Wiring diagram engine performance 6.0l bi-fuel for GMC Sierra 2500 HD (2002-2012)

3-2 SS CTRL REF LOW A/C SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START I/P FUSE BLOCK IGN 0 FUSE INJ 1 CTRL INJ 6 CTRL AFO ENABLE RLY CTRL GND KS SIGNAL KS SIGNAL CKP SIG LPL CTRL INJ 7 CTRL INJ 4 CTRL LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MOD STATUS B+ CLS 2 DATA OIL LEV SW SIG SELECT SIG PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK 1 2 3 4 5 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND A SIG BRK SW SIG PRND P SIG PPL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND SERIAL DATA (-) SERIAL DATA (+) STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

5 6 PNK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCM B FUSE FUSE PNK 1 2 3 4 5 WIRE PNK 1 2 3 4 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE

5 6 PNK WIRE AF DIODE 1 AF DIODE 2 AF FUEL RAIL PRESSURE SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE FUEL GAUGE SELECT SWITCH FUEL RAIL TEMPERATURE (FRT) SENSOR FUEL TANK PRESSURE (FTP) SENSOR FUEL TANK TEMPERATURE (FTT) SENSOR GASOLINE FUEL INJECTOR GRY WIRE HIGH PRESSURE LOCK-OFF SOLENOID LOW PRESSURE LOCK-OFF SOLENOID LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 3 4 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

AF INJECTOR BATTERY BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/ WHT WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENABLE EVEN FUEL INJECTOR CONTROL MODULE (FICM) (BELOW AIR FILTER ASSEMBLY) FUSIBLE LINK GRY WIRE HOT IN RUN OR START PCM 1/AFS FUSE IGN INJ 1 INJ 2 INJ 3 INJ 4 INJ 5 INJ 6 INJ 7 INJ 8 INLINE AF FUSE LT BLU/BLK WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE OUT PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL PNK PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REF SIG STATUS TAN WIRE UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 PNK WIRE AF FUEL MODE RELAY AF INJECTOR POWER RELAY (EVEN BANK) AF INJECTOR POWER RELAY (ODD BANK) AF INJECTOR RELAY 1 AF INJECTOR RELAY 2 AF INJECTOR RELAY 3 AF INJECTOR RELAY 4 AF INJECTOR RELAY 5 AF INJECTOR RELAY 6 AF INJECTOR RELAY 7 AF INJECTOR RELAY 8 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/ WHT WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE GRY WIRE LEFT UNDERHOOD AF RELAY BLOCK LT BLU/ BLK WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT UNDERHOOD AF RELAY BLOCK WHT WIRE YEL/BLK WIRE

1 2 PNK WIRE 1-2 SOL 2-3 SOL 3-2 SOL 33 34 35 PNK WIRE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID (BEHIND THROTTLE BODY) EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (RIGHT FRONT SIDE OF FUEL TANK) GASOLINE EVAP FUEL TANK PRESSURE SENSOR GRY WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REV STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN (OR BLK) WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK VEHICLE SPEED SENSOR (REAR OF TRANSMISSION/ TRANSFER CASE) WHT WIRE YEL WIRE YEL/BLK WIRE

33 34 35 PNK WIRE 9 10 11 12 13 14 15 16 17 18 19 PNK WIRE ACT CNTRL APP SENS 1 APP SENS 2 AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE REQ DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT/ECM FUSE FUSE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN, START I/P FUSE BLOCK IGN LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE R/A INPUT RED WIRE RED/BLK WIRE RED/WHT WIRE REF LOW S/C INPUT SIGNAL STP LP IN TAC CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE ACTUATOR CONTROL MODULE (REAR OF ENGINE COMPT) TP SENS 1 TP SENS 2 UNDERHOOD FUSE BLOCK VEH STOP FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

33 34 35 PNK WIRE A/C SYSTEM A/C SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE CTRL CYCLE SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS OUT VSS OUT TFT SENS SIG EXC SEO FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN START IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND IGNITION COILS INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE OUT RPM PC SOL HI CTRL PC SOL LO CTRL PMP RLY CTRL RPM OUT PNK 10 11 12 13 14 15 16 17 18 19 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV SIG PPL PNK PNK WIRE PPL/WHT WIRE PRESS SENS SIG IND CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW SEO SPARK PLUG SPARK PLUG SPARK PLUG STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CLU RLY CTRL TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE