GMC Vandura G2500 (1985-1995) fuse block Wiring diagrams

1 2 PPL 1-2 SHIFT SOLENIOD 2-3 SHIFT SOLENIOD 4.3L 5.7L AND 7.4L B/H CONN BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF SHIPPING PANEL) DK BLU WIRE DK GRN/WHT WIRE ECM BAT FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION FUEL PUMP AND SENDER (IN FUEL TANK) FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE) FUEL PUMP PRIME CONNECTOR (NO LOCATION AVAILABLE) FUEL PUMP RELAY (LOWER LEFT SIDE OF SHIPPING PANEL) FUSE BLOCK GRY WIRE HEATED OXYGEN SENSOR (IN EXHAUST MANIFOLD) HOT AT ALL TIMES LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SOLENOID TORQUE CONVERTER CLUTCH TRANS- MISSION TEMP SENSOR VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF I/P) WHT/BLK WIRE YEL/BLK WIRE

BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF SHIPPING PANEL) DIAGNOSIS TEST TP SIGNAL INJECTOR 1 CTRL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE ECM-CRNK FUSE ECT SIGNAL EGR CONTROL ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) ENGINE GROUND FUEL PUMP RELAY CTRL FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS TP/ECT GROUND MAP GROUND IC SIGNAL VSS SIGNAL VSS TP REFERENCE IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) INJ FUSE KNOCK SENSOR SIGNAL LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) MAP REFERENCE IGNITION FUSED BATTERY FEED ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL 3 4 PPL/WHT WIRE RED WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) THROTTLE POSITION SENSOR (TOP RIGHT SIDE OF ENGINE) WHT WIRE WHT/BLK WIRE YEL WIRE

ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE EGR SOLENOID (TOP RIGHT SIDE OF ENGINE) ENGINE GROUND FUEL PUMP AND SENDER (IN FUEL TANK) FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LOWER LEFT SIDE OF SHIPPING PANEL) FUSE BLOCK GRY WIRE HEATED OXYGEN SENSOR (IN EXHAUST MANIFOLD) HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP OF ENGINE NEAR DISTRIBUTOR) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (RIGHT SIDE OF ENGINE) LOCK OFF LT BLU WIRE LT GRN/YEL WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR NCA WIRE ORG/ WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL 3 4 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RUN WIRE TAN/BLK WIRE VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF I/P) WHT WIRE

1995 VFTC 23 24 PNK WIRE 4.3L AND 5.7 W/O HD 452 455 PPL 5.7 HD AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SIGNAL LO SIDE INJ A ECM I FUSE ECM-B FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID TRANS SHIFT 2/3 SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENGINE COOLANT TEMP SENS EVAP CONTROL EVAPORATIVE CANISTER PURGE SOLENOID (TOP RIGHT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY DRIVE PCM TRANS FORCE MTR LO FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IGNITION BYPASS KNOCK SENSOR IN LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 1 2 3 4 PPL 21 22 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 23 24 PNK WIRE 3 121 PNK WIRE 4.3L ONLY ACCY AUXILIARY FUSE BLOCK BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON INTAKE MANIFOLD) FUSE BLOCK GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL PPL 1 2 3 4 PPL 21 22 PPL 3 4 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE TACHOMETER TEST LEAD TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 23 24 PNK WIRE 4.3L AND 5.7 W/O HD 452 455 PPL 5.7 HD AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SIGNAL LO SIDE INJ A ECM I FUSE ECM-B FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID TRANS SHIFT 2/3 SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENGINE COOLANT TEMP SENS EVAP CONTROL EVAPORATIVE CANISTER PURGE SOLENOID (TOP RIGHT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY DRIVE PCM TRANS FORCE MTR LO FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IGNITION BYPASS KNOCK SENSOR IN LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 1 2 3 4 PPL 21 22 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 23 24 PNK WIRE 3 121 PNK WIRE 4.3L ONLY ACCY AUXILIARY FUSE BLOCK BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON INTAKE MANIFOLD) FUSE BLOCK GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL PPL 1 2 3 4 PPL 21 22 PPL 3 4 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE TACHOMETER TEST LEAD TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 4.3L AND 5.7L 4.3L AND 5.7L ONLY 5.7L HD ONLY 452 455 PPL 5.7L HD 7.4L 7.4L ONLY AIR CONDITION- ING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SIGNAL DIAGNOSTIC TEST TP SENSOR SIGNAL INJECTOR 1 CONTROL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECM I FUSE ECM B FUSE ECT SIGNAL EGR CONTROL GOVERNOR CONTROL EGR ELECTONIC VACUUM REGULATOR SOLENIOD VALVE (TOP RIGHT SIDE OF ENGINE) EVAPORATIVE CANISTER PURGE CONTROL SOLENOID (TOP RIGHT FRONT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCS LOW FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS SENSOR GROUND SENSOR GROUND TFT SIGNAL IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IDLE SPEED ACTUATOR CONTROL SOLENOID (NO LOCATION AVAILABLE) KNOCK SIGNAL EGR PINTLE POSITION SIGNAL LINEAR EGR VACUUM REGULATOR SOLENOID VALVE (ABOVE RIGHT ROCKER COVER) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) OXYGEN SENSOR GROUND PNK 23 24 PPL WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 21 22 PPL/WHT WIRE RANGE SIGNAL A INPUT SPEED SIGNAL HIGH INPUT SPEED SIGNAL LOW RANGE SIGNAL B RANGE SIGNAL C MIL CONTROL RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE TRANSMISSION INPUT SPEED SENSOR (NO LOCATION) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 3 121 PNK WIRE ACCY AUXILIARY FUSE BLOCK BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON INTAKE MANIFOLD) FUSE BLOCK GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/BLK WIRE PNK PPL 23 24 WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL PPL 21 22 PPL 3 4 PPL/WHT WIRE RED WIRE RED/BLK WIRE RUN WIRE TACHOMETER TEST LEAD TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.3L 5.7L 5.7L ONLY 4.3L ONLY 7.4L 7.4L ONLY AIR CONDITION- ING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SIGNAL DIAGNOSTIC TEST TP SENSOR SIGNAL INJECTOR 1 CONTROL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECM CRNK FUSE ECM BAT FUSE EGR CONTROL EGR ELECTONIC VACUUM REGULATOR SOLENIOD VALVE (TOP RIGHT FRONT OF ENGINE) EVAPORATIVE CANISTER PURGE CONTROL SOLENOID (TOP RIGHT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCS LOW FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS SENSOR GROUND SENSOR GROUND TFT SIGNAL IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) INJ FUSE KNOCK SENSOR INPUT ECT SIGNAL KNOCK SIGNAL EGR PINTLE POSITION SIGNAL LINEAR EGR VACUUM REGULATOR SOLENOID VALVE (TOP FRONT OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE OXYGEN SENSOR GROUND PNK 26 27 WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL 24 25 PPL/WHT WIRE RANGE SIGNAL A INPUT SPEED SIGNAL HIGH INPUT SPEED SIGNAL LOW RANGE SIGNAL B RANGE SIGNAL C MIL CONTROL RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANSMISSION INPUT SPEED SENSOR (NO LOCATION) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE