GMC Sierra 2500 HD (2002-2012) Manual a/c circuit

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

193 735 1050 DEFOGGER SYSTEM A/C CMPRSR FUSE 17 (EXCEPT 6.6L) FUSE 16 (6.6L) A/C CMPRSR RELAY A/C IND A/C ON AMBIENT AIR TEMPERATURE SENSOR BATT POS VOLT BLK WIRE BLK/WHT WIRE COLNT LVL COMPUTER DATA LINES SYSTEM DFRST VAL FRH AIR BLWR SPD FRESH AIR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE COOLANT LEVEL SWITCH (6.6L) (ON BOTTOM OF SURGE TANK) EVAPORATOR TEMPERATURE SENSOR (ON HVAC ASSEMBLY) FROM PWR/TRN RELAY (DIAGRAM 3 OF 3) GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC BATT FUSE 39 (EXCEPT 6.6L) FUSE 36 (6.6L) HVAC BLWR FUSE 70 (EXCEPT 6.6L) FUSE 65 (6.6L) HVAC IGN FUSE 55 (EXCEPT 6.6L) FUSE 52 (6.6L) INTERIOR LIGHTS SYSTEM POWER DISTRIBUTION SYSTEM 6817 300 1851 3340 5060 LED CNTL IGN 3 GROUND B(+) GMLAN L LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LO REF RECIRC LOW REF LT GRN WIRE LT GRN/BLK WIRE MODE LOGIC SWITCH HVAC CONTROL MODULE MTR SPD CTRL ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE R AIR TMP SENS SIG MODE CTRL BLOWER MOTOR CONTROL SWITCH REAR DEFOG TEMP SENS GROUND REAR DFG RECIR RECIR CTRL R AIR TMP LOW REF LOW REF RED WIRE RED/BLK WIRE RED/WHT WIRE RER DEF 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RUN/ CRNK RELAY TAN WIRE TEMPERATURE CONTROL SWITCH UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

AMBIENT LIGHT SENS LO REF AMBIENT LIGHT SENS SIG AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE LEFT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) RECIRCULATION ACTUATOR (TOP CENTER OF HVAC MODULE) RIGHT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BRN WIRE COOLING FAN DIODE 1 COOLING FAN DIODE 2 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EXCEPT 6.0L FAN CNTRL RELAY FAN LO RELAY FAN-1 FUSE 60 FAN-2 FUSE 62 GRY WIRE GRY/BLK WIRE HI FAN RELAY HOT AT ALL TIMES LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE PNK WIRE PPL/WHT WIRE PWR/ TRN RELAY RED WIRE RED/BLK WIRE RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RLY CTRL TAN WIRE UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4 58 22 21 30 46 LOW REF ECT SENS SIG 6.0L 6.6L 4.8L, 5.3L,, 6.2L 4.3L AIR TEMPERATURE ACTUATOR (TOP MIDDLE OF HVAC MODULE) BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) ENGINE COOLING FAN (6.6L) (FRONT CENTER OF ENGINE COMPT) EXCEPT 6.0L EXCEPT 6.6L 6.6L FAN FUSE 68 FAN RELAY GRY WIRE HEAD HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC B+ GND LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT END OF HVAC MODULE) LOGIC NEAR FAN SHROUD) ORG/BLK WIRE RECIRCULATION ACTUATOR (FRONT A/C) (TOP RIGHT SIDE OF HVAC MODULE) SENS SIG FAN RLY CTRL PWRTRN RLY CTRL FAN RLY CTRL RLY SPD SIG LOW REF SPD SIG SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE