWITCH KEY REMINDER SWITCH KEY IN IGN INPUT LEFT FRONT DOOR SWITCH LIGHTS ON INPUT LT GRN/WHT WIRE OFF PARK PNK/BLU WIRE RED/BLK WIRE RED/BLU WIRE SEAT BELT REMINDER LIGHT SUPPLEMENTAL RESTRAINT SYSTEM TAIL LIGHT RELAY (ON DASH FUSE BOX) TRIM PANEL) WHT WIRE YEL WIRE

1 2 3 4 5 6 GND A/C SYSTEM ACCELERATION POSITION SENSOR ASSEMBLY ACCELERATION SENSORS (ON ACCELERATOR PEDAL BRACKET) BLK WIRE BLK/BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BLU/YEL WIRE BRAID BRAIDED WIRES BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CRUISE CONTROL CRUISE CONTROL E-23 CRUISE SW FUEL SENDER IAT SEN DEFOGGER SYSTEM E-21 E-21 (LEFT SIDE OF ENGINE) E-23 (RIGHT SIDE OF ENGINE) ECT OUT FUEL GAGE DLC FUEL SEN TCC SOL VAPOR PRESS PWR SW EGR CTRL LO VSS IN ELECTRONIC SUSPENSION SYSTEM ENG COOLANT TEMP GAUGE ENGINE OR POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) FUEL GAUGE FUEL TANK SENDER FUEL TANK UNIT (ON TOP OF FUEL TANK) GRN WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/GRN WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN I-22 I-23 I-24 LT GRN WIRE MALFUNCTION INDICATOR LIGHT (MIL) METER ASSEMBLY NAVIGATION SYSTEM ORG/ WIRE ORG/BLU WIRE ORG/GRN WIRE ORG/WHT WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/VIO WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT CRUISE CANCEL EVAP PURGE REF VOLT REF VOLT REF VOLT CRUISE LMP GND SHIFT HI MIL IND CTRL SPEED- OMETER STARTER SYSTEM TACH- OMETER TFT SEN EGR IN AP SENSOR 1 TH VAL MTR TFT SEN GND DEFOG REQ TRANS SPD GND TR 1-2, 3-4 DEFOG RLY ST RELAY CTRL TRANS SPD TRANSMISSION SPEED SENSOR (A/T) (TOP OF TRANSMISSION) VIO/GRN WIRE VIO/RED WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/RED WIRE WINTER SW CRUISE SW TR SIGN 2-3 IGN FEED TCC SOL YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE