GMC Sierra 2500 HD (2002-2012) fuel pump relay Wiring diagrams

A/C CMPRSR RELAY AIR BAG BATT FUSE 46 AMP FUSE 42 AUDIO AMPLIFIER BODY CONTROL MODULE (BCM) CHIME MODULE COOLING FAN (LEFT) COOLING FAN (RIGHT) DIGITAL RADIO RECEIVER DK GRN WIRE ECM BATT ELEC RUN BOARD ENGINE CONTROL MODULE (ECM) ESC/ALH EXH EXCEPT LUXURY NO RADIO EXP/ PTO FAN 1 FUSE FAN LO RELAY FAN WIPER HI CONTROL RELAY PCB RELAY FAN-2 FRT WPR FUSE FUSE 37 FROM LGM FUSE (DIAGRAM 1 OF 5) FRT WASH PCB RELAY FSCM FUSE 22 FUEL PUMP RELAY FUEL SYSTEM CONTROL MODULE (FSCM) FUSE 13 FUSE 15 FUSE 23 FUSE 3 FUSE 40 FUSE 49 FUSE 67 FUSE BLOCK (UNDERHOOD) (RIGHT SIDE OF FIREWALL) GPS, REAR ENTER- TAINMENT EXCEPT LUXURY GRY WIRE HDLP WASH HEAVY DUTY ABS WSW/HTR FUSE 61 FUSE 68 HORN PCB RELAY HVAC BATT HVAC BLWR FUSE 72 HVAC CONTROL MODULE INFOTMNT FUSE 47 INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 48 ITBC ABS-1 ABS 2 FUSE 7 FUSE 63 FUSE 10 J/B (LEFT I/P) J/B (LEFT I/P) (LOWER LEFT SIDE OF DASH) LT BLU WIRE LUXURY NCA WIRE POWER TAKE-OFF (BLUNT CUT) POWER TAKE-OFF (PTO) RELAY PPL PREMIUM AUDIO EXCEPT LUXURY PREMIUM AUDIO W/LUXURY RADIO REAR SEAT AUDIO (RSA) CONTROLLER RDO FUSE 43 REAR DEFOG RELAY REAR ENTER- TAINMENT EXCEPT LUXURY REAR ENTER- TAINMENT W/LUXURY REAR ENTER- TAINMENT W/LUXURY GPS EXCEPT LUXURY GPS W/ LUXURY RED WIRE RED/BLK WIRE RED/WHT WIRE STRTR RELAY TCM BATT TRAILER BRAKE CONTROLLER MODULE (TBCM) ELECTRONIC BRAKE CONTROL MODULE (EBCM) TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE TREC FUSE 69 VIDEO COMMUNICATION INTERFACE MODULE (VCIM) VIDEO DISPLAY WHT WIRE WINDSHIELD WASHER SOLVENT HEATER J/B (RIGHT I/P) WINDSHIELD WIPER MOTOR WIPER SPEED PCB RELAY

A/C FUSE A/C RELAY ABS FUSE ACCESSORY POWER OUTLET AIR FUSE AUDIO AMPLIFIER AUTOMATIC TRANSMISSION CONTROL MODULE (ALLISON) BATTERY CABLE JUNCTION BLOCK BLK WIRE BODY CONTROL MODULE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) CIGAR LIGHTER CTSY LP FUSE DATA LINK CONNECTOR (DLC) DIESEL ONLY DK GRN WIRE DK USED DRL FUSE EARLY SIERRA PRO ECM-B FUSE ELECTRONIC BRAKE CONTROL MODULE (EBCM) ENGINE CONTROL MODULE (ECM) POWERTRAIN CONTROL MODULE (PCM) EXTERIOR ILLUM LAMPS RELAY FOG LPS FUSE FOGLAMP RELAY FROM AIR FUSE (DIAGRAM 1 OF 4) FROM FUSE BLOCK (DIAGRAM 4 OF 4) FROM RAP FUSE (DIAGRAM 1 OF 4) PARK LAMPS FUSE FRONT BLOWER MOTOR RESISTOR ASSEMBLY FRONT PASSENGER WINDOW/DOOR LOCK SWITCH FRT HVAC FUSE FUEL PUMP RELAY FUSIBLE LINK GRN WIRE HAZARD FUSE HEADLAMP DAYTIME RELAY RUNNING LAMP (DRL) RELAY HEADLAMP DIMMER SWITCH HEADLAMP ROOF SWITCH BEACON RELAY HEADLAMP SWITCH HORN RELAY HVAC CONTROL MODULE INADVERTENT POWER RELAY INSTRUMENT DRIVER PANEL INFOR- CLUSTER MATION (IPC) CENTER (DIC) INTERIOR LIGHT SUSTEM LATE LEFT BATTERY LEFT GENERATOR LEFT I/P FUSE BLOCK LUXURY NCA WIRE ORG/ WIRE PARKLAMP RELAY PASSENGER DRIVER SEAT SEAT PWR WDO CB POWER TAKEOFF (PTO) RELAY RADIO RADIO FUSE RAP 1 FUSE RAP 2 FUSE RAP 2 RELAY RDO AMP FUSE REAR DEFOGGER RELAY REAR WHEEL STEERING CONTROL MODULE RED WIRE REMOTE CONTROL DOOR LOCK RECEIVER RIGHT GENERATOR (W/ DUAL GENERATOR) RIGHT REAR WINDOW SWITCH ROOF THERMO BEACON CUPHOLDER SWITCH ASSEMBLY SEO 1 FUSE SEO 2 FUSE SIERRA DENALI STARTER SOLENOID STOP LPS FUSE ATC FUSE STOPLAMP TRANSFER SWITCH CASE SHIFT MODULE TBC FUSE TO ECM B FUSE (DIAGRAM 1 OF 4) TO FUSE BLOCK (MIR/LOCK FUSE) (DIAGRAM 4 OF 4) TO FUSIBLE LINK (DIAGRAM 3 OF 4) TO IGN 1 RELAY (DIAGRAM 3 OF 4) TO IGN A FUSE (DIAGRAM 2 OF 4) AUX PWR FUSE CIGAR FUSE TO PARK LAMPS FUSE (DIAGRAM 1 OF 4) TRANSFER CASE ENCODER MOTOR TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

5 6 PNK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCM B FUSE FUSE PNK 1 2 3 4 5 WIRE PNK 1 2 3 4 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE

3 4 PNK WIRE BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCM B FUSE FUSE PNK 1 2 3 4 5 WIRE PNK 1 2 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

4 5 PNK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCM B FUSE FUSE PNK 1 2 3 4 5 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (IN UNDERHOOD FUSE BLOCK) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE SBA FUSE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (IN UNDERHOOD FUSE BLOCK) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START KNOCK SENSOR 1 (UNDER INTAKE MANIFOLD) KNOCK SENSOR 2 (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE SBA FUSE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/RED WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM-B FUSE ENGINE COOLANT TEMPERATURE SENSOR (LEFT FRONT OF CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PNK WIRE PPL PPL PPL/WHT WIRE PRIMARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) RED WIRE SECONDARY FUEL PUMP RELAY SECONDARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/RED WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM-B FUSE ENGINE COOLANT TEMPERATURE SENSOR (LEFT FRONT OF CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PNK WIRE PPL PPL PPL/WHT WIRE PRIMARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) RED WIRE SECONDARY FUEL PUMP RELAY SECONDARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) TAN WIRE UNDER- HOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE

1 2 PNK WIRE ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (MIDDLE OF RIGHT CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY FUEL PUMP RELAY (SECONDARY) (DUAL TANKS) (ON UNDERHOOD FUSE BLOCK BRACKET) FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES HOT IN RUN, START INTERNAL MODE SWITCH KNOCK SENSOR (BANK 1) (LEFT SIDE OF ENGINE) KNOCK SENSOR (BANK 2) (ON RIGHT SIDE OF ENGINE) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PCM B FUSE PNK PNK 2 3 WIRE PNK PNK 27 28 WIRE PNK PNK 4 5 6 7 8 9 10 11 12 13 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL 31 32 33 34 35 36 37 PPL/BLK WIRE PPL/WHT WIRE RED/WHT WIRE SBA FUSE TAN WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE