GMC Sierra 3500 HD (2007-2012) hot at all times Wiring diagrams

AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR SIGNAL AUX HVAC- IGN FUSE 45 BATT + GND BRAKE PEDAL SIG BLK/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DK BLU WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUSE 19 GROUND DISTRIBUTION SYSTEM HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED IGN INSTRUMENT CLUSTER PANEL (IPC) LEFT I/P JUNCTION BLOCK LOGIC LOW REFERENCE LT BLU/WHT WIRE LT GRN/BLK WIRE MISC-IGN FUSE 43 ORG/BLK WIRE PC SOLENOID 1 CONTROL PC SOLENOID 2 CONTROL PC SOLENOID 3 CONTROL PC SOLENOID 4 CONTROL PC SOLENOID 5 CONTROL PNK IGN WIRE PNK PNK ANTI-LOCK BRAKES SYSTEM WIRE PNK PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE PRESSURE CONTROL (PC) SOLENOID VALVE 1 PRESSURE CONTROL (PC) SOLENOID VALVE 2 PRESSURE CONTROL (PC) SOLENOID VALVE 3 PRESSURE CONTROL (PC) SOLENOID VALVE 4 PRESSURE CONTROL (PC) SOLENOID VALVE 5 RED/WHT WIRE REPLICATED TOS SIGNAL SHIFT SOLENOID (SS) 1 CONTROL SHIFT SOLENOID (SS) 2 CONTROL SHIFT SOLENOID (SS) VALVE 1 SHIFT SOLENOID (SS) VALVE 2 STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TCM- BATT FUSE 14 TO AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) (DIAGRAM 2 OF 2) TORQUE CONVERTER CLUTCH (TCC) PRESSURE CONTROL (PC) SOLENOID VALVE TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL TOS SIG TOW/ HAUL IND TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON TRANSFER CASE TAILSHAFT HOUSING) VSS HIGH SIG VSS LOW SIG

13 26 12 40 13 34 12 59 58 17 27 28 8 65 25 13 5 49 44 43 LOW REF 22 21 4 58 LOW REF ECT SENS SIG 4.3L 6.0L 4.8L, 5.3L, 6.2L BLK WIRE COMPUTER DATA LINES SYSTEM COOLING FAN DIODE 1 COOLING FAN DIODE 2 DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN-1 FUSE 60 FAN-2 FUSE 62 GRY WIRE HOT AT ALL TIMES LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE ORG/BLK WIRE PWR/ TRN RELAY RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) SENS SIG PWRTRN RLY CTRL FAN RLY CTRL FAN RLY CTRL DATA BUS (-) DATA BUS (+) TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

2-HI IND 4-HI IND 4-LO IND 5 VOLT REF INCRMT ENCODER SIG 6.0L (VIN G) 7475 7476 1693 1566 1565 PPL ACCY WAKEUP SRL DATA ASSEMBLY AUX HVAC-IGN FUSE 48 FUSE 45 AXLE ACTR CTRL AXLE SW SIG GMLAN BUS - GMLAN BUS + IGN 1 VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DIRTN SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE FRONT AXLE ACTUATOR FUSE 19 FUSE 13 GAS GAS DIESEL GMLAN BUS - GMLAN BUS + INCRMT ENCODER SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED HOT W/ RUN/CRNK RELAY ENERGIZED UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) IGN INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LO REF SW SIG 4 HI IND CTRL 4 LO IND CTRL LOGIC LOW REF LT BLU WIRE LT GRN/BLK WIRE LT GRN/DK BLU WIRE MISC IGN FUSE 43 FUSE 40 MTR CTRL B MTR CTRL A BATT + GND NEUTRAL IND NEUTRAL IND CTRL 2 HI IND CTRL ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PULSE SIG RED/BLK WIRE RIGHT I/P JUNCTION BLOCK SER DATA SHIFT MOTOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSFER CASE ENCODER MOTOR (ON TRANSFER CASE) TRANSFER CASE SHIFT CONTROL MODULE (LOWER LEFT SIDE OF DASH) TRANSFER CASE SHIFT CONTROL SWITCH (ON TOP LEFT OF TRANSFER CASE) TREC FUSE 67 FUSE 62 WHT WIRE WHT/GRN WIRE WIPER/WASHER SYSTEM YEL WIRE

2501 2500 976 COMPUTER DATA LINES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CUT) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUSE 49 GRY WIRE GRY/BLK WIRE HI SPD GMLAN SERIAL DATA HI SPD SERIAL DATA - HI SPD SERIAL DATA + LOW REF HI SPD SERIAL DATA - HI SPD SERIAL DATA + LOW REFERENCE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE MISC IGN FUSE 40 MODE SELECT A PTO REMOTE SW SET SIG PTO RELAY COIL CTRL PTO SW INDICATOR CTRL PNK WIRE POWER TAKE OFF (PTO) PROVISION (BLUNT POWER TAKE OFF (PTO) RELAY POWER TAKE OFF (PTO) SWITCH POWER TAKE OFF MODULE (PTO) (OUTSIDE OF RIGHT FRONT CHASSIS FRAME) PPL PPL/WHT WIRE PTO FUSE 44 RED/ WHT WIRE RED/WHT WIRE REMOTE MODE ENABLE SIG PTO ENGAGE SIG PTO RLY ENGAGE SIG RES+ SERIAL DATA ENABLE SET OFF SHUTDOWN SIGNAL TAN WIRE TAN/BLK WIRE TCC BRAKE SIGNAL UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT RED/ WIRE WHT WIRE YEL WIRE

2500 2501 COMPUTER DATA LINES SYSTEM 66 46 SERIAL DATA + SERIAL DATA - BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ECT SENS SIG ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) ENGINE COOLANT LEVEL SWITCH (ON BOTTOM OF SURGE TANK) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT CENTER OF ENGINE) ENGINE COOLING FAN (FRONT CENTER OF ENGINE COMPT) FAN FUSE 68 FAN RLY RELAY GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC B+ GND LOW REF LT GRN WIRE MANUAL A/C AUTOMATIC A/C RLY SPD SIG SERIAL DATA SPD SIG SW SIG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

2 OR MORE OF W/ ONSTAR, AUDIO AMPLIFIER (IF EQUIPPED) (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DATA LINK CONNECTOR (DLC) (LOWER LEFT SIDE OF DASH) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT END OF DASH) DIGITAL RADIO, REAR SEAT, DK GRN WIRE DRIVER DOOR LOCK/WINDOW SWITCH DRIVER'S SEAT EARPHONE JACKS RADIO CONTROL GROUND DISTRIBUTION SYSTEM HEATED SEAT CONTROL MODULE (W/ SPO HEATED SEATS) HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW SPD GMLAN SER DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED SERIAL DATA LTR FUSE 53 (EXCEPT 6.6L) FUSE 50 (6.6L) MEMORY SEAT MODULE (W/ INDIVIDUAL FRONT SEAT) (UNDER FRONT OF NOT USED NOT USED PASSENGER DOOR LOCK/WINDOW SWITCH POWER DISTRIBUTION SYSTEM RADIO REAR OBJECT SENSOR CONTROL MODULE (AT REAR CARGO AREA, BEHIND TRIM PANEL) REAR SEAT AUDIO (RSA) CONTROL REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) TAN WIRE TAN/BLK WIRE THEFT DETERRENT CONTROL MODULE (TDM) (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) W/ DIGITAL RADIO W/ DIGITAL RADIO, REAR SEAT, ONSTAR, EARPHONE JACKS RADIO CONTROL W/ FRONT SEAT, REMOTE CONTROL W/ INDIVIDUAL FRONT SEAT W/ LUXURY EDITION W/ ONSTAR W/ RADIO PROVISIONS W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL W/ REMOTE KEYLESS ENTRY W/O INDIVIDUAL FRONT SEAT W/O LUXURY EDITION W/O LUXURY EDITION, W/ ODOMETER SECURITY PROVISIONS W/O RADIO PROVISIONS WHT WIRE

1 2 3 4 9 10 BATTERY (+) BATTERY (+) BATTERY (+) BATTERY (+) GROUND BATTERY (+) BCM FUSE 15 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CREW CAB CTSY FUSE 5 DIM FUSE 7 DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (REAR OF DRIVER'S DOOR) GRN WIRE GRY WIRE GRY/BLK WIRE HEAD HEAD OFF AUTO PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HYBRID EXCEPT HYBRID I/P FUSE BLOCK (LEFT SIDE I/P FUSE BLOCK (LEFT SIDE OF DASH, IGN IS LPS FUSE 17 LEFT REAR DOOR LATCH ASSEMBLY (REAR OF LEFT REAR DOOR) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT STOP TRN FUSE 6 OF DASH) OFF AUTO PARK PARK BRAKE SW SIGNAL PASSENGER DOOR LATCH ASSEMBLY (REAR OF PASSENGER'S DOOR) PNK/BLK WIRE POWER DISTRIBUTION RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT REAR DOOR LATCH ASSEMBLY (REAR OF RIGHT REAR DOOR) RT STOP TRN FUSE 8 STOP LAMPS FUSE 12 SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ ELECTRONIC DOOR LOCK CONTROL W/O ELECTRONIC DOOR LOCK CONTROL W/ POWER WINDOWS WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ B+ LOW REF LO SPD DATA BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL ASSEMBLY) CHIME MODULE (CENTER OF DASH, BEHIND RADIO) CONNECTOR BREAKOUT) (W/ LUXURY EDITION) DK BLU WIRE DK GRN WIRE DLIS FUSE 35 FUSE 32 DRIVER INFORMATION CENTER (DIC) DISPLAY DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SWITCH GASOLINE DIESEL HOT AT ALL TIMES IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER DRIVER'S SEAT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 FUSE 43 KEY-IN IGNITION SWITCH LEFT I/P JUNCTION BLOCK (LOWER LEFT LEFT SEAT BELT SW LO SPD GMLAN SERIAL DATA LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LOW TIRE PRESSURE IND LT (W/ FRONT BENCH SEAT) LT BLU WIRE NCA WIRE OFF PARK BRAKE SWITCH (ON PARK PNK SUPPLEMENTAL RESTRAINTS SYSTEM WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RDO FUSE 42 FUSE 39 RED/WHT WIRE RUN WIRE SEAT BRAKE BELT IND IND SERIAL DATA SIDE OF DASH) SOUND SYSTEMS TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ RADIO PROVISIONS W/O LUXURY EDITION W/O RADIO PROVISIONS WHT WIRE

1 2 3 4 9 10 BATTERY (+) BATTERY (+) BATTERY (+) BATTERY (+) GROUND BATTERY (+) 14 15 RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW 5 4 13 9 LOW REF LF OPEN SIG LF AJAR SIG LO SPD DATA 9 5 13 LO SPD DATA LOW REF RF AJAR SIG BCM FUSE 15 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CREW CAB CTSY FUSE 5 DIM FUSE 7 DK GRN WIRE DOOR DRIVER DOOR LATCH ASSEMBLY (REAR OF DRIVER'S DRIVER DOOR LOCK/ WINDOW SWITCH GRY/BLK WIRE HEAD HEAD OFF AUTO PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE IGN IS LPS FUSE 17 LEFT REAR DOOR LATCH ASSEMBLY (REAR OF LEFT REAR DOOR) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT STOP TRN FUSE 6 OF DASH) OFF AUTO PARK PARK BRAKE SW SIGNAL PASSENGER DOOR LATCH ASSEMBLY (REAR OF PASSENGER'S PASSENGER DOOR LOCK/ WINDOW SWITCH PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT REAR DOOR LATCH ASSEMBLY (REAR OF RIGHT REAR DOOR) RT STOP TRN FUSE 8 STOP LAMPS FUSE 12 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ 1 8 13 B+ LOW REF LO SPD DATA BLK WIRE BLK/WHT WIRE BLU WIRE CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DK BLU WIRE DK GRN WIRE DLIS FUSE 35 FUSE 32 DRIVER INFORMATION CENTER (DIC) DISPLAY DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SWITCH GASOLINE DIESEL HOT AT ALL TIMES IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER DRIVER'S SEAT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 FUSE 43 KEY-IN IGNITION SWITCH LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT SEAT BELT SW LO SPD GMLAN SERIAL DATA LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LOW TIRE PRESSURE IND LT BLU WIRE NCA WIRE OFF PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RDO FUSE 42 FUSE 39 RED/WHT WIRE RUN WIRE SEAT BRAKE BELT IND IND SERIAL DATA SOUND SYSTEMS SPLICE PACK SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ RADIO PROVISIONS W/O LUXURY EDITION W/O RADIO PROVISIONS WHT WIRE