GMC Sierra 2500 (2000-2004) hot in run Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 2 SIG LOW REF LOW REF APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SERIAL DATA CLASS 2 DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (LEFT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 2 SIG LOW REF LOW REF APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SERIAL DATA CLASS 2 DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (LEFT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL ON/OFF SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF APP SENSOR 3 SIG LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SERIAL DATA SET/COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MOTOR (ON THROTTLE BODY) THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T A/T M/T BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE FUSE BRN WIRE BRN/WHT WIRE CLUTCH CRUISE CONTROL MODULE (LEFT REAR OF ENGINE COMPT, ON FIREWALL) CRUISE CONTROL ON/OFF SWITCH CRUISE ENGAGE IN CRUISE ENGAGE OUT SPEED SENSOR INPUT CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER SYSTEM LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE M/T M/T A/T NCA WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SET/COAST SOUND SYSTEMS SPEED SENSOR OUT STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) SWITCH (TOP OF CLUTCH PEDAL) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE

ABS FUSE ABS IND PNK WIRE BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IND BRAKE INPUT SERIAL DATA BRN WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DIESEL DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) ENGINE CONTROLS SYSTEM FRONT AXLE ACT/SW INPUT VSS INPUT LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) FRONT AXLE ACTUATOR/ SWITCH (ON AXLE HOUSING) GAS GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/ PPL/ PPL/ PPL/ PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSFER CASE SHIFT CONTROL MODULE (LEFT SIDE OF DASH, BEHIND HEADLAMP SWITCH) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND. BLK WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE DEL TORQUE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GAS DIESEL GROUND DISTRIBUTION SYSTEM GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LOW TRACTION INDICATOR ILLUM LAMP LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) ORG/BLK WIRE PNK PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL 1122 832 PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SERVICE TRAC CNTL SIG SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH TRACTION OFF INDICATOR UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUT WHT WIRE YEL WIRE YEL/BLK WIRE

59 33 (DIESEL) (GAS) ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IND BRN WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SEO SEO IGN FUSE STOP- LAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC BRAKE SW TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRASFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

BASE BATTERY SERIAL DATA GROUND BLK WIRE BLK/WHT WIRE BLU WIRE BODY RELAY BLOCK BODY RELAY BLOCK (LEFT SIDE OF DASH, NEAR KICK PANEL) BRN WIRE CRUISE FUSE DK BLU WIRE DK GRN WIRE DOOR JAMB SW IN DRIVER MINI WEDGE SWITCH DRIVER POWER WINDOW/ DOOR LOCK SWITCH EXTERIOR LIGHTS FUSE BLOCK GRY WIRE HDLMP RLY CNTRL PARK LIGHTS IN KEY IN IGN HEADLAMP SWITCH HOT AT ALL TIMES UNDERHOOD FUSE BLOCK TBC FUSE HOT IN RUN HOT IN RUN OR START HOT WITH PARK LIGHTS ON IGN 1 FUSE IGNITION KEY ALARM SWITCH INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) INT PRK FUSE LEFT I/P FUSE BLOCK LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PARK BRAKE SWITCH PNK IGNITION 1 IGNITION 3 SEAT BELT INPUT PARK BRAKE SW WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPARTMENT) RIGHT TURN INPUT LEFT TURN INPUT GROUND SEAT BELT IND SEAT BELT SWITCH (ON DRIVER'S SEAT BELT BUCKLE) TAN WIRE TURN SIGNAL/ MULITFUNCTION SWITCH UNDERHOOD FUSE BLOCK WHT WIRE

1-2 SOL 11 12 PNK WIRE 13 14 15 PNK WIRE 2 3 4 5 6 7 8 PNK WIRE 2-3 SOL 3-2 SOL 32 33 34 PNK WIRE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE BLK WIRE BLK/WHT WIRE BLU WIRE BODY RELAY BLOCK BRAKE FUSE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID (BEHIND THROTTLE BODY) EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (RIGHT FRONT SIDE OF FUEL TANK) GASOLINE EVAP FUEL TANK PRESSURE SENSOR GRY WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER SYSTEM LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REV STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN (OR BLK) WIRE TAN/WHT WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDER- HOOD FUSE BLOCK VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION/ TRANSFER CASE) WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SOL 2-3 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE BLK WIRE BLU WIRE BODY RELAY BLOCK BRAKE FUSE BRN WIRE BRN/RED WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANISTER PURGE SOLENOID (TOP RIGHT REAR OF ENGINE) EVAP CANISTER VENT SOLENOID (RIGHT FRONT SIDE OF FUEL TANK) EXHAUST GAS RECIRCULATION VALVE (TOP RIGHT FRONT OF ENGINE) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GRY DK GRN WIRE GRY WIRE HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE REV STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN WIRE TCC PWM SOL TFT SENSOR UNDER- HOOD FUSE BLOCK VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE